Model year record

2024 Grand Design Reflection recalls & problems

The 2024 Grand Design Reflection has 3 safety recalls and 7 owner complaints on file with NHTSA. The most-reported problem area is structure (2 complaints).

Recalls3safety recalls

Complaints7filed by owners

Crashes · fires0 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

EquipmentSep 24, 2026

Recreational vehicle/trailer

Recall 26V61600016,075 vehicles

Problem: Grand Design RV, LLC (Grand Design) is recalling certain 2024-2027 Reflection fifth wheel recreational trailers. The auto detect solar controller may select a 24 volt output when the electrical system is designed for 12 volts. The incorrect voltage may damage the 7-way bulkhead power center and other circuits.
Risk: While damage to the power center increases the risk of a fire, damage to the electrical system may cause the trailer brakes or exterior lightings to fail, increasing the risk of a crash.
Fix: An over-the-air (OTA) software update will be released. Lighting will be inspected and repaired as necessary, free of charge. Owner notification letters are expected to be mailed November 16, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910068.

Components: Equipment › Recreational vehicle/trailer; Electrical system › Software

Electrical systemJul 9, 2024

Wiring › Fuses and circuit breakers

Recall 24V522000734 vehicles

Problem: Grand Design RV, LLC (Grand Design) is recalling certain 2024 Reflection travel trailers. The electrical wiring may be missing over current circuit protection.
Risk: Wiring without circuit protection may become damaged and short circuit, increasing the risk of a fire.
Fix: Dealers will install a 50-amp breaker, free of charge. Owner notification letters were mailed July 24, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910044.

Electrical systemNov 22, 2023

Wiring

Recall 23V7880001,011 vehicles

Problem: Grand Design RV, LLC (Grand Design) is recalling certain 2024 Reflection travel trailers. The electrical plug blade openings (narrow hot blade and wider neutral blade) may be reversed on one of the two receptacle outlet faces, which can cause outlet failure.
Risk: Electrical outlet failure can increase the risk of a fire.
Fix: Dealers will replace the incorrect receptacles, free of charge. Owner notification letters were mailed January 5, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910041.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Typical mileage*
StructureBody; Frame and members	2	—
Suspension	2	—
Electrical system	1	—
Unknown or other	1	—
Service brakes	1	—
Wheels	1	—
TiresPressure monitoring and regulating systems	1	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Wheels
Fifth wheel was purchased with a tire monitoring system included. It has not worked since we purchased it 8-19-2024. We have taken it twice to the dealer, Blue Compass and it still doesn't work. I am told the problem is they put the wrong sensors in the tires. Lippert and Grand Design are fighting about who's fault it is all while it still doesn't work. Not having the tire sensor/monitoring system working has created a safety issues for us. We have no idea if the tires get hot, start to lose air, all of which could happen without the system working correctly. That creates a safety issue because the camper is a fifth wheel 35' long weighing 12,000 lbs. I am reporting this because I have no…
Aug 19, 2024
Structure › Frame and members
The contact owns a 2024 Grand Design Reflection RV. The contact stated that while attempting to raise the RV, the RV failed to raise up or level as designed. The RV was taken to a local dealer where it was diagnosed, and the contact was advised that the frame was bent because of a manufacturer's defect, and that further diagnosis was required to determine the cause of the failure. The RV was not repaired. The manufacturer was notified of the failure.
May 1, 2025
Service brakes
Trailer is equipped with the Lippert ABS brake system. During final review of issues covered by warranty at the Dealer (General RV in Birch Run MI) the dealer recommended a wheel bearing re grease which I agreed to. During this procedure the left rear brakes were noted as totally worn out and the brake drum had a significant crack due to excessive heat from the dragging brake. This trailer has approx. 8000 mi of towing. As of now root cause has not been determined but if I had not opted for the wheel bearing grease service the problem would not have been discovered. Failure of the cracked drum could have caused wheel lockup and led to a loss of control. There was no indication of a problem…
Mar 20, 2025
Unknown or other
The entire rear section/walls of the camper have lifted and separated from the main frame. A licensed RV specialist has inspected the unit, and determined the main frame has severe issues and the unit should not be used or moved. There were several warning signs brought to the attention of Grand Design but they dismissed it as being within 'tolerance'. I'm a licensed contractor of 39 years and proved to them there is a major issue, but even their own service response technician dismissed it as being in 'tolerance'. Now it has turned into a catastrophic failure. I demanded Grand Design come and take it away. I let them know it has major failure and is a safety hazard, they sent a driver to…
May 5, 2024
Suspension
Took delivery of this new 2024 on [XXX], 2024. There has been a know problem with the rear stabilizing jacks being installed too long. Lippert is the manufacture of the jacks and their specifications require that the rear jacks be at least 7" from the ground in travel mode. Mine measure 3-5" from the ground when attached to the truck and level. This creates a a dangerous issue if a jack strikes the ground during travel and comes loose. It was conveyed to me that Grand Design made changes to this by installing a shorter rear jack system beginning in March of this year which did not happen on this unit. This is the correspondence with the dealer that I purchased from when I inquired about the…
Apr 26, 2024
Structure › Body
Each trailer must have rear impact guards (bumpers) or other devices that prevent another vehicle from riding underneath. https://csa.fmcsa.dot.gov âº MyFiles 5.1.9 Rear-End Protection (393.86) - CSA Compliance, Safety My trailer does not have a rear bumper.
Jan 29, 2024
Electrical system
The camper does not have a GFCI receptacle within the camper. It does have a GFCI breaker. Unfortunately, the GFCI breaker is not easily accessible because you have to remove a couch before you can access the breaker. That does not follow ANSI code.
Mar 4, 2024

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.