WINDSHIELD LEAK CAUSES ELECTRIC FAILURESClosed
CONSUMERS ALLEGED THAT WHEN IT RAINED OR SNOWED, WATER LEAKED INTO THE VEHICLE AROUND THE WINDSHIELD.MOISTURE FLOWING THROUGH THE SEAL THAT SURROUNDS THE FRONT WINDSHIELD FOLLOWS A PATH THROUGH THE SEAL INTO THE GENERIC ELECTRONIC MODULE (GEM) AND FUSE BOX, AND MAY CAUSE THE ELECTRICAL COMPONENTS IN THE VEHICLE TO MALFUNCTION.OVERALL, THE NUMBER OF REPORTS ALLEGING WIPER FAILURES AND LIGHTING FAILURES IS RELATIVELY SMALL.IN REVIEWING A LARGE SAMPLE OF THE 1503 COMPLAINTS FOR WINDSHIELD LEAKS, ODI'S ANALYSIS REVEALS THAT 0.04% OF THE TOTAL VEHICLE POPULATION REPORTED IMPROPER WINDSHIELD WIPER OPERATION AND 0.01% OF THE TOTAL VEHICLE POPULATIONREPORTED LIGHTING FAILURES.THE WARRANTY CLAIMS REVEAL THAT APPROXIMATELY 0.10% OF THE POPULATION HAS BEEN SERVICED FOR WIPER MALFUNCTIONS AND 0.08% FOR LIGHTING MALFUNCTIONS AS A RESULT OF WINDSHIELD LEAKING. ODI'S ANALYSIS OF THE FIELD PERFORMANCE…
EA05015 · opened Oct 13, 2005 · closed Dec 6, 2006SPARK PLUG EJECTION FROM CYLINDER HEADClosed
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…
DP05005 · opened Sep 22, 2005 · closed Jan 4, 2006ELECTRICAL SYSTEM FAILUREClosed
ODI HAS RECEIVED 39 REPORTS ALLEGING THAT WATER LEAKS AROUND THE WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE WINDSHIELD WIPERS AND THE HEADLAMPS.FORD REPORTS THAT WATER ENTERING THE VEHICLE CAN WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM).THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, EA05015, TO ALLOW FURTHER INVESTIGATION OF THE ISSUE AND TO ASSESS THE NATURE OF THE POTENTIAL SAFETY CONSEQUENCE.
PE05033 · opened Jun 15, 2005 · closed Oct 13, 2005ENGINE COMPARTMENT FIRESClosedLed to recall 05V388000
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED…
EA05005 · opened Mar 22, 2005 · closed Aug 2, 2006FRONT SEAT BELT BUCKLE ASSEMBLYClosed
DURING THE INITIAL RECALL CAMPAIGN IN 2001, THE SUBJECT VEHICLES WERE INSPECTED BY FORD DEALERSHIPS USING A TEST TOOL THAT WOULD DETECT A DEFECTIVE FRONT SEAT OUTBOARD SEAT BELT BUCKLE ASSEMBLY.APPROXIMATELY ONE MILLION VEHICLES PASSED THE INSPECTION TEST FOR ONE OR BOTH FRONT BUCKLES.SUBSEQUENT TO THE RECALL SERVICE ACTION, ODI RECEIVED 15 CONSUMER REPORTS ALLEGING THAT A PASSED INSPECTION BUCKLE SUBSEQUENTLY FAILED TO LATCH OR INADVERTENTLY UNLATCHED DURING USE.IN ADDITION, FORD HAS IDENTIFIED 543 OWNER AND FIELD REPORTS ALLEGING BUCKLE FAILURE SUBSEQUENT TO PASSING THE INSPECTION TEST.FORD TESTED AND EXAMINED OVER 100 WARRANTY-RETURNED BUCKLES AND FOUND THAT 44% OF THE BUCKLES HAD NO PROBLEM OR A CONDITION NOT RELATED TO THE RECALL INSPECTION (NON-LATCH RELATED BUCKLE DAMAGE OR FOREIGN CONTAMINATION).WARRANTY CLAIMS WERE HIGHEST DURING THE 18-MONTH PERIOD AFTER THE START OF THE…
EA05004 · opened Feb 17, 2005 · closed Jul 6, 2005FRONT SEAT BELT BUCKLE ASSEMBLYClosed
UNDER RECALL CAMPAIGN (01V227), FORD RECALLED APPROXIMATELY 1.3 MILLION VEHICLES TO INSPECT AND IF NECESSARY REPLACE THE FRONT DRIVER AND/OR PASSENGER SEAT BELT BUCKLE.APPROXIMATELY 1.1 MILLION OWNERS RESPONDED BY TAKING THEIR VEHICLES TO A DEALER FOR INSPECTION OF THE BUCKLE USING A SPECIALIZED BUCKLE TEST TOOL.FORD REPORTED THAT 829,927 VEHICLES HAD BOTH BUCKLES PASS THE TOOL TEST AND ANOTHER 167,336 VEHICLES HAD ONE BUCKLE PASS.ODI AND FORD RECEIVED COMPLAINTS ALLEGING SEAT BELT BUCKLE FAILURE SHORTLY AFTER PASSING THE ORIGINAL RECALL INSPECTION SERVICE.COMPLAINANTS ALLEGED THAT THE BUCKLE FAILED BY EITHER NOT LATCHING OR FALSE-LATCHING (PARTIAL ENGAGEMENT OF THE LATCH TO THE LATCH PLATE).A FALSE-LATCHED BUCKLE MAY RELEASE WITH MINOR MOVEMENT OR IMPACT AGAINST THE BUCKLE HOUSING INCLUDING INADVERTENT RELEASE WHILE THE VEHICLE IS IN MOTION.ODI IS UPGRADING THIS RECALL QUERY TO AN…
RQ04011 · opened Oct 22, 2004 · closed Feb 17, 2005
