Model year record
2012 Toyota Highlander Hybrid recalls & problems
The 2012 Toyota Highlander Hybrid has no safety recalls on file with NHTSA, and 9 owner complaints. The most-reported problem area is structure (2 complaints).
Safety recalls
No safety recalls have been filed for the 2012 Toyota Highlander Hybrid.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Fuel economy
Highlander Hybrid 4WD Hybrid
| City / highway | 28 / 28 mpg |
|---|---|
| Fuel | Regular Gasoline |
3.5 L · 6 cyl · Automatic (variable gear ratios) · All-Wheel Drive · about $2,400/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| StructureBody | 2 | — |
| Fuel system, other | 1 | — |
| Power train | 1 | — |
| Hybrid propulsion system | 1 | — |
| Electrical system | 1 | — |
| Visibility/wiper | 1 | — |
| Unknown or other | 1 | — |
| Steering | 1 | — |
| Service brakes | 1 | — |
| Seats | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Seats
THE MID-ROW SEATS SHAKE AND RATTLE WHEN DRIVING AND NO ONE IS SITTING ON THEM.
- Structure › Body
VEHICLE POWER UNLOCKING MECHANISM IS UNRELIABLE, AND SHOWS SIGNIFICANT DEFECT IN THE UNLOCKING CAPABILITIES OF ALL BUT THE DRIVERS DOOR. AFTER SEVERAL LOCK ACTUATOR REPLACEMENTS, THE VEHICLE STILL EXHIBITS IMPROPER OPERATION. DEALERSHIP AGREES THAT THERE IS A COMMON COMPLAINT WITH THIS VEHICLE, AND IT'S LOCK OPERATION. BIGGEST ISSUE I SEE IS HAVING TO LEAVE MY CHILDREN UNATTENDED TO ENTER THE VEHICLE TO MANUALLY UNLOCK DOORS. I HAVE RESEARCHED THIS EXTENSIVELY, AND FOUND SIMILAR COMPLAINTS ONLINE, IN MANY FORUMS ETC - TOYOTA REFUSES TO ACKNOWLEDGE THAT THERE IS AN ISSUE WITH THE LOCK MECHANISMS. THIS HAS BEEN AN ONGOING ISSUE FOR OVER 2 YEARS NOW, AND SHOULD BE EXAMINED FOR THE SAFETY…
- Service brakes
BRAKE BOOSTER PUMP/ABS ACTUATOR C1391/C1256 WERE CODES GIVEN IN ATTACHED REPORT FROM TOYOTA. THIS IS APPARENTLY BEEN A PROBLEM WITH OTHER MODELS OF TOYOTAS AND ARE COVERED UNDER A WARRANTY ENHANCEMENT, HOWEVER THE 2012 IS NOT COVERED. NOTHING SEEMS WRONG WITH THE CAR AND THEY CANNOT REALLY TELL ME WHAT EXACTLY IS WRONG OR IF IT IS A BAD SENSOR, HOWEVER THEY WANT $4,200 TO REPLACE THE WHOLE UNIT. SEEMS LIKE THIS IS A KNOWN ISSUE THAT THEY HAVE NOT BEEN ABLE TO FIX FROM PREVIOUS MODELS AND WOULD LIKE IT COVERED DUE TO POTENTIAL SAFETY RISK.
- Steering
THE VEHICLE DEVELOPED A CLUNK OR KNOCK TYPE NOISE WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT. IT OCCURRED AT SLOW SPEEDS SUCH AS TURNING AT AN INTERSECTION. THIS REQUIRED REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT. THIS IS A KNOWN , REPORTED DEFECT ON HIGHLANDERS FROM 2008 - 2013. IT NEEDS TO BE ELEVATED TO THE LEVEL OF A RECALL.
- Visibility/wiper
THE SUNROOF EXPLODED AND SHUTTERED WITH A LOAD EXPLOSION NOISE WHILE I WAS DRIVING 55MPH ON A HIGHWAY 17 IN CALIFORNIA WITH MY CHILDREN.
- Hybrid propulsion system
NO PRIOR HISTORY OF HYBRID PROBLEMS DURING PREVIOUS 65,000 MILES. ON MONDAY MORNING, THE HIGHLANDER HYBRID STARTED UP FINE. AFTER WARMING UP FOR 5 MINUTES TO SCRAPE OFF SNOW, SHIFTED TO DRIVE AND BEGAN DRIVING. CAR SHUT DOWN AFTER ABOUT 12 FEET. CAR WOULD NOT RESTART. WARNING MESSAGE APPEARED ON DISPLAY, INDICATING HYBRID SYSTEM PROBLEM. AAA CAME, PUT ON FLATBED, AND TOOK TO NEAREST DEALERSHIP. DEALERSHIP WAS UNABLE TO DETERMINE CAUSE OR FIX PROBLEM FOLLOWING 6+ HOURS OF TROUBLESHOOTING BY THEIR HYBRID EXPERT YESTERDAY. THEY INDICATED IT COULD BE SOMETHING IN THE INVERTER, BUT THAT IT MAY NOT BE COVERED BY EXISTING EXTENDED WARRANTY, AND THAT WE MAY WANT TO CONTACT OUR INSURANCE COMPANY.…
- Structure › Body
SEVERAL SMALL PAINT BUBBLES ON REAR HATCH. ONE HAD BURST AT SEAM OF TRIM AND IS RUSTING. SCREWS HOLDING THE LICENSE PLATE LIGHT AND ASSEMBLY ARE RUSTED. UNDERSIDE OF "HIGHLANDER" EMBLEM TRIM WHERE REAR CAMERA IS LOCATED IS CORRODED AND RUSTED. *TR
- Power train
THE VEHICLE WAS TAKEN INTO DEALER FOR A FACTORY RECALL TO REPLACE THE REAR DRIVESHAFT ASSEMBLY. THE CAR WAS DRIVING COMPLETELY NORMALLY WHEN TAKEN IN FOR THIS SERVICE. BUT WHEN PICKED UP, THE CAR WAS UNSAFE. IT DROVE NORMALLY AT LOW SPEEDS LEAVING THE DEALERSHIP. BUT A COUPLE OF MILES LATER WHEN GETTING ONTO THE FREEWAY, AT ABOUT 50 MPH, THE REAR END STARTED TO FEEL LIKE IT WAS A DRAG ON FORWARD MOVEMENT, AND FELT LIKE IT WAS SWAYING FROM SIDE TO SIDE, MAKING THE VEHICLE VERY DIFFICULT TO CONTROL. NO UNUSUAL NOISES WERE HEARD. EMERGENCY FLASHERS WERE ACTIVATED AND SPEED REDUCED TO 25 MPH TO TRY TO MAINTAIN CONTROL OF THE VEHICLE. THE FIRST OFF RAMP WAS TAKEN, AND THE DEALER NOTIFIED. THE…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- Pedestrian alert soundsClosedLed to recall 22V063000
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review…
- Steering Column SeparationClosed
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the…
- Upper Steering Column SeparationClosed
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with…