Model year record

1996 Mercury Grand Marquis recalls & problems

The 1996 Mercury Grand Marquis has 6 safety recalls and 239 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (87 complaints).

Recalls6safety recalls

Complaints239filed by owners

Crashes · fires9 · 19reported in complaints

Injuries · deaths16 · 2reported in complaints

Safety recalls

SteeringOct 6, 2015

Steering

Recall 15E0820001,767 vehicles

Problem: Dorman Products, Inc. (Dorman) is recalling certain model Dorman Steering Shafts, part number 425-359, Solutions Steering Shafts, part number 7-0359, and OE Solutions Steering Shafts, part number 425-359, manufactured April 17, 2014, to September 28, 2015. These aftermarket replacement steering shafts are sold for use in 1995-2002 Ford Crown Victoria, Mercury Grand Marquis, and Lincoln Town Car vehicles. These steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.
Risk: If the shafts separate during vehicle operation, a loss of steering control would result, increasing the risk of a vehicle crash.
Fix: Dorman will notify owners, and dealers will replace the steering shaft, free of charge. The recall began on October 28, 2015. Owners may contact Dorman customer service at 1-800-523-2492, option 5.

Vehicle speed controlFeb 4, 2008

Cruise control

Recall 08V051000225,000 vehicles

Problem: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Risk: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Fix: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Vehicle speed controlAug 3, 2007

Vehicle speed control

Recall 07V3360003,600,000 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Fix: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Seat beltsJun 12, 2000

Front › Anchorage

Recall 00V1570011,167 vehiclesopened after NHTSA action (OVSC)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Risk: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Fix: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.

Seat beltsJun 12, 2000

Front › Anchorage

Recall 00V1570021,129 vehiclesopened after NHTSA action (OVSC)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Risk: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Fix: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.

Latches/locks/linkagesApr 22, 1996

Doors › Latch

Recall 96V07000073,500 vehicles

Problem: WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Risk: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Fix: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1996 Mercury Grand Marquis 4-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Grand Marquis

18mpg combined

City / highway	15 / 23 mpg
Fuel	Regular Gasoline

4.6 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,700/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Engine and engine coolingExhaust system › Manifold/header/muffler/tail pipe; Engine	87	0	8	7	85,109 mi
Service brakes, hydraulicFoundation components › Hoses, lines/piping, and fittings; Foundation components	25	2	2	1	70,535 mi
Fuel system, gasolineCarburetor system; Fuel injection system › Injectors	21	0	0	0	—
SteeringSteering wheel/handle bar; Linkages › Tie rod assembly	21	0	0	0	114,050 mi
Exterior lightingHeadlights; Headlights › High/low beam dimmer switch	19	0	0	0	110,236 mi
Vehicle speed controlCruise control; Linkages	19	3	4	2	98,000 mi
Electrical systemWiring › Front underhood; Horn	17	0	5	0	117,121 mi
SuspensionFront; Front › Control arm › Lower ball joint	16	0	0	0	96,492 mi
Power trainAutomatic transmission; Driveline › Differential unit	16	0	1	3	70,000 mi
VisibilityWindshield; Rearview mirrors/devices › Exterior	10	0	2	0	70,000 mi
Air bagsFrontal	6	3	2	2	—
StructureFrame and members; Body › Roof and pillars	5	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Electrical system
The contact owns a 1996 Mercury Grand Marquis. The contact stated while driving approximately 60 MPH the instrument panel began started flashing off and on before going black. The contact stated that he was headed to an off ramp the head lights stopped functioning. The contact stated no warning light was illuminated. The contact had stopped driving the vehicle for several days and then tested the head lights and stated that the functionality had returned. The contact had not taken the vehicle to a dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 225,000.
Feb 25, 2023 · 225,000 miles
Exterior lighting › Headlights
The contact owns a 1996 Mercury Grand Marquis. The contact stated while driving approximately 70 MPH at night, the headlights became inoperable. While driving for approximately 30 more miles and exiting the off ramp, the headlights started to flicker. The headlights momentarily worked but then became inoperable again. The instrument panel warning lights illuminated and were flashing. The contact also detected an abnormal clicking noise from the steering column. The contact stated that the windshield wipers became stuck in the on position. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was…
Feb 18, 2023 · 210,000 miles
Steering
WHEN DRIVING AND TURN TO LEFT VEHICLES STEERING WANTS TO LOCK UP
Jul 27, 2017 · 150,000 miles
Exterior lighting
TL* THE CONTACT OWNS A 1996 MERCURY GRAND MARQUIS. WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLIGHTS BECAME VERY DIM AND HINDERED THE CONTACT'S VISIBILITY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THERE WAS NO FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
Oct 1, 2015
Power train
TL* THE CONTACT OWNS A 1996 MERCURY GRAND MARQUIS. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE TRANSMISSION FLUID LEAKED ONTO THE GASKET PAN. THERE WAS NO FLUID VISIBLE ON THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TORQUE CONVERTER, TRANSMISSION PUMP, AND PAN NEEDED TO BE REPLACED. ADDITIONALLY, THE TRANSMISSION REAR MAIN SEAL AND DRIVE SHAFT REQUIRED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
Jan 13, 2014 · 70,000 miles
Vehicle speed control
TL* THE CONTACT OWNS A 1996 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT THE DEALER DISCONNECTED THE SPEED CONTROL DEACTIVATION SWITCH AS AN INTERIM REPAIR UNTIL THE INSTALLATION OF A FUSED WIRING HARNESS BECAME AVAILABLE FOR NHTSA CAMPAIGN NUMBER: 07V336000 (VEHICLE SPEED CONTROL). THE CONTACT STATED THAT THE VEHICLE WAS TAKEN BACK TO THE DEALER TO COMPLETE THE RECALL REPAIRS; HOWEVER, THE DEALER REFUSED TO HONOR THE RECALL REPAIR. AS A RESULT, THE CONTACT WAS UNABLE TO ACTIVE THE SPEED CONTROL ACTIVATION SWITCH. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V051000…
Aug 3, 2007 · 114,000 miles
Vehicle speed controlFire
ON 9/17/2003 @ 11:23 PM, MY 1996 GRAND MARQUIS CAUGHT FIRE UNDER THE HOOD AND WAS TOTALLY DESTROYED WHILE SITTING IDLE IN FRONT OF MY HOUSE. THE HENRICO COUNTY FIRE DEPARTMENT WAS CALLED. I HAVE THE FIRE REPORT, WHICH INDICATES THAT NO CAUSE FOR THE FIRE WAS DETERMINED. IN JUNE 2014, I RECEIVED A NOTIFICATION FROM FORD MOTOR COMPANY STATING THAT MY 1996 GRAND MARQUIS HAS A POTENTIAL UNDER HOOD FIRE RISK. THE ISSUE AS STATED WAS THAT "FORD CANNOT BE CONFIDENT THAT AFTER MANY YEARS IN SERVICE, THE SPEED CONTROL DEACTIVATION SWITCH IN YOUR VEHICLE WILL NOT LEAK, POSING THE RISK OF AN UNDER HOOD FIRE. UNTIL THIS REPAIR IS PERFORMED, A FIRE COULD OCCUR AT ANY TIME. A FIRE CAN OCCUR EVEN IF THE…
Sep 17, 2013 · 190,000 miles
Exterior lighting
PLASTIC HEADLIGHT LENSES HAVE BECOME YELLOWED AND CLOUDY. THIS HAS SEVERELY REDUCED NIGHTTIME VISIBILITY ON UNLIT STREETS, WHICH IS A SAFETY ISSUE. DID SOME INTERNET RESEARCH AND DISCOVERED THAT THIS IS A WIDESPREAD ISSUE WITH NUMEROUS EXPENSIVE AFTERMARKET PRODUCTS THAT WILL SUPPOSEDLY RESTORE LENS CLARITY. I BOUGHT AND USED ONE OF THESE PRODUCTS, BUT WAS UNABLE TO RESTORE FULL LENS CLARITY. I'M GUESSING THAT THE CLOUDINESS WILL RETURN AND I'LL HAVE TO REPEAT THE "RESTORATION" PROCESS. I WENT TO A NEARBY SHOPPING MALL AND NOTICED NUMEROUS VEHICLES WITH CLOUDY HEADLIGHTS, ALL WITH PLASTIC LENSES. THIS SAFETY ISSUE WAS A NON-ISSUE WHEN ALL HEADLIGHTS WERE REQUIRED TO USE GLASS LENSES. PLEASE…
May 31, 2014 · 130,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

REAR BRAKE LINE FAILUREClosedLed to recall 05V086000
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR…
EA03012 · opened Jul 25, 2003 · closed Apr 11, 2005
REAR BRAKE LINE FAILUREClosed
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
RQ03004 · opened Mar 11, 2003 · closed Jul 25, 2003
BALL JOINT SEPARATIONClosed
SEE ATTACHED REPORT.
RQ03002 · opened Jan 3, 2003 · closed Jun 3, 2003
SPEED CONTROL DEACTIVATION SWITCH FIRESClosed
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA02025 · opened Sep 6, 2002 · closed Jun 30, 2004
FUEL-FED FIRESClosed
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
DP02007 · opened Aug 22, 2002 · closed Dec 4, 2002
POST REAR END COLLISION FIRESClosedLed to recall 02I003000
There is no summary currently available
SQ01014 · opened Nov 27, 2001 · closed Oct 3, 2002
IMPROPER HEIGHT FOR HEAD RESTRAINTSClosed
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JULY 28, 1998.THE PETITION ALLEGES THAT THE DRIVER'S SEAT HEAD RESTRAINT WAS NOT HIGH ENOUGH AT ITS HIGHEST POSITION TO PROTECT HIM FROM NECK INJURIES SUSTAINED DURING A REAR IMPACT COLLISION.OTHER THAN THE SUBJECT PETITIN, ODI HAS RECEIVED NO OTHER COMPLAINTS OF INADEQUATE HEAD RESTRAINT HEIGHT FOR THE SUBJECT VEHICLES.FORD MOTOR COMPANY'S COMPLIANCE DATA SHOWS THAT THE SUBJECT VEHICLES MET THE HEAD RESTRAINT HEIGHT REQUIREMENT OF FMVSS NO. 202, HEAD RESTRAINTS. THEREFORE, THE PETITION IS DENIED.
DP98007 · opened Jul 28, 1998 · closed Sep 28, 1998