Model year record

2011 Toyota Highlander Hybrid recalls & problems

The 2011 Toyota Highlander Hybrid has 1 safety recall and 5 owner complaints on file with NHTSA. The most-reported problem area is vehicle speed control (2 complaints).

Recalls1safety recalls

Complaints5filed by owners

Crashes · fires0 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

VisibilityOct 22, 2015

Power window devices and controls

Recall 15V6890001,814,284 vehicles

Problem: Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Risk: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Fix: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

Highlander Hybrid 4WD Hybrid

28mpg combined

City / highway	28 / 28 mpg
Fuel	Regular Gasoline

3.5 L · 6 cyl · Automatic (variable gear ratios) · All-Wheel Drive · about $2,400/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Typical mileage*
Vehicle speed control	2	—
Unknown or other	1	—
Service brakes	1	—
Engine	1	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Engine
TL* THE CONTACT OWNS A 2011 TOYOTA HIGHLANDER HYBRID. WHILE DRIVING APPROXIMATELY 40 MPH, A GRINDING NOISE WAS PRESENT COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO NORTH BROOK TOYOTA (1530 FRONTAGE RD, NORTH BROOK, IL) WHERE IT WAS DIAGNOSED THAT THE RUBBER OIL HOSE WAS DAMAGED. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO THE SAME DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE WAS DAMAGED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 105,000.
Mar 1, 2019 · 105,000 miles
Vehicle speed control
TL* THE CONTACT OWNS A 2011 TOYOTA HIGHLANDER HYBRID. WHILE DRIVING AT LOW SPEEDS, THE VEHICLE ACCELERATED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 60,000.
Feb 9, 2019 · 60,000 miles
Service brakes
BREAK LIGHT WARNINGS ALL CAME ON. BRAKES WENT OUT WHILE IN MOTION ON A CITY STREET. HAD TO SHOVE BREAK PEDAL DOWN WITH BOTH FEET TO THE FLOOR GOING UPHILL TO STOP. DEALERSHIP TOLD US IT'S THE BREAK ACTUATOR PUMP AND WILL BE $5000 TO REPAIR. THIS IS A SERIOUS HARDSHIP ON US. I'M A FOSTER PARENT AND NEED MY VEHICLE IN WORKING ORDER. DEALERSHIP SAID ONLY THEY CAN DO THE REPAIR DUE TO SENSOR CALIBRATIONS.
May 26, 2018 · 153,000 miles
Unknown or other
THE BACK-UP CAMERA HAS STARTED SHOWN MORE OF THE BUMPER... IT HAS STARTED POINTING MORE TO IT. THE CAMERA DID NOT SEE LOOSE. BUT I SEE THE MORE BUMPER ON THE SCREEN. WHEN I CONTACTED TO THE DEALERSHIP, WHERE I PURCHASED INCLUDE THE EXTENDED WARRANTY IN 2011. I WAS TOLD THAT I STILL HAVE TO PAY THE DIAGNOSIS FEE $89.99 + TAX.
Mar 10, 2015 · 30,000 miles
Vehicle speed control
MY HIGHLANDER HYBRID: PUSHED START BUTTON, AND BEHAVED NORMALLY. UPON BEING PLACED IN GEAR, THE VEHICLE ATTEMPTED TO ACCELERATE AS IF THE GAS PEDAL WAS PUSHED TO THE FLOOR. ONLY HEAVY BRAKE PRESSURE PREVENTED A SERIOUSLY DANGEROUSNESS CONDITION OF FULL ACCELERATION IN A SMALL PARKING LOT. WHEN PLACED IN PARK, THE THROTTLE REDUCED TO IDLE. I REPEATED THE ACTION OF PLACING THE CAR IN GEAR (EITHER REVERSE OR DRIVE), AND AGAIN, THE THROTTLE ADVANCED TO A FULL ACCELERATION MODE. AGAIN, ONLY VERY HEAVY PRESSURE ON THE BRAKE PREVENTED UNCONTROLLED ACCELERATION. I PARKED THE VEHICLE, AND CALLED MY LOCAL TOYOTA DEALER. AFTER BEING PLACED ON HOLD SEVERAL TIMES, I LEFT A VOICE MAIL WITH THE SERVICE…
May 3, 2014 · 72,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Pedestrian alert soundsClosedLed to recall 22V063000
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review…
DP22005 · opened Jan 27, 2023 · closed Aug 7, 2023
Steering Column SeparationClosed
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005).Â The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed.Â The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.Â The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the…
EA18006 · opened Nov 16, 2018 · closed Apr 2, 2024
Upper Steering Column SeparationClosed
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with…
PE18005 · opened May 4, 2018 · closed Nov 20, 2018