Model year record

2004 Mazda Mazda3 recalls & problems

The 2004 Mazda Mazda3 has 3 safety recalls and 145 owner complaints on file with NHTSA. The most-reported problem area is air bags (30 complaints).

Recalls3safety recalls

Complaints145filed by owners

Crashes · fires18 · 2reported in complaints

Injuries · deaths14 · 0reported in complaints

2004 Mazda Mazda3 in an NHTSA crash test — NHTSA crash test

Safety recalls

Air bagsJul 1, 2021

Frontal

Recall 21V494000260,915 vehicles

Problem: Mazda North American Operations (Mazda) is recalling certain 2004-2007 Mazda3 vehicles. During air bag deployment, the plastic emblem on the steering wheel air bag module cover may shatter, and project plastic fragments into the vehicle.
Risk: Plastic fragments can hit occupants during air bag deployment, increasing the risk of injury.
Fix: Dealers will replace the air bag module cover, free of charge. Owner letters were mailed between August 28, 2021 and October 28, 2021. Owners may contact Mazda customer service at 1-800-222-5500 Option 4. Mazda's number for this recall is 4921G.

EquipmentApr 2, 2009

Equipment

Recall 09E0110002,323 vehicles

Problem: THULE, INC. IS RECALLING 2,323 OWNER-INSTALLED ROOF-MOUNTED FIT KITS, MODELS 3068 AND 3069, MANUFACTURED BETWEEN JANUARY 1, 2008 AND FEBRUARY 28, 2009 THAT ARE USED WITH THULE PODIUM FOOT PACKS, MODELS 460 AND 460R. THESE FIT KITS WERE SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE BOLT(S) USED TO SECURE THE FOOT TO THE VEHICLE WAS MANUFACTURED TO A HARDNESS THAT MAY CAUSE THE BOLT(S) TO BE BRITTLE AND POTENTIALLY BREAK UNDER STRESS.
Risk: THIS MAY RESULT IN THE BOLT(S) SNAPPING OFF DURING USE OR WITHOUT A LOAD. THE UNSECURED RACK AND LOAD CAN THEN COME LOOSE WHILE DRIVING CREATING A POTENTIAL ROAD HAZARD, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: THULE WILL MAIL A RETRO FIT KIT ALONG WITH REPAIR INSTRUCTIONS TO OWNERS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 13, 2009. OWNERS MAY CONTACT THULE TOLL-FREE AT 1-800-238-2388.

Air bagsSep 24, 2004

Frontal › Sensor/control module-inactive

Recall 04V46800042,000 vehicles

Problem: ON CERTAIN PASSENGER VEHICLES, A CRACK IN THE AIR BAG CRASH ZONE SENSOR HOUSING CAN ALLOW WATER TO ENTER THE SENSOR, CAUSING A SHORT CIRCUIT AND ILLUMINATING THE AIR BAG WARNING LIGHT.
Risk: IF THIS PROBLEM EXISTS, THE AIR WILL NOT DEPLOY AS DESIGNED IN CERTAIN TYPES OF FRONTAL CRASHES, INCREASING THE RISK OF DEATH OR SERIOUS INJURY TO THE DRIVER AND FRONT SEAT PASSENGER.
Fix: DEALERS WILL INSPECT THE CRASH ZONE SENSOR AND REPLACE IT, IF NECESSARY. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2004 Mazda3 4-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

2004 Mazda Mazda3 NHTSA side crash test — NHTSA side barrier crash test

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Air bagsFrontal › Sensor/control module; Frontal	30	16	0	20	78,500 mi
Service brakes, hydraulicFoundation components › Disc › Pads; Foundation components › Disc › Rotor	30	1	0	0	12,000 mi
Power trainAutomatic transmission; Manual transmission	24	0	1	0	38,000 mi
SteeringLinkages; Column	19	1	0	2	81,000 mi
Engine and engine coolingEngine; Cooling system	18	2	1	1	54,826 mi
TiresSidewall; Bead	9	2	0	1	12,200 mi
StructureBody; Body › Door	8	1	0	0	115,000 mi
Exterior lightingHeadlights	8	0	0	0	120,000 mi
Electrical systemIgnition	8	0	1	0	93,500 mi
EquipmentAppliance › Air conditioner	5	0	0	0	—
Engine	4	0	1	0	77,825 mi
Fuel system, gasolineDelivery › Fuel pump	3	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Exterior lighting
This model car has a fuse box under the glove box known as a "passenger junction box" that has a faulty or defective relay soldered onto the circuit board. The relay is tied to lighting that includes the interior lights, exterior front parking lights, exterior rear tail lights, and the license plate light and is controlled by the left turn signal stalk (rotating switch). Based on my experience and many others (on the Mazda 3 forums), this relay has the tendency to fail and cause all of these lights tied to this relay to intermittently or permanently be disabled. There is no warning for this; the driver will only notice when driving at night that the interior illumination of the dashboard…
Aug 1, 2021
TiresCrash1 injury
The contact owns a 2004 Mazda 3 equipped with Hankook Tires, Tire Line: Ventus S1 Noble2, Tire Size: 205/50/R17, DOT Number: N/A. The contact stated that while driving at approximately 45 MPH, a loud explosion was heard. The contact's wife alerted him that the rear driver's side tire had blown out. The contact's vehicle was then rear-ended by another vehicle, causing his vehicle to turn 360 degrees. The air bags did not deploy. The contact was not injured, but his wife suffered from neck pain. Medical attention was not received. A police report was filed. The vehicle was towed to the contact's workplace and was not deemed totaled by the insurance company. A body shop repaired the vehicle.…
Apr 1, 2023 · 150,000 miles
Structure › Body
There has been no accident- the vehicle is my mother in laws vehicle- my concern is while at work she has at times loaded our daughter into the vehicle- I inspected the vehicle one day while as an employee of Les Schwab- the driver cvc axle vibrates so bad from the boot being torn and having no lubrication- these axles power the vehicle forward and if not maintained can snap and cause damage- the wipers no longer work correctly- the tires are 2017 and old and weather cracked- potential to separate while driving or blow out on the heated pavement. upon inspection also found that the front shocks are blown out and bouncing in the mounts under the hood- causing the tires to not have the…
Aug 13, 2023
Air bags
The contact owns a 2004 Mazda Mazda3. The contact stated that while starting the vehicle and driving at an undisclosed speed, the air bag warning light was illuminated. The dealer was made aware of the failure but informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in a recall. The contact related the failure to NHTSA Campaign Number: 04V468000 (Air Bags). The failure mileage was approximately 165,000.
Oct 28, 2016 · 165,000 miles
Engine
THE CAR RAN GREAT FOR THE END OF 2019. I BOUGHT IT USED AT 145,000 MILES. THEN THE AUTOMATIC TRANSMISSION STARTED TO SLIP. NOW ITS STUCK IN LIMP MODE.
Jan 1, 2020 · 45 miles
Exterior lighting
THE TAIL LIGHTS GO OUT INTERMITTENTLY DUE TO A DEFECTIVE PASSENGER JUNCTION BOX (FUSE BOX). TAPPING THE BOX WITH A SCREWDRIVER HANDLE WILL BRING THE TAIL LIGHTS BACK ON FOR A WHILE. THIS HAS BEEN A MAZDA 3 ISSUE OVER THE YEARS. THE SHOULD BE A RECALL ON THIS.
Aug 7, 2018 · 204,000 miles
Air bags
TL* THE CONTACT OWNS A 2004 MAZDA 3. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT PASSENGER SEAT MAIN MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. AN UNKNOWN DEALER WAS CONTACTED, BUT COULD NOT ASSIST. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,680.
May 1, 2018 · 128,680 miles
Steering
THE LOCK RELEASE LEVER ON THE STEERING WHEEL GET LOOSE WHILE THE VEHICLE IS IN MOTION AND DOES NOT LOCKED IN PLACE. THIS CAN CAUSE AN ACCIDENT AND SERIOUS INJURIES. THERE SHOULD BE A RECALL TO GET THIS REPAIR.
Jan 8, 2013

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.