1994 Subaru Legacy recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Service brakes

  A FEW MONTHS AGO, MY SON WAS DRIVING MY OLDER SUBARU AND SAID THE BRAKES WENT DOWN TO THE FLOOR WHEN HE APPLIED THEM NOT FAR FROM HOME. HE PUMPED THEM AND SLOW CREPT HOME WITH THE CAR. I FOUND A RUSTED OUT LEAK AT THE REAR PASSENGER SIDE CONNECTION LOCATION NEAR THE FRAME ON THE SIDE OF THE GAS TANK. I JUST SAW THERE WERE A NUMBER OF RECALLS FOR THIS EXACT SAME PROBLEM. I HAVE NEVER RECEIVED OR SAW ONE BEFORE. ARE THEY STILL VALATE? WHOM DO I CONTACT FOR SERVICE IF SO? MY SON WAS JUST LUCKY HE WASN'T ON A HIGHWAY!

  Sep 4, 2020 · 123,567 miles
• Seat belts

  THE RETRACTABLE MECHANIZED SHOULDER HARNESS DOES NOT WORK.

  Aug 22, 2013 · 193,000 miles
• Engine and engine cooling › Engine

  I WILL BE ACCELERATING AT ANY MPH AND THE CAR WILL SUDDENLY TURN ITSELF OFF. THE BATTERY IS STILL POWERING THE CAR (RADIO PLAYING, LIGHTS ON), BUT THE ENGINE WILL BE COMPLETELY STOPPED. STEERING AND BRAKES WILL BOTH LOCK AND REQUIRE MUSCLING IN ORDER TO GET TO THE ROADSIDE AND STOP THE CAR. THIS HAS OCCURRED 4 TIMES SINCE THE DATE GIVEN (6/09). THE FIRST TIME WAS ON THE INTERSTATE AND WAS A VERY CLOSE CALL. *TR

  Jun 19, 2009 · 173,000 miles
• Power train › Automatic transmission

  1994 SUBARU LEGACY TRANSMISSION WILL NOT SHIFT OUT OF 1ST GEAR. AFTER CAR WARMS UP, WITHIN A SHORT DISTANCE THE TRANSMISSION FAILS ALTOGETHER AND THE CAR WILL NOT MOVE. AFTER A COOLING OFF PERIOD, THE CAR WILL PROCEED FOR A SHORT DURATION. THIS IS APPARENTLY A COMMON ISSUE DUE TO DESIGN DEFICIENCIES CAUSING AN OVER HEATING AND COMPONENT FAILURE. IT IS NOT CORRECTED YET. *TR

  Sep 1, 2008 · 159,470 miles
• Fuel system, gasoline

  FUEL PUMP WIRING SHORTED OUT IN THE GAS TANK. *TR

  Aug 18, 2008 · 160,000 miles
• Electrical system › Instrument cluster/panel

  TL*THE CONTACT OWNS A 1994 SUBARU LEGACY. THE CONTACT STATED THAT THE ODOMETER STOPPED WORKING FOR APPROXIMATELY ONE YEAR. THE VEHICLE WAS ALSO LEAKING EXHAUST FUMES, WHICH CAUSED HER TO HAVE HEADACHES. WHILE DRIVING APPROXIMATELY 25 MPH IN DRY WEATHER, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO PULL OVER WITHOUT CRASHING. THE DEALER HAS BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE 142,000. UPDATED 02-14-08. *KB THE CONSUMER STATED HAVE SINCE SOLD THE VEHICLE TO D AUTO 214-629-0941 BUT WISHES TO PURSUE HEALTH DAMAGE IN RESPIRATORY AND MENTAL ANGUISH. UPDATED 02/14/08 *TR

  May 23, 2006 · 142,000 miles
• Seat belts › Front

  DT: 1994 SUBARU LEGACY L ALL WHEEL DRIVE, THE MOTORIZED SEAT BELT BROKE. THE SEAT BELT IS CONNECTED TO THE DOOR, AND WHEN CLOSING THE DOOR THE MOTORIZED SEAT BELT WILL NOT RUN THE TRACK TO BE IN THE PROPER POSITION FOR SAFETY. THIS IS ON THE SHOULDER PORTION OF THE SEAT BELT. THE CONSUMER WAS TOLD THAT THE LAP BELT ALONE IS NOT SAFE USE. HAVE CONTACTED THE DEALER AND MANUFACTURER, AND THEY TOLD THE CONSUMER THERE IS NO RECALL ON THE SEAT BELT, AND THE MOTORIZED SEAT BELT WAS ONLY UNDER WARRANTY FOR 3 YEARS. THE COST TO REPLACE THE MOTOR OF THE SEAT BELT IS AT LEAST $400. THERE HAVE BEEN OTHERS WITH THIS SEAT BELT MOTOR PROBLEM. BASED ON WHAT THE MANUFACTURER TOLD THE CONSUMER THERE WAS NO…

  Jul 17, 2005 · 17,000 miles
• Fuel system, gasoline › Storage › Tank assemblyFire

  WHILE DRIVING DOWN THE FREEWAY, DRIVER OBSERVED SMOKE COMING FROM REAR OF VEHICLE. THE VEHICLE WAS PULLED TO THE SIDE OF THE ROAD, BOTH DRIVER AND PASSENGER EXITED SAFELY, AND OBSERVED FLAMES COMING FROM THE AREA UNDER THE REAR OF THE CAR (STATION WAGON BODY, AWD MODEL) ABOVE THE DIFFERENTIAL AND NEAR THE GAS TANK. RESPONDERS QUENCHED THE FIRE. THE VEHICLE WAS EXAMINED AND FOUND THAT THE WIRING FOR THE FUEL PUMP HAD THE INSULATION MELTED OFF, THE FUEL PUMP GASKET WAS COMPRIMISED, AND THERE WAS EVIDENCE OF FLAMES HAVING BEEN IN THE AREA. FURTHER INVESTIGATION FOUND THAT WHEN THE VEHICLE WAS DRIVEN SHORT DISTANCES, THE DIFFERENTIAL BECAME "RED HOT". THE AXLE WAS REPLACED, AND THE VEHICLE WAS…

  Dec 10, 2004

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.