Model year record

1999 Hyundai Sonata recalls & problems

The 1999 Hyundai Sonata has 4 safety recalls and 124 owner complaints on file with NHTSA. The most-reported problem area is structure (37 complaints).

Recalls4safety recalls

Complaints124filed by owners

Crashes · fires12 · 3reported in complaints

Injuries · deaths23 · 0reported in complaints

Safety recalls

SuspensionApr 16, 2009

Suspension

Recall 09V124000188,282 vehiclesopened after NHTSA action (ODI)

Problem: HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUB-FRAME ON THE VEHICLES, AND MAY RESULT IN THINNING OR PERFORATION OF THE SUB-FRAME STEEL. THE CORROSION IS FREQUENTLY VISIBLE AND OFTEN DISCOVERED DURING INSPECTION OR ROUTINE MAINTENANCE, AND OWNERS MAY ALSO HEAR NOISES OR NOTICE TIRE MISALIGNMENT AND STEERING PULL. IF THESE SIGNALS ARE UNDETECTED OR UNHEEDED, THE CORROSION MAY PROGRESS AND THE FORWARD MOUNTING OF THE LOWER CONTROL ARM MAY DETACH FROM THE SUB-FRAME.
Risk: IF THAT HAPPENS, THE VEHICLE MAY LOSE DRIVE POWER TO THE WHEELS, AND THE FRONT WHEEL MAY MAKE CONTACT WITH THE FENDER OR WHEEL WELL, THEREBY INCREASING THE RISK OF A CRASH.
Fix: DEALERS WILL MEASURE THE THICKNESS OF THE FRONT SUB-FRAME AND INSPECT THE FRONT SUB-FRAME FOR CORROSION DAMAGE AND, IF NECESSARY, THE FRONT SUB-FRAME WILL BE REPLACED WITH A NEW SUB-FRAME THAT INCORPORATES ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT SUB-FRAME DOES NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE SUB-FRAME AND WILL TREAT THE SUB-FRAME WITH RUST-PROOFING MATERIAL TO STOP THE CORROSION PROCESS. THIS PROCEDURE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

Air bagsApr 9, 2002

Side/window

Recall 02V105000145,355 vehicles

Problem: ON CERTAIN PASSENGER VEHICLES, AN INTERMITTENT CONDITION THAT LEADS TO THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT ILLUMINATION COULD RESULT FROM MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR WHICH MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE SIDE IMPACT AIR BAGS AND COULD PREVENT AIR BAG DEPLOYMENT DURING A CRASH WHERE SUCH DEPLOYMENT SHOULD OCCUR.
Risk: NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAG COULD INCREASE THE RISK OF INJURY DURING A SIDE IMPACT CRASH.
Fix: DEALERS WILL MORE SECURELY FASTEN THE SIDE IMPACT AIR BAG WIRING HARNESSES AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION BEGAN MAY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

Air bagsNov 6, 2001

Air bags

Recall 01V34700086,513 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT COULD ILLUMINATE DUE TO MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR THAT MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE DRIVER AND/OR PASSENGER SEAT-MOUNTED SIDE IMPACT AIR BAG(S).
Risk: THIS CONDITION COULD PREVENT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT DURING AN ACCIDENT WHERE SUCH DEPLOYMENT SHOULD OCCUR. NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAGS COULD INCREASE THE RISK OF INJURY DURING AN ACCIDENT WHERE SIDE IMPACT AIR BAG DEPLOYMENT IS INTENDED.
Fix: DEALERS WILL MORE SECURELY FASTEN THE FRONT SEAT SIDE IMPACT AIR BAG WIRING HARNESS AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION WILL OCCUR IN SIX MAILINGS ON MAY 27, JUNE 3, JUNE 10, JUNE 17, JUNE 24, AND JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

Electrical systemSep 11, 2000

Wiring

Recall 00V259001165,977 vehicles

Problem: VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS.
Risk: THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH.
Fix: DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

Sonata

22mpg combined

City / highway	19 / 27 mpg
Fuel	Regular Gasoline

2.4 L · 4 cyl · Manual 5-spd · Front-Wheel Drive · about $3,050/year to fuel

Sonata

21mpg combined

City / highway	18 / 26 mpg
Fuel	Regular Gasoline

2.4 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel

Sonata

21mpg combined

City / highway	18 / 26 mpg
Fuel	Regular Gasoline

2.5 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel

Sonata

21mpg combined

City / highway	18 / 26 mpg
Fuel	Regular Gasoline

2.5 L · 6 cyl · Manual 5-spd · Front-Wheel Drive · about $3,200/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
StructureFrame and members; Frame and members › Underbody shields	37	2	0	3	105,000 mi
Air bagsFrontal; Frontal › Sensor/control module	31	10	0	20	59,750 mi
Engine and engine coolingEngine › Gasoline; Engine	23	3	1	4	89,000 mi
SuspensionFront; Front › Wheel bearing	17	0	0	0	123,184 mi
Electrical systemWiring; Wiring › Interior/under dash	15	1	2	1	70,000 mi
Power trainAutomatic transmission; Clutch assembly › Pedal/hand lever(motorcycle)	14	1	0	1	71,313 mi
Seat beltsFront › Anchorage; Front › Buckle assembly	8	1	1	0	—
VisibilityWindshield wiper/washer; Sun/moon roof assembly	7	3	0	3	49,961 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Power assist	6	1	0	0	—
TiresTread/belt	6	1	0	0	51,433 mi
SteeringColumn	6	1	0	2	104,500 mi
Unknown or other	5	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Suspension
I WAS DRIVING HOME FROM WORK ON JAN 30TH, 2015 AND THE CAR STARTED PULLING TO THE RIGHT. THE NEXT DAY, SAT THE 31ST, I JACKED UP THE RIGHT FRONT OF THE CAR TO SEE WHY THE CAR STEERED TO THE RIGHT. I FOUND THE LOWER WHEEL ASSEMBLY ATTACHMENT TO THE FRAME HAD COME LOOSE. THAT WAS BECAUSE THE FRAME HAD THREE OF FOUR SIDES RUSTED THRU. THE CONDITION COULD HAVE CAUSED A MORE SEVERE ACCIDENT IF THE ATTACHMENT TO THE FRAME HAD PULLED COMPLETELY APART. I WILL CHECK WITH HYUNDAI TO SEE WHAT THEY CAN DO ABOUT IT. THANKS FOR LISTENING. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Jan 30, 2015 · 114,000 miles
Structure › Body
AFTER REMOVING THE DRIVERS FRONT WHEEL I NOTICED THE CONTROL ARM ATTACHMENT POINT SEVERELY RUSTED, & THE SUB FRAME CRACKED READY TO BREAK. I KNOW ABOUT THE RECALL. UNFORTUNATELY NEBRASKA ALONG WITH OTHER STATES WERE NOT INCLUDED. THIS CAR WAS WELL MAINTAINED BY THE ORIGINAL OWNER, & DRIVEN VERY LITTLE IN SALT/ SNOW CONDITIONS. SHE PURCHASED @ APPROX. 80 YEARS OF AGE. NHTSA SHOULD TAKE A LOOK AT THIS AGAIN. WATER BEING TRAPPED IN THE SUB FRAMES IS THE REAL PROBLEM, SALT MAY HAVE ONLY MADE THE FAILURE HAPPENED A BIT SOONER. I HAVE TALKED WITH HYUNDAI CUSTOMER ASSISTANCE, & WAS TOLD THE CAR WOULD NOT BE COVERED BY THE RECALL. I LIVE 8 MILES AWAY FROM IOWA, WHICH IS COVERED BY THE RECALL. OMAHA…
Mar 19, 2014 · 75,800 miles
Air bagsCrash1 injury
L WAS STOPPED ON TRAFFIC ON HIGH WAY ,AND SOME ONE, HIT ME ON THE BACK ,THE GUY WAS SO FAST PROBLEM MORE THAN 75 MPH ,THAN MY CAR FLOAT 20 FOOT ,AND HIT THE CAR ON MY FRONT AND MY AIR BAGS DID NOT DEPLOY OR OPEN , SO THE QUESTION IS HYUNDAI SONATA 1999 USUALLY HAVE THIS PROBLEM , ???? *TR
Jan 4, 2014 · 123,000 miles
Structure › Frame and members › Underbody shields
THE SUB FRAME/K FRAME ON MY 99 HYUNDAI SONATA RUSTED OUT CAUSING MY DRIVER SIDE REAR TIRE AND PASSENGER SIDE REAR TIRE TO FACE OUTWARDS ALMOST COMING OFF AND DAMAGING MY LEFT CONTROL ARM. I HEARD A LOUD POP AND COULDN'T FIGURE OUT WHAT IT WAS THEN REALIZED THE STEERING WHEEL WAS COCKED AT 180. I HAD TO DRIVE IT HOME WHICH WAS LUCKILY ONLY 2 MINUTES DOWN THE ROAD, I HAD TO DRIVE 10MPH SMELLING BURNING RUBBER. *TR
Nov 1, 2013 · 213,627 miles
Structure › Frame and members › Underbody shields
I WAS PULLING IN A SHOPPING CENTER TURNING THE STEERING WHEEL TO THE RIGHT, I HEARD A LOUD BANG AND GOT OUT OF CAR, THE DRIVERS SIDE WHEEL WAS CAVED IN, HAD CAR TOWED TO MECHANIC, HE SAID THE SUBFRAME WAS COMPLETELY RUSTED AND BROKE AWAY FROM THE CAR, AND I WAS LUCKY THAT I WASN'T GOING AT A HIGHER SPEED. *TR
Aug 5, 2013 · 165,000 miles
Suspension
TL* THE CONTACT OWNS A 1999 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, HE HEARD NOISES AND NOTICED THAT THE TIRE WAS MISALIGNED CAUSING THE STEERING WHEEL PULLING ABNORMALLY. THE VEHICLE WAS TAKEN TO THE MECHANIC AND AFTER INSPECTION, THEY FOUND THAT THE FRONT SUB-FRAME WAS RUSTED AND CORRODED. THERE WERE ALSO HOLES NEXT TO THE BOLTS THAT HELD THE SUB FRAME IN PLACE. THE DEALER WAS NOTIFIED WHO ADVISED THE CONTAC THAT THERE WAS A RECALL FOR THE FAILURE BUT HIS VIN WAS NOT INCLUDED (NHTSA CAMPAIGN ID NUMBER: 09V124000: SUSPENSION). THE MANUFACTURER WAS NOTIFIED WHO CONFIRMED THAT THE CONTACT'S VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE…
Nov 3, 2012 · 157,000 miles
Suspension
TL* THE CONTACT OWNS A 1999 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE WAS BEING EXAMINED BY AN INDEPENDENT REPAIR SHOP AND SHE WAS INFORMED THAT THE FRONT SUB-FRAME WAS CORRODED. THE MANUFACTURER WAS THEN NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V124000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 125,764.
May 22, 2012 · 125,764 miles
Suspension
I PURCHASED MY 1999 SONATA FROM A USED CAR DEALER & HAVE HAD NUMEROUS PROBLEMS WITH THE CAR, ITS BEEN A NIGHTMARE, ONE PROBLEM AFTER ANOTHER!!!! THE CRANKSHAFT SENSOR HAD TO BE COMPLETELY REPLACED BECAUSE THE COMPONENT HAD SEVERELY MELTED, ISSUES WITH THE TRANSMISSION, ABS/AIRBAG WARNING LIGHT ON, & HAVE HAD TO CHANGE OUT THE HALF SHAFT ON BOTH DRIVERS/PASSENGER SIDE, NUMEROUS TIRES, BRAKES BUT THE MOST SEVERE OF ALL THE PROBLEMS WHICH PUTS MY SAFETY, MY 12 YR OLD SON & FIANCE'S SAFETY, ALONG WITH FAMILY/FRIEND'S SAFETY AT RISK IS THE COMPLETE CORROSION OF THE SUBFRAME I TOO TO A MECHANIC TODAY & HE TOLD ME TO NOT DRIVE THIS CAR FOR ANYTHING BECAUSE IT WILL RESULT IN AN ACCIDENT WHERE I CAN…
Oct 1, 2009 · 52,500 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

FRONT SUB-FRAME CORROSIONClosedLed to recall 09V124000
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT HYUNDAIIS CONDUCTING A SAFETY RECALL OF MODEL YEAR (MY) 1999 THROUGH 2004 HYUNDAI SONATA VEHICLES MANUFACTURED PRIOR TO NOVEMBER 20, 2003 THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO REMEDY A CONDITION WHERE INTERNAL CORROSION OF THE FRONT SUBFRAME MAY LEAD TO SEPARATION OF THE LOWER CONTROL ARM AT THE FORWARD MOUNTING POINT AND/OR SEPARATION OF THE AXLE FROM THE TRANSAXLE.THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL AND/OR VEHICLE DISABLEMENT. THE SUBFRAMES WILL BE INSPECTED…
EA08016 · opened Aug 21, 2008 · closed Apr 20, 2009
FRONT SUB-FRAME CORROSIONClosed
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE08-029, ON APRIL 22, 2008, BASED ON 40 CONSUMER COMPLAINTS ALLEGING FRONT SUB-FRAME CORROSION IN MODEL YEAR (MY) 1999 THROUGH 2002 HYUNDAI SONATA VEHICLES.COMPLAINTS DESCRIBE SEVERE CORROSION OF THE VEHICLE SUB-FRAME IN THE AREA WHERE THE RIGHT-FRONT LOWER CONTROL ARM IS ATTACHED.IN SOME VEHICLES, SUB-FRAME CORROSION HAS CAUSED COMPLETE OR PARTIAL DETACHMENT OF THE CONTROL ARM, RESULTING IN WHEEL COLLAPSE OR SEPARATION. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER FOR PE08-029, HYUNDAI PROVIDED OWNER COMPLAINTS, FIELD REPORTS, AND WARRANTY CLAIM DATA FOR APPROXIMATELY 197,906 MY 1999 THROUGH 2002 SUBJECT VEHICLES SOLD OR LEASED IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 60 MONTHS OR 60,000 MILES, WHICHEVER OCCURS FIRST.ACCORDING TO HYUNDAI, PROLONGED EXPOSURE TO THE ROAD SALTS MAY…
PE08029 · opened Apr 22, 2008 · closed Aug 21, 2008
IMPROPER FRONTAL AIR BAG PERFORMANCEClosed
HYUNDAI HAS RECEIVED 49 REPORTS FROM CUSTOMERS STATING THE FRONTAL AIR BAGS DID NOT DEPLOY IN A CRASH FOR THE SUBJECT VEHICLES.EXAMINATION OF SUPLIMENTAL INFORMATION PROVIDED TO ODI BY THE MANUFACTURER FOR THE REPORTED CASES IT APPEARED THAT THE NECESSARY AIR BAG DEPLOYMENT THRESHOLD WAS NOT MET.THERE HAVE BEEN NO FATAL INCIDENTS OR REPORTS OF SERIOUS INJURY AS A RESULT OF BEING IN A FRONTAL CRASH AND THE AIR BAGS NOT DEPLOYING.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI?S RESPONSE TO THE PETITIONER…
DP03001 · opened Mar 26, 2003 · closed Aug 1, 2003