2001 Ford Windstar recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Suspension › Rear › Axle › Spindle

  The contact owns a 2001 Ford Windstar. The contact stated while driving 15 MPH, the rear axle fractured. There was no warning light was illuminated. The vehicle was towed back to the residence. The vehicle had been diagnosed by an independent mechanic. The contact was informed that the failure was due to a stress crack caused by excessive corrosion. The vehicle had not been repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 105,000.

  Nov 10, 2023 · 105,000 miles
• Structure

  The contact owns a 2001 Ford Windstar. The contact stated while driving at various speeds and depressing the brake pedal, the front end of the vehicle made abnormal sounds. The vehicle was taken to an independent mechanic, where it was diagnosed that there was a fracture due to corrosion on the front sub frame. The mechanic related the failure to NHTSA Campaign Number: 11V030000 (Structure). The vehicle was not repaired. The dealer was notified of the failure and informed the contact that the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 55,000.

  Jun 17, 2023 · 55,000 miles
• Suspension

  Rear axle cracked where bracket that was installed during previous recall. Van is not drivable and could have been a bad accident.

  Mar 26, 2023
• Structure › Body

  Rear axle cracked in multiple locations causes car to sway and tires to turn inward and bald

  Feb 9, 2023
• Suspension › Rear › Axle › Non-powered axle assembly

  The contact owns a 2001 Ford Windstar. The contact stated that while his son was driving at an undisclosed speed, the vehicle inadvertently came to a complete stop. Upon inspection, the contact noticed that the rear wheels were crooked and rubbing against the inner fender well. The vehicle was towed to the residence and then later to the dealer, where it was diagnosed that the rear axle was fractured. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 180,000. The contact noted that the failure speed was 55 mph. The axle was previously repaired due to the recall while the vehicle was under warranty. When the contact took the…

  Dec 1, 2022 · 180,000 miles
• Suspension

  The contact's girlfriend owns a 2001 Ford Windstar. The contact stated that the rear axle was previously replaced under NHTSA Campaign Number: 15V608000 (Suspension). The contact stated that while his girlfriend was driving approximately 10 MPH and making a left turn, a loud bang was heard from the rear of the vehicle. No warning lights were illuminated. The contact's girlfriend was able to veer to the side of the road and became aware that both the rear driver’s and passenger’s side tires were tilted inward, and the rear axle was fractured. The vehicle was towed to an independent mechanic, where it was diagnosed that the rear axle needed to be replaced. The vehicle remained with the…

  Jan 18, 2023 · 159,000 miles
• Suspension

  The contact owns a 2001 Ford Windstar. The contact stated while driving approximately 40 MPH and crossing railroad tracks that were flush with the road surface, the contact heard the passenger’s side rear tire making a loud screeching noise. The contact could hear rubbing or friction and then noticed that smoke was coming from the rear of the vehicle. The contact stated there was no warning light illuminated. The contact pulled off the road safely and inspected the vehicle and saw that the wheel was tilted into the wheel well and was rubbing the top and inside of the tire against the wheel well. The contact had the vehicle towed back to his residence. The vehicle was not taken to an…

  Nov 30, 2022 · 132,000 miles
• Structure

  The contact's husband owns a 2001 Ford Windstar. The contact stated that while in reverse, she heard an abnormal noise. No warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the control arm was cracked. The contact was then informed by the mechanic of the NHTSA Campaign Number: 11V03000 (Structure). The dealer was notified of the failure and the contact was informed that no recall was affiliated with the VIN. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.

  Nov 1, 2022 · 70,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• Front Subframe Corrosion FailuresClosedLed to recall 11V030000

  In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front…

  EA10007 · opened Dec 20, 2010 · closed Mar 17, 2011
• Front Subframe Corrosion FailuresClosedLed to recall 11V030000

  The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment…

  PE10026 · opened Jul 20, 2010 · closed Dec 20, 2010
• Rear Axle CrackingClosedLed to recall 10V385000

  In a letter dated August 26, 2010, Ford Motor Company (Ford) submitted a Defect Information Report notifying NHTSA that it will conduct a safety recall (NHTSA Recall No. 10V-385) to address a rear axle defect in model year (MY) 1998 through 2003 Ford Windstar vehicles built at the Oakville assembly plant from September 1, 1997 through February 28, 2003 and either sold or currently registered in high corrosion (Salt-Belt) states where the use of salt and other corrosive chemicals may be used to treat snow/ice covered roads.The following states are included in Ford's recall:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. The subject vehicles utilize a Stamped/Formed axle assembly…

  PE10016 · opened May 13, 2010 · closed Sep 22, 2010
• ENGINE COMPARTMENT FIRESClosedLed to recall 09V399000

  EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

  EA08021 · opened Sep 17, 2008 · closed Oct 14, 2009
• ENGINE COMPARTMENT FIRESClosed

  ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME)…

  PE08035 · opened May 13, 2008 · closed Sep 17, 2008
• FRONT SEAT BELT BUCKLE ASSEMBLYClosed

  DURING THE INITIAL RECALL CAMPAIGN IN 2001, THE SUBJECT VEHICLES WERE INSPECTED BY FORD DEALERSHIPS USING A TEST TOOL THAT WOULD DETECT A DEFECTIVE FRONT SEAT OUTBOARD SEAT BELT BUCKLE ASSEMBLY.APPROXIMATELY ONE MILLION VEHICLES PASSED THE INSPECTION TEST FOR ONE OR BOTH FRONT BUCKLES.SUBSEQUENT TO THE RECALL SERVICE ACTION, ODI RECEIVED 15 CONSUMER REPORTS ALLEGING THAT A PASSED INSPECTION BUCKLE SUBSEQUENTLY FAILED TO LATCH OR INADVERTENTLY UNLATCHED DURING USE.IN ADDITION, FORD HAS IDENTIFIED 543 OWNER AND FIELD REPORTS ALLEGING BUCKLE FAILURE SUBSEQUENT TO PASSING THE INSPECTION TEST.FORD TESTED AND EXAMINED OVER 100 WARRANTY-RETURNED BUCKLES AND FOUND THAT 44% OF THE BUCKLES HAD NO PROBLEM OR A CONDITION NOT RELATED TO THE RECALL INSPECTION (NON-LATCH RELATED BUCKLE DAMAGE OR FOREIGN CONTAMINATION).WARRANTY CLAIMS WERE HIGHEST DURING THE 18-MONTH PERIOD AFTER THE START OF THE…

  EA05004 · opened Feb 17, 2005 · closed Jul 6, 2005
• FRONT SEAT BELT BUCKLE ASSEMBLYClosed

  UNDER RECALL CAMPAIGN (01V227), FORD RECALLED APPROXIMATELY 1.3 MILLION VEHICLES TO INSPECT AND IF NECESSARY REPLACE THE FRONT DRIVER AND/OR PASSENGER SEAT BELT BUCKLE.APPROXIMATELY 1.1 MILLION OWNERS RESPONDED BY TAKING THEIR VEHICLES TO A DEALER FOR INSPECTION OF THE BUCKLE USING A SPECIALIZED BUCKLE TEST TOOL.FORD REPORTED THAT 829,927 VEHICLES HAD BOTH BUCKLES PASS THE TOOL TEST AND ANOTHER 167,336 VEHICLES HAD ONE BUCKLE PASS.ODI AND FORD RECEIVED COMPLAINTS ALLEGING SEAT BELT BUCKLE FAILURE SHORTLY AFTER PASSING THE ORIGINAL RECALL INSPECTION SERVICE.COMPLAINANTS ALLEGED THAT THE BUCKLE FAILED BY EITHER NOT LATCHING OR FALSE-LATCHING (PARTIAL ENGAGEMENT OF THE LATCH TO THE LATCH PLATE).A FALSE-LATCHED BUCKLE MAY RELEASE WITH MINOR MOVEMENT OR IMPACT AGAINST THE BUCKLE HOUSING INCLUDING INADVERTENT RELEASE WHILE THE VEHICLE IS IN MOTION.ODI IS UPGRADING THIS RECALL QUERY TO AN…

  RQ04011 · opened Oct 22, 2004 · closed Feb 17, 2005
• POWER SLIDING DOOR OPENINGClosed

  THE SUBJECT VEHICLES ARE EQUIPPED WITH SINGLE OR DUAL POWER SLIDING DOORS (PSD).APPROXIMATELY 111,000 VEHICLES HAVE DUAL POWER SLIDING DOORS.THE PSD IS OPENED BY ANY OF 5 METHODS, THE INSIDE OR OUTSIDE MANUAL DOOR HANDLE, THE KEY FOB, THE OVERHEAD CONSOLE SWITCH AND THE B-PILLAR SWITCH.THE DOOR MAY BE OPENED ONLY UNDER THESE CONDITIONS: IGNITION KEY IS IN OFF/ACCESSORIES/ON/START POSITION, GEAR SELECTOR IN PARK, VEHICLE SPEED LESS THAN 6 MPH, AND DOOR UNLOCKED.THE PSD LATCH IS LOCATED AT THE REAR OF THE DOOR AND HAS A SECONDARY AND PRIMARY LATCH POSITION.FULL AND PROPER CLOSURE ENGAGES BOTH THE SECONDARY AND PRIMARY LATCH.WITH THE IGNITION IN THE ON POSITION, AS THE GEAR SELECTOR IS MOVED OUT OF PARK THE DOOR AUTOMATICALLY LOCKS AND THAT ACTION MECHANICALLY ISOLATES THE LATCH, SECONDARY AND PRIMARY, FROM ALL LATCH RELEASE CONNECTIONS.IN ADDITION TO THE REPORTS ALLEGING DOOR OPENING…

  PE04022 · opened Mar 3, 2004 · closed Jul 1, 2004