The 1997 Hyundai Sonata has 2 safety recalls and 49 owner complaints on file with NHTSA. The most-reported problem area is fuel system, gasoline (18 complaints).
Recalls2safety recalls
Complaints49filed by owners
Crashes · fires5 · 1reported in complaints
Injuries · deaths3 · 1reported in complaints
1997 Hyundai Sonata in an NHTSA crash test
Safety recalls
Fuel system, gasoline › Storage › Tank assembly
NHTSA recall 00V314001 · Oct 2, 2000 · 66,086 vehicles
Problem: VEHICLE DESCRIPTION: ACCENT GT MODEL VEHICLES EQUIPPED WITH DOHC ENGINES MANUFACTURED FROM DECEMBER 19, 1996 THROUGH JUNE 30, 1997; 1998 ACCENT MODEL VEHICLES MANUFACTURED FROM MAY 6, 1997 THROUGH JUNE 25, 1998; 1997 SONATA VEHICLES MANUFACTURED FROM AUGUST 1, 1996 THROUGH JULY 9, 1997 AND 1998 SONATA VEHICLES PRODUCED FROM JULY 9, 1997 THROUGH APRIL 24, 1998. THE EVAPORATIVE EMISSION CONTROL SYSTEMS MAY APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. MINOR FUEL TANK DISTORTION COULD RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER COULD NOTICE A GASOLINE ODOR.
Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Fix: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF IT IS CRACKED, A NEW FUEL TANK WILL BE INSTALLED. A NEW FUEL FILLER CAP THAT DECREASES THE AMOUNT OF VACUUM INSIDE THE FUEL TANK WILL ALSO BE INSTALLED. NOTE: THE 1997-1998 SONATA FUEL TANKS HAVE ALSO EXPERIENCED CRACKING. HOWEVER, AT THIS TIME, THE CAUSE FOR THE CRACKING HAS NOT BEEN IDENTIFIED. THIS PORTION OF THE CAMPAIGN WILL BEGIN AFTER HYUNDAI HAS DETERMINED THE CAUSE AND CORRECTIVE PROCEDURE.
Visibility › Windshield wiper/washer › Motor
NHTSA recall 97V026000 · Feb 26, 1997 · 74,965 vehicles · opened after NHTSA action (ODI)
Problem: THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER ELECTRICAL CONTACTS WERE CONTAMINATED DURING ASSEMBLY.
Risk: THIS CONTAMINATION INTERFERES WITH THE ELECTRICAL CIRCUIT CONTINUITY AND PREVENTS THE WINDSHIELD WIPER MOTOR FROM OPERATING. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL REMOVE THE CONTAMINANTS FROM THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER CONTACTS.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
1997 Hyundai Sonata 4-DR.
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
Not Rated
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
Sonata
21mpg combined
City / highway
19 / 26 mpg
Fuel
Regular Gasoline
2 L · 4 cyl · Manual 5-spd · Front-Wheel Drive · about $3,200/year to fuel
Sonata
20mpg combined
City / highway
18 / 25 mpg
Fuel
Regular Gasoline
2 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,350/year to fuel
Sonata
18mpg combined
City / highway
16 / 22 mpg
Fuel
Regular Gasoline
3 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,700/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Fuel system, gasoline Storage › Tank assembly; Storage › Tank assembly › Filler pipe and cap
18
0
0
0
108,000 mi
Power train Automatic transmission; Automatic transmission › Gear position indication (prndl)
11
0
0
0
—
Air bags Frontal
9
5
0
3
—
Engine and engine cooling Engine › Gasoline; Engine
9
0
0
0
—
Electrical system Ignition; Wiring › Interior/under dash
5
0
1
0
—
Visibility Power window devices and controls; Windshield wiper/washer › Motor
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
May 2, 2014 · 64,000 milesVisibility FAILURE/BREAKAGE OF PASSENGER SIDE SUN VISOR AS ADDRESSED IN HYUNDAI TSB 09-01-003 NHTSA ID:10028945 RESULTING IN VISOR BEING UNABLE TO STAY IN POSITION BLOCKING VISIBILITY. *TR
May 1, 2010 · 108,000 milesElectrical system AFTER ATTEMPTING TO CALL HYUNDAI, I AM ABSOLUTELY FED UP WITH EVERYTHING THEY ARE DOING. I HAVE "REPAIRED" MY VEHICLE ON NUMEROUS OCCASIONS TO NO AVAIL. AFTER AT LEAST 5, DEFINITELY MORE, TRIPS TO THE MECHANIC I HAVE REPAIRED THE ALTERNATOR TWICE, THE IDLE AIR CONTROL VALVE, BRAKES, MOTOR MOUNTS, DONE A TRANSMISSION FLUID CHANGE, AND HAVE HAD TO REPAIR 2 FLYWHEELS IN THE TRANSMISSION. THAT LIST DOES NOT INCLUDE THE GENERAL MAINTENANCE OF PLUGS, FILTERS, AND OIL. I CAN'T DEAL WITH THIS ANYMORE. THIS IS NOT ACTUALLY MY VEHICLE, THIS IS MY MOTHERS VEHICLE, BUT REGARDLESS OF WHO'S VEHICLE IT IS, THIS IS NOT ACCEPTABLE. WHAT IT BASICALLY IS DOING IS WHEN IT REACHES A CERTAIN MILEAGE IT WILL…
Jun 30, 2005Fuel system, gasoline › Storage › Tank assembly 1997 HYUNDAI SONATA HAS DEFECTIVE FUEL TANK. LEAKING GAS FROM THE UPPER PART OF ON THE FUEL TANK. THERE WAS A RECALL ON THE TANK IN THE YEAR 2001..AND MY CAR WAS FIXED, HOWEVER IT HAS REOCCURED (SAME PROBLEM). I TOOK TO DEALER AND THEY WOULD NOT HONOR THE RECALL, DUE TO THE FACT IT HAD ALREADY BEEN DONE. I ALSO CALLED THE MANUFACTUROR AND THEY WOULD ALSO NOT HONOR. THERE IS ALSO A DEFECT IN THE DOOR LOCK, NOT ALLOWING THE DOOR TO EVEN OPEN.
May 29, 2005 · 148,000 milesFuel system, gasoline › Storage › Tank assembly RECALL # 00V314001 1997 HYUNDAI SONATA I HAD CALLED DEALER TO ASK OF RECALL THEY HAD INFORMED ME THAT THIS VEHICLE HAS BEEN SERVICED FOR THIS PROBLEM THREE TIMES. AND THEY HAD SAID THAT IT IS OUT OF WARRANTY AND THEY WILL NOT REPAIR. MY QUESTION IS ARE THEY STILL RESPONSIBLE FOR THE DEFECT THAT HAS BEEN REPAIRED THREE TIMES. I AM LEAVING THE VIN # ALSO [XXX] PLEASE HELP THANKS. *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mar 6, 2005 · 86,000 milesLatches/locks/linkages › Doors › Latch THE POWER LOCKS ARE DEFECTIVE, WHEN PLACING THE KEY INTO THE LOCK THE PASSENGER LOCK WOULD NOT OPEN, WHEN THE CONSUMER WAS INSIDE THE VEHICLE ,THE LOCKING DEVICE WOULD NOT LIFT.
Nov 12, 2003 · 128,000 milesFuel system, gasoline › Storage › Tank assembly RECALL 001V314001 CONCERNING FUEL TANK. AFTER HAVING RECALL REPAIRS DONE CONSUMER SMELLED GASOLINE ODORS, AND CHECK ENGINE LIGHT ILLUMINATED WHILE DRIVING. VEHICLE WAS REPAIRED ON FIVE SEPARATE TIMES BY THE DEALER, BUT PROBLEM RECURRED. CONSUMER COMPLAINED THAT THE DEALER WANTED TO CHARGE FOR THE NEXT REPAIRS. *AK
Jul 10, 2004 · 25,000 milesFuel system, gasoline › Storage › Tank assembly RECALL 00V314001 CONCERNING FUEL TANK. AFTER REFILLING THE FUEL TANK CONSUMER SMELLED STRONG GASOLINE ODOR. CONTACTED THE DEALER CONCERNING THIS RECALL. DEALER INFORMED CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK
Dec 1, 1999 · 33,116 milesFuel system, gasoline › Storage › Tank assembly RECALL REGARDING GAS TANK PROBLEM.*MR WHILE DRIVING THE CONSUMER HIT A POTHOLE IN THE ROAD. SHORTLY AFTER ALL THE FUEL IN THE FUEL TANK LEAKED OUT. THE DEALER DID NOT SAVE THE TANK OR INSPECT IT FURTHER BECAUSE THE CONSUMER HIT A POTHOLE. SOMETIME IN 2001 THE CONSUMER RECEIVED A RECALL (00V-314001) REGARDING A GAS TANK PROBLEM. THE VEHICLE WAS TAKEN TO A DEALER AND THE RECALL WORK WAS DONE. *NM
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
