*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Unknown or other1 injury
I am formally reporting a serious safety incident involving the original factory-supplied tire jack provided with our 2024 Ford Expedition Limited. Vehicle: 2024 Ford Expedition Limited VIN: [XXX] Incident Date: [XXX] Location: [XXX]. While attempting to change a tire, my husband, [XXX], experienced a sudden loss of stability when the factory-supplied jack slipped, causing the vehicle to fall and trapping him underneath. My husband underwent total knee replacement surgery approximately two and a half months ago. The Expedition came down onto his surgically repaired leg, potentially causing additional injury. Even more concerning, the Ford-provided jack slipped three times during this…
Oct 22, 2026Unknown or other1 injury
On [XXX] I was grabbing my wallet from the center console of the vehicle and the peeling chrome piece tore my left ring finger open. It was a flap tear that required an urgent care visit to fix/stop the bleeding. They applied derma bond and other bandaging to help stop bleeding and heal the wound - I also had to go back into urgent care on [XXX] to re-treat the wound after the initial bandaging fell off. My local dealer (Greiner) inspected the vehicle on [XXX] and provided a repair order to prove that the chrome trim piece was indeed peeling and sharp and subject to the recall. I contacted ford's customer service today, [XXX], to request reimbursement of medical expenses, some kind of…
Sep 28, 2026Forward collision avoidance › Adaptive cruise controlCrash
While leaving a parking lot the vehicle was pulling out a parking spot in reverse, as the vehicle changed from reverse to drive, teh vehicle randomly started accelerating without cause, the gas pedal was not initiated and there was no pedal influence at all. The car had an internal computer issue and started to sort through the cruise control settings, adapative cruise control settings, and just started accelerating out of nowhere without being told to do so. The car was able to come to a complete stop after the driver reacted quickly;y and swiftly, scaring the passenger of the vehicle which was his wife, and his (2) daughters one of which is an infant and the other a toddler. This was a…
Oct 2, 2026Unknown or other
As I drove down the road my sunroof exploded, glass flew everywhere and scratched the top of vehicle
Sep 23, 2026Structure › Body
Hood striker fasteners failed allowing hood to separate from striker at highway speed resulting in hood flying open, striking and damaging windshield and blocking view of driver. Photos from incident scene and subsequent dealer inspection agree on fastener failure as the striker was found fully latched into the retainers. Fortunately, driver was in an outer lane and able to navigate to shoulder and stop vehicle without further damage.
Sep 22, 2026Electrical system
Started vehicle for first drive of the day and noticed the digital instrument cluster failed to display any information. The screen remained blank although the backlight was on. Turned the vehicle off and on, performed a reset, disconnected battery for more than an hour before reconnecting, checked fuses, etc., but the display did not correct. Unable to check speedometer, fuel levels, RPM, drive mode, etc. The vehicle has been taken to local Ford Dealership, buy was advised it would be several weeks before they could run diagnostics check.
Sep 21, 2026Steering
This was a rental vehicle obtained from Budget at [XXX]. On XXX at approximately 2:45 p.m., while driving south toward [XXX], the Ford Expedition developed increasingly severe rumbling and shaking and became difficult to control. All occupants noticed the condition. We reduced speed and pulled off at the first safe available location at approximately 3:00 p.m. rather than continue driving. After stopping, we inspected the left-rear wheel and found a snapped wheel stud and a missing lug-nut position. Multiple actual threaded lug nuts were loose enough to be turned by hand. Budget roadside assistance dispatched a tow operator. The tow driver independently verified the snapped stud and…
Sep 17, 2026Chest clip, buckle, harness
I recently discovered that the car seat harness is fraying on both sides. This is near the base (by hips of child in seat) where they enter the cushion and connect to the car seat. I think this is a defect and poses a risk, especially if I were to get in an accident. When I submitted a complaint with photos to Baby Jogger they replied "After reviewing the concern, please note that fraying is not considered a manufacturing defect. Fraying occurs gradually through normal use and wear over time rather than from a single incident and should be addressed before it gets worse. As a result, this type of condition is not covered under our warranty policy." They did offer a whopping $100 off an item…
Aug 24, 2026
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
