*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Structure
The contact owns a 2012 Ford Transit Connect. The contact stated that while the vehicle was parked, the contact became aware that the front driverâs and front passengerâs seat belts were damp following a rainstorm. Upon inspection, the contact observed that the door seals on both front doors were allowing water to enter the vehicle, causing the seat belts to become damp. The vehicle was taken to a dealer; however, it was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 116,838.
Jan 8, 2026 · 116,838 milesElectrical system
1. The heat shielding around the exhaust system failed to protect the fuel tank from exhaust heat. Heat from the exhaust system melted holes in the fuel tank, causing fuel to leak from the tank. The parts are at the Ford dealer with the vehicle. 2. The fuel tank developed leaks when it melted, causing a risk of fire or explosion. 3. The dealer confirmed that the fuel tank melted and leaked due to heat from the exhaust system. In diagnosing the issue, they refilled the fuel tank and it continued to leak. 4. To my knowledge, the vehicle or components have not been inspected by the manufacturer, police, insurance representatives, or others. My insurance chose not to be involved since it does…
Mar 15, 2024Seat belts1 injury
The seat belt buckle/latch in the backseat is a dangerous defective design that can cause injury. It is available for inspection, see photos provided. Merely taking a seat can result in a bruised or broken coccyx. The car was parked when the incident occurred. No, the problem has not been reproduced by a dealer or independent service center. No, the component has not been inspected by the manufacturer, police, insurance reps or others. No, there are no warnings or messages. The danger is inherent in the design.
Oct 12, 2022Visibility
The contact's boyfriend owns a 2012 Ford Transit Connect. The contact stated that while her boyfriend was driving 25 MPH, the windshield wiper arms failed to operate. Upon investigation, the contact discovered NHTSA Campaign Number: 12V374000 (Visibility) which she linked to the failure. The dealer and the manufacturer were notified of the failure and informed her that the vehicle was not under recall. The vehicle was not repaired. The failure mileage was approximately 200,000.
Jul 3, 2022 · 200,000 milesTires
I noticed the 2 rear P205/65R15 (with approximately 4,500 mi) had a small dip in the sidewall. Typically evident of belt breaks or some other defect. About four weeks later, the front 2 p205/65R15 (with approximately 2,500 mi) also display this same dip in the sidewall. Iâve not had a problem with any 4 tires to date, all tires are still installed in my vehicle and available for inspection. I have not had these examined by a service center yet.
Apr 17, 2022Electronic stability control (esc)
COULD NOT DRIVE IN SLUSHY SNOW, VEHICLE SELF CUT POWER IN MIDDLE OF ROAD, THERE IS NO WAY TO DISABLE TRACTION CONTROL SO VEHICLE CAN SPIN TO GAIN FORWARD MOVEMENT. THIS SITUATION ALMOST CAUSED HEAD ON COLLISION WITH ONCOMING VEHICLE. I HAD TO KEEP BACKING UP TO TRY TO GAIN FORWARD MOTION. IF I HAD BEEN ABLE TO DISABLE TRACTION CONTROL SO THE VEHICLE COULD SPIN JUST A LITTLE, I WOULD HAVE HAD NO INCIDENT. THIS SITUATION IS VERY UNSAFE IN THE SNOWY CONDITIONS. IN READING ABOUT THIS, OTHER PEOPLE HAVE HAD THE SAME ISSUE. TO DISABLE THIS SYSTEM PEOPLE ARE PULLING THE FUSE ON THESE VEHICLES TO SOLVE THIS ISSUE. THIS IS VERY UNSAFE. FORD NEEDS TO INSTALL AN TEMPORARY INTERRUPT TO SOLVE THIS VERY…
Dec 29, 2019 · 92,000 milesVisibility/wiper
TL* THE CONTACT OWNS A 2012 FORD TRANSIT CONNECT. THE CONTACT STATED THAT THE WINDSHIELD WIPERS FAILED TO OPERATE. THE DRIVER'S VIEW WAS OBSTRUCTED WHILE DRIVING IN THE RAIN ON MORE THAN ONE OCCASION. LUTHER FAMILY FORD (3302 36TH STREET SOUTH, FARGO, NORTH DAKOTA 58104, (701) 282-2350) DIAGNOSED THAT THE RIVETS ON THE WIPERS WERE TOO SHORT AND THE PIVOT PIN WAS FAULTY. THE CONTACT STATED THAT THE RIVETS ON THE WINDSHIELD WIPERS WERE REPLACED, BUT THE FAILURE RECURRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 12V374000 (VISIBILITY) AS A POTENTIAL CAUSE OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.
Apr 15, 2018 · 110,000 milesVisibility › Defroster/defogger/hvac system › Rear window
TL* THE CONTACT OWNS A 2012 FORD TRANSIT CONNECT. THE CONTACT STATED THAT WHEN THE REAR DEFROSTER WAS ACTIVATED, THE REAR WINDOW FRACTURED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS REPAIRED BY SAFELITE AUTO GLASS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 67,000. 2ND TIME IT BROKE *TT
Feb 20, 2018 · 67,000 miles
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
