The 2004 Ford F-450 Sd has 3 safety recalls and 33 owner complaints on file with NHTSA. The most-reported problem area is fuel system, diesel (14 complaints).
Problem: FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Risk: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Fix: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
NHTSA recall 07E066000 · Aug 28, 2007 · 175 vehicles
Problem: CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Risk: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Fix: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Electrical system › Wiring
NHTSA recall 05V270000 · Jun 10, 2005 · 180,104 vehicles · opened after NHTSA action (ODI)
Problem: CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Risk: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Fix: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Fuel system, diesel Storage › Tank assembly
14
0
0
0
80,500 mi
Engine and engine cooling Engine › Diesel; Engine › Other fuel types › Turbo/supercharger
7
0
0
0
27,200 mi
Power train Driveline › Differential unit
3
0
0
0
—
Electrical system Wiring › Front underhood
3
0
1
0
41,498 mi
Fuel system, other Fuel injection system
3
0
0
0
—
Service brakes, hydraulic Antilock/traction control/electronic limited slip
2
1
0
0
—
Fuel system, gasoline
2
0
0
0
—
Equipment Recreational vehicle/trailer › Lpg systems › Tank assembly; Recreational vehicle/trailer › Lpg systems
2
0
0
0
—
Vehicle speed control Accelerator pedal
1
0
0
0
—
Wheels Rim
1
0
0
0
—
Tires Tread/belt
1
0
0
0
—
Steering
1
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Dec 23, 2013 · 71,000 milesFuel system, gasoline TL* THE CONTACT OWNS A 2004 FORD F-450 SD. THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE FUEL TANK LINING HAD FAILED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 05V270000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 71,000.
Oct 17, 2013Fuel system, diesel 10/17/13 I WAS DRIVING ON THE INTERSTATE WITH A LOAD OF CATTLE RUNNING FINE AND JUST LOST POWER GOING ON THE INTERSTATE GOING FROM 65 TO 10 MILES AN HOUR. TRAFFIC ZIPPING BY. I THOUGHT IT WAS THE FUEL FILTERS BUT IT DONE THE SAME AFTER I CHANGED THEM. I TOOK IT TO A GARAGE AND HE SAID HE THE TANK LINER WAS COMING APART NOW IT MESSED UP MY INJECTORS, AND I THINK FORD SHOULD HAVE A RECALL ON SOMETHING LIKE THAT BEFORE SOMEONE GETS KILLED OR SEVERLY HURT!!!! IT IS IN THE SHOP NOW AND I THINK FORD SHOULD PAY SOMETHING ON THIS. *TR
Nov 1, 2012 · 59,000 milesPower train VEHICLE LOOSES POWER, NO ACCELERATION, OCCURS MOST FREQUENTLY UNDER HEAVY LOAD OR HIGH ACCELERATION DEMAND, TOLD BY FORD DEALER THE PROBLEM IS CAUSED BY DE-LAMINATING FUEL TANK RESULTING IN FUEL TANK COATING ENTERING THE FUEL SYSTEM AND OBSTRUCTING DIESEL FUEL FLOW TO MOTOR WHEN HIGH DEMAND FOR DUEL OCCURS. NEAR COLLISION AT FREEWAY SPEEDS AND WAS VERY DANGEROUS TO PULL OVER WHEN THERE WAS NO SHOULDER. FORD DEALER STATES THE COST TO REPAIR IS OVER $3,500.00 AND OPEN ENDED DEPENDING ON WHETHER THE FUEL TANK COATING ENTERED THE MOTOR OR INJECTORS. THEY WANT TO START BY REPLACING THE HARNESS, FUEL TANK AND FUEL PUMP AND GO FROM THERE. FORD REFUSES TO HONOR THIS CLEAR MANUFACTURING DEFECT. *TR
Jan 16, 2012 · 80,000 milesFuel system, diesel AT APPX. 80,000 MILES ON OUR 2004 F450 SD FUEL TANK DELAMINATED CAUSING FUEL SYSTEM FAILURE WHICH RESULTED IN SUDDEN LOSS OF POWER. WE HAVE ALWAYS PURCHASED HIGH QUALITY DIESEL FROM REPUTATABLE GAS STATIONS (CHEVRON, SHELL). VEHICLE REPAIRED AT FORD AND HAD CONTACTED FORD MOTOR COMPANY REGARDING REIMBURSEMENT OF COST AND WAS DECLINED. *TR
Jan 17, 2012 · 80,000 milesFuel system, gasoline TRUCK FAILS TO MAINTAIN SPEED (ACTS FUEL STARVED) AND IS AT RISK OF STALLING IN TRAFFIC. VEHICLE HAS BEEN MAINTAIN COMPLETELY AT FORD DEALERSHIP AND HAS HAD NO AFTERMARKET ADJUSTMENTS. AFTER TAKING THIS TRUCK TO THE FORD DEALER (PARR FORD IN BREMERTON, WA) WE HAVE BEEN NOTIFIED THAT THE FUEL TANK IS DELAMINATING AND CAUSING PARTICLES TO CLOG THE FUEL SYSTEM. AS WE HAUL A LARGE TRAILER WITH THIS VEHICLE (AS I'M SURE OTHER CONSUMERS DO AS WELL) THIS CAN RESULT IN A CATASTROPHIC OUTCOME AS STALLING RESULTS IN LACK OF STEERING ABILITIES AND CAN LEAVE VEHICLE VULNERABLE IN TRAFFIC. FORD NEEDS TO RECOGNIZE THIS ISSUE IMMEDIATELY AND CORRECT VEHICLES CURRENTLY ON THE ROAD AT THEIR COST. *TR
Mar 23, 2011 · 200,000 milesFuel system, diesel › Storage › Tank assembly TL* THE CONTACT OWNS A 2004 FORD F-450. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 55 MPH. THE CHECK ENGINE LIGHT ILLUMINATED AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE DEALER PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AS THE FUEL LINER DELAMINATING. THE DEALER REPLACED THE FUEL TANK AND THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 200,000. UPDATED 01/11/12
Jul 1, 2011Fuel system, diesel TL* THE CONTACT OWNS A 2004 F-450 SD. WHILE DRIVING, THE CONTACT STATED THAT THE VEHICLE WOULD LOOSE POWER AND WOULD STALL INTERMITTENTLY. THE DEALER DIAGNOSED THAT THERE WAS DELAMINATION FOUND IN THE FUEL TANK LINING, WHICH WAS FLAKING OFF AND CAUSING A LEAK IN THE FUEL FILTER AND FUEL PUMP. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 34,000.
May 2, 2011Fuel system, diesel › Storage › Tank assembly 2004 FORD F450 AMBULANCE. CONSUMER STATES DEFECTIVE OF THE FUEL TANK *TGW THE CONSUMER STATED AS A RESULT OF A SERIOUS STRUCTURAL DEFECT OF THE FUEL TANK, THE VEHICLE STALLED DURING SEVERAL EMERGENCY CALLS. THE COATING IN THE INTERIOR DIESEL FUEL TANK CORRODED AND COLLECTED AS SEDIMENT, WHICH EXTRACTED INTO THE FUEL SYSTEM. THE FUEL LINE BECAME CLOGGED AND DAMAGED THE FUEL PUMP AND VALVES. *JB UPDATED 03/01/12 *BF UPDATED 03/16/12 UPDATED 04/18/12
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
EA05003 · opened Feb 15, 2005 · closed Nov 2, 2005 · led to recall 05V270000ENGINE STALLING IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE…