Model year record

1998 Subaru Outback recalls & problems

The 1998 Subaru Outback has 2 safety recalls and 127 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (46 complaints).

Recalls2safety recalls

Complaints127filed by owners

Crashes · fires9 · 2reported in complaints

Injuries · deaths8 · 1reported in complaints

Safety recalls

SuspensionJun 25, 2001

Front › Springs › Coil springs

Recall 01V216000180,000 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT COIL SPRINGS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW YORK, NEW JERSEY, NEW HAMPSHIRE, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE SALT, CAN RESULT IN BREAKAGE OF THE SPRING.
Risk: DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE. SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Fix: DEALERS WILL NOTIFIY CUSTOMERS TO BRING THEIR VEHICLE TO AN AUTHORIZE DEALERSHIP TO HAVE A SPRING GUARD INSTALLED ON BOTH FRONT STRUTS TO PREVENT TIRE PUNCTURE AND REPLACE ANY BROKEN SPRINGS FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

Power trainFeb 20, 1998

Automatic transmission › Gear position indication (prndl)

Recall 98V04200019,386 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. DUE TO POOR WELDS, IGNITION KEYS CAN STICK, SHIFT LEVERS/LINKAGES CAN BREAK AND SHIFT LEVERS CAN MOVE.
Risk: THIS CONDITION CAN CAUSE UNEXPECTED MOVEMENT OF THE VEHICLE INCREASING THE RISK OF A CRASH OR PROPERTY DAMAGE.
Fix: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION SHIFT LEVER ASSEMBLIES (EXCEPT THE HANDLE GRIP).

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Engine and engine coolingEngine; Cooling system	46	0	0	0	93,850 mi
Power trainAutomatic transmission; Clutch assembly	21	1	1	2	69,000 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components	14	1	0	0	—
Vehicle speed controlAccelerator pedal	14	4	0	3	66,500 mi
Air bagsFrontal; Frontal › Sensor/control module	11	5	0	2	56,500 mi
VisibilityWindshield wiper/washer; Glass, side/rear	7	0	0	0	—
Electrical systemAlternator/generator/regulator; Wiring	7	0	0	0	100,147 mi
TiresTemporary/emergency spare tire; Sidewall	5	0	1	0	—
Unknown or other	4	1	0	2	—
Seat beltsFront › Retractor; Front › Anchorage	4	0	0	0	—
Exterior lightingHeadlights; Turn signal › Flasher unit	4	0	0	0	—
SuspensionFront › Springs › Coil springs	4	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Service brakes
WHILE DRIVING IN THE CITY STREETS, I CAME TO A STOP AND REALIZED THE CAR WOULD NOT STOP. WHEN I TOOK MY VEHICLE TO THE MECHANIC HE SAID 3 BRAKE LINES ON MY SUBARU OUTBACK 1998 HAD BROKEN. I LIVE IN PENNSYLVANIA. THIS INCIDENT COST ME $500 IN REPAIRS. I REALIZE THERE IS A RECALL FOR NEWER MODELS, BUT MY OLDER SUBARU OUTBACK IS HAVING THE SAME ISSUE. *TR
Apr 7, 2014 · 117,000 miles
Service brakes
ON MARCH 19, 2013, I WAS RETURNING TO MY PLACE OF EMPLOYMENT AFTER PICKING UP MY OUTBACK FROM BLOOMINGTON ACURA SUBARU, BLOOMINGTON, MN AFTER A CLUTCH REPLACEMENT WHEN THE HYDRAULIC BRAKE SYSTEM HAD A TOTAL FAILURE RESULTING IN A NEAR CATASTROPHIC COLLISION WITH SEVERAL VEHICLES. THIS VEHICLE WAS TAKEN BACK TO THE DEALER FOR EVALUATION. DEALER INSPECTION CONFIRMED THAT THE RIGHT REAR BRAKE LINE BY THE FUEL TANK PROTECTOR HAD EXCESSIVE CORROSION RESULTING IN SEVERE FLUID RELEASE THUS NOT ALLOWING THE HYDRAULIC SYSTEM TO PROPERLY PRESSURIZE RESULTING IN A COMPLETE FAILURE OF THE BRAKE HYDRAULIC SYSTEM. THE BRAKE LINES REPLACED WERE PART NUMBER 26522AA010 AND 26522AA020 (RIGHT AND LEFT). ON…
Mar 19, 2013 · 168,000 miles
Latches/locks/linkages
I WAS DRIVING ON INTERSTATE 90 IN IDAHO AT 62 MPH WHEN THE HOOD LATCH FAILED. THE HOOD WAS SECURED DOWN ALL THE WAY BEFORE THE INCIDENT AND HAD NOT BEEN OPENED IN TWO WEEKS. THERE HAD BEEN OVER 100 MILES OF HIGHWAY DRIVING OVER 60 MPH SINCE THE HOOD WAS LAST OPENED. THE HOOD FLEW UP WITH NO SAFETY CATCH OR HESITATION AND SLAMMED INTO THE WINDSHIELD. THE WINDSHIELD WAS SHATTERED, THE HOOD BENT AND THE ROOF DENTED. THE REAR VIEW MIRROR FLEW OFF INSIDE. I WAS ABLE TO GET TO THE SIDE OF THE ROAD AND THE PERSON FOLLOWING ME ON THE INTERSTATE PULLED OVER AND HELPED ME TIE IT DOWN TO BE ABLE TO LEAVE THE SCENE. WE BOTH DETERMINED IT WAS LATCH FAILURE. IT HAD THE POTENTIAL TO CAUSE A SERIOUS…
May 17, 2012 · 180,420 miles
Suspension
SOUNDED LIKE THERE WAS A POP IN MY FRONT CORNER. STILL DROVE OK UNDER 20-25 MPH. FASTER THAN THAT THE WHEEL SHOOK VIOLENTLY. BACKING UP THERE WAS A LOUD GRINDING NOISE. TOOK TO FRIENDS HOSE WHO WORKS ON CARS. HE SAID IT WAS MY FRONT LOWER CONTROL ARM ON THE DRIVER'S SIDE. THE CONNECTION BETWEEN THE CONTROL ARM AND THE FRONT (HE CALLED IT HANDLING BUSHING) WAS RUSTED COMPLETELY IN TWO. HE FOUND A USED CONTROL ARM AT A JUNK YARD AND REPLACED IT FOR ME. WE TOOK PICTURES OF THE PART THAT I CAN PROVIDE IF NEEDED. I NO LONGER HAVE THE OLD PART. *TR
Dec 3, 2011 · 150,000 miles
Fuel system, gasoline › Storage › Tank assembly › Filler pipe and cap
AS MY WIFE AND I WERE FILLING UP OUR 98 SUBARU LEGACY OUTBACK WE NOTICED A SMELL OF GAS FUMES ON THE WAY HOME AS I BACKED THE CAR INTO THE DRIVEWAY I NOTICED THE SMELL OF FUEL EVEN STONGER. I WENT TO THE BACK AND LOOKED UNDER THE RIGHT REAR AND TO MY SURPRISE THE FUEL FILLER NECK WAS LEAKING FUEL!! I PLACED A OIL CHANGE PAN UNDERNEATH AND TO THIS DAY I STILL HAVEN'T FIXED IT. DON'T KNOW WERE TO BEGIN WITH IT AND I'M THINKING IT'S A DESIGN FLAW SEEMS LIKE THERE IS HEAVY CORROSION ON THE VERY LOW PART OF THE FILLER PIPE AND THAT'S WERE IT'S LEAKING FROM. I'M GOING TO TRY AND HAVE IT REPAIRED BUT AT WHAT COST. I THINK THAT THIS SHOULD BE ADDRESSED TO AND BY SUBARU OF NORTH AMERICA AS A…
Aug 1, 2011 · 140,150 miles
Fuel system, other
FUEL (GASOLINE) FILLER NECK FOR THE 1998 SUBARU LEGACY WAGON RUSTS OUT. MECHANIC INDICATED VERY COMMON PROBLEM WITH THIS YEAR MAKE AND MODEL. VERY POOR DESIGN BECAUSE THE TUBE IS BEHIND A PLASTIC MOLDING THAT ACCUMULATES DIRT, SALT, WATER, AND ROTS THE TUBING CAUSING A CHRONIC LEAK OF GASOLINE POTENTIALLY OVER THE EXHAUST SYSTEM. RECALL AND REPAIR IS NEEDED. *TR
Sep 5, 2010 · 166,000 miles
Electrical system
TL*THE CONTACT OWNS A 1998 SUBARU OUTBACK. THE CONTACT STATED THAT WHEN ANY TYPE OF GMC VEHICLE WAS PARKED NEXT TO HIS VEHICLE THE AUTOMATIC DOOR LOCKS AND ALARM SYSTEM WOULD ENGAGE WHEN THE OTHER VEHICLES KEYLESS ENTRY SYSTEM WAS ACTIVATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO RECOMMENDED THAT THE VEHICLE BE TAKEN TO AN AUTHORIZED DEALER TO BE REPAIRED. THE FAILURE MILEAGE WAS 160,000. THE VIN WAS UNAVAILABLE.
Dec 20, 2009 · 160,000 miles
Engine and engine cooling
ENGINE OVERHEATING EVERY HALF MILE WITH ENGINE RESERVOIR OVERFLOWING. AFTER $1300 OF REPLACING THERMOSTAT, TIMING BELT, BELT TENSIONER, WATER PUMP, FLUSHING THE COOLING SYSTEM, AND COMPRESSION TESTS, I WAS TOLD I HAD A BLOWN HEAD GASKET. I WAS TOLD THE REPLACEMENT WOULD COST AN ADDITIONAL $2,200 AT LEAST. *TR
May 15, 2010 · 81,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.