Loss of headlightsClosedLed to recall 15V861000
The Office of Defects Investigation (ODI) opened an investigation concerning the loss of headlights in model year (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The subject vehicles share the same architecture and major components.ODI has received 636 unique reports (for all submission dates) related to the alleged defect, with owners describing a loss of both low and/or high beam headlights occurring while driving.ODI identified 4 Vehicle Owner Questionnaire ( VOQ) reports alleging minor crash or loss of control incidents due to headlight failures.Drivers alleged running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 4173 unique reports related to the alleged problem.There were a total…
PE15028 · opened Aug 10, 2015 · closed Jan 8, 2016Loss of headlamp/exterior lightingClosed
In a letter dated October 2, 2014 the Office of Defects Investigation (ODI) was initially petitioned by the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.ODI analyzed Vehicle Owner Questionnaire (VOQ) complaints received from consumers and identified a total of 605 reports (for all submission dates) alleging headlight failure.The complaints indicate failures of both low beam headlights typically while driving, a defect condition that was evaluated under a prior ODI investigation (PE08066).Most consumer VOQs indicate that the headlights failed suddenly and without warning leaving the driver with no forward lighting, however some report the headlights flickered or dimmed prior to turning off.In some cases…
DP15002 · opened Apr 1, 2015 · closed Aug 11, 2015LOSS OF HEADLIGHT FUNCTIONClosed
THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF COMPLAINT REPORTS, FIELD AND TECHNICAL DATA PROVIDED BY FORD AND COMPLAINANT INTERVIEWS. FORD FOUND THAT SOME LIGHTING CONTROL MODULES (LCM) IN THE SUBJECT VEHICLES CONTAINED DEFECTIVE SOLDER JOINTS ON THE PRINTED CIRCUIT BOARD.THIS CONDITION CAN LEAD TO POOR HEADLIGHT PERFORMANCE RANGING FROM INTERMITTENT OUTAGE AND DIMMING TO EVENTUAL HEADLIGHTS FAILURE.THE FAILURE DOES NOT AFFECT OTHER LIGHTING FUNCTIONS (PARK, EMERGENCY FLASHER, BRAKE AND FLASH TO PASS LIGHTS).THE AGENCY IS AWARE OF A TOTAL OF 306 CONSUMERS COMPLAINTS AND NO REPORT OF CRASH, INJURY OR FATALITY.FORD REPORTS 2,074 WARRANTY CLAIMS RELATED TO HEADLIGHT FAILURE LINKED TO THE LCM DURING THE FIRST THREE YEARS OF OPERATION.ABOUT 12% (247) OF THESE CLAIMS ARE SPECIFIC TO HEADLIGHT FAILURE WHILE DRIVING.THE AVERAGE WARRANTY RATE FOR HEADLIGHT FAILING WHILE…
PE08066 · opened Nov 26, 2008 · closed Mar 24, 2009SPARK PLUG EJECTION FROM CYLINDER HEADClosed
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…
DP05005 · opened Sep 22, 2005 · closed Jan 4, 2006REAR AXLE FRACTUREClosedLed to recall 04V328000
THIS PE WAS OPENED AFTER ODI BECAME AWARE OF TWO ALLEGATIONS CONCERNING REAR AXLE FRACTURE AND PARTIAL WHEEL SEPARATION INVOLVING MY 2003 FORD CROWN VICTORIA POLICE INTERCEPTORS (CVPI).INITIALLY, THE PE'S SCOPE INVOLVED ALL MY 2003 GRAND MARQUIS, CROWN VICTORIA, AND LINCOLN TOWN CARS (I.E., PANTHER PLATFORM) PRODUCED THROUGH JANUARY 2003.WHILE GATHERING INFORMATION ABOUT THIS ISSUE, IT BECAME EVIDENT THAT THE FAILURES WERE CONFINED TO LONG-WHEELBASE LINCOLN TOWN CARS AND THE CVPI'S DUE TO THEIR UNIQUE WEIGHT DISTRIBUTION AND USAGE PROFILES.FORD'S RECALL ADDRESSES THESE VEHICLES.BOTH THE COMPANY AND ODI ARE CONTINUING TO MONITOR THE FIELD PERFORMANCE OF THE AXLES AND WILL TAKE APPROPRIATE ACTION AS REQUIRED.
PE04010 · opened Jan 22, 2004 · closed Jul 8, 2004FRACTURE OF THE STEEL WHEEL RIMClosedLed to recall 03V279000
THE SUBJECT WHEEL (NEW FOR MY 2003) IS USED ON CROWN VICTORIA (CV) AND GRAND MARQUIS.COMPLAINT DATA INDICATES THAT WHEEL FAILURE AFFECTS PRIMARILY THE COMMERCIAL SPECIFICATION CV MODEL (POLICE AND TAXI) WHICH HAS UNIQUE DESIGN CHARACTERISTICS AND IS GENERALLY SUBJECTED TO HIGHER USAGE DEMANDS.DURING FORD'S ANALYSIS, IT WAS DETERMINED THAT CYCLIC BENDING MOMENT FATIGUE COULD CAUSE RIM CRACKS TO OCCUR IN THE HEAT AFFECTED ZONE ADJACENT TO THE CIRCUMFERENTIAL WELD.FORD IMPLEMENTED CHANGES IN WHEEL MANUFACTURE IN SEPTEMBER 2002 AND INTRODUCED A NEW WHEEL DESIGN WITH A THICKER RIM IN APRIL 2003.ODI FOUND EVIDENCE THAT INDICATED RAPID CRACK PROPOGATION MIGHT HAVE OCCURRED IN SEVEN WHEEL FAILURE INCIDENTS, TWO OF WHICH LEAD TO TIRE DEBEADING.FORD HAS ANNOUNCED THAT 29,946 COMMERCIAL SPEC CV VEHICLES, MANUFACTURED PRIOR TO THE SEPTEMBER CHANGE, WILL BE RECALLED TO HAVE THE APRIL 2003 DESIGN…
PE03009 · opened Feb 25, 2003 · closed Aug 8, 2003