The 2012 Ford Expedition has 3 safety recalls and 118 owner complaints on file with NHTSA. The most-reported problem area is power train (64 complaints).
Problem: Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.
Risk: An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.
Fix: Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S19.
Exterior lighting › Back up lights
NHTSA recall 12V190000 · May 3, 2012 · 10,500 vehicles
Problem: FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 ÂLAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Risk: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE ÂRÂ POSITION AND THE VEHICLEÂS TRANSMISSION DOES GO IN REVERSE, THE ÂRÂ MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLEÂS NOT SIGNALING IT IS IN REVERSE.
Fix: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Components: Exterior lighting › Back up lights; Power train › Automatic transmission › Control module (tcm/pcm/tecm)
Seats › Mid/rear assembly
NHTSA recall 12V034000 · Feb 2, 2012 · 569 vehicles
Problem: FORD IS RECALLING CERTAIN MODEL YEAR 2012 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES, MANUFACTURED FROM NOVEMBER 19, 2011, THROUGH DECEMBER 2, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINTS." THESE VEHICLES MAY HAVE INADEQUATE WELDS ON THE HEAD RESTRAINT SUPPORT BRACKETS FOR THE SECOND ROW, RIGHT-HAND SEAT.
Risk: IN THE EVENT OF A CRASH, THE SEAT HEAD RESTRAINT MAY NOT PROVIDE THE REQUIRED STRENGTH, INCREASING THE RISK OF INJURY.
Fix: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE HEAD RESTRAINTS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
NHTSA side barrier crash testNHTSA side pole crash test
2012 Ford Expedition EXTENDED SUV 4x4
Overall
★★★★★
Frontal crash
★★★★★
Side crash
★★★★★
Rollover
★★★★★
Rollover risk
19.8%
2012 Ford Expedition EXTENDED SUV 4x2
Overall
★★★★★
Frontal crash
★★★★★
Side crash
★★★★★
Rollover
★★★★★
Rollover risk
21.2%
2012 Ford Expedition SUV 4x4
Overall
★★★★★
Frontal crash
★★★★★
Side crash
★★★★★
Rollover
★★★★★
Rollover risk
19.8%
2012 Ford Expedition SUV 4x2
Overall
★★★★★
Frontal crash
★★★★★
Side crash
★★★★★
Rollover
★★★★★
Rollover risk
21.2%
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
Expedition 2WD FFV FFV
16mpg combined
City / highway
14 / 20 mpg
Fuel
Regular Gasoline
5.4 L · 8 cyl · Automatic 6-spd · Rear-Wheel Drive · about $4,200/year to fuel
Expedition 4WD FFV FFV
15mpg combined
City / highway
13 / 18 mpg
Fuel
Regular Gasoline
5.4 L · 8 cyl · Automatic 6-spd · Part-time 4-Wheel Drive · about $4,450/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Aug 10, 2026Vehicle speed control vehicle shifting erratically and shows fuel mileage low and loss of speedometer
Aug 10, 2026Vehicle speed control vehicle shifting erratically and shows fuel mileage low and loss of speedometer
Apr 4, 2026 · 166,000 milesPower train The contact owns a 2012 Ford Expedition. The contact stated that while his wife was driving 30 MPH, the transmission unexpectedly downshifted, causing the occupants to lunge forward. The tires squealed and the wheels locked up. The vehicle was turned off but failed to restart. No warning light was illuminated. The contact stated the failure was associated with NHTSA Campaign Number: 16V248000 (Power Train). A tow truck company was contacted, and was able to restart the vehicle, but the failure persisted. The local dealer was contacted and confirmed that there was no recall coverage associated with the VIN. The vehicle was not diagnosed or repaired. An attempt was made to contact the…
Feb 23, 2026Power train While exiting the freeway at approximately 45 to 50 mph, the transmission downshifted to 1st gear locking up the tires.
Nov 9, 2025Vehicle speed control The speedometer will quit working and the vehicle will not shift out of 1st gear, if you can work through it it will start throwing error messages such as zero miles to empty, tire moniter system fault, etc. This is a very dangerous situation especially in high traffic areas. There was a customer satisfaction program on it but only up to 150,000 miles. This program should last the life of the vehicle, also, if it was fixed before ownership, why did it go bad again
Oct 13, 2025Power train Over a period of time this problem is occurring more often. The vehicle will downshift into first gear. I pull over check engine light is on. I turn off wait turn back on and no problem for awhile. Within the last month this has occurred many times . Each time the check engine light comes on but also now the advance track light. Each time I have the same codes pulled. Driving on the highway with my daughter at 65mph it downshifted and the back tires locked up . Vehicles had to swerve to miss us. The check engine light was on advance track light same codes pulled. The dealership said itâs not in the recall even though it was built in Jefferson co Kentucky 9/2011. I donât understand why…
Sep 10, 2024 · 78,000 milesBack over prevention The contact owns a 2012 Ford Expedition. The contact stated that the image displayed on the back over prevention screen was either upside down, distorted, static only, or completely black. The failure was intermittent. During the failure, the contact was able to restart the vehicle to fix the image; however, the fix was intermittent. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The contact researched and found information on NHTSA Campaign Number: 25V270000 (Back Over Prevention); however, the VIN and model year was not included. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 78,000.
Aug 11, 2025Vehicle speed control I was driving my 2012 expedition and suddenly the vehicle went from doing 60 to 40 immediately the tires squealed and threw me into the right lane . This vehicle transmission has a recall for down shifting and power train issues. My vin number does not fit the Recall but my vehicle has all the symptoms of multiple recalls and is not safe to drive . Had i not known how to drive i and my daughter would be in the hospital due to the faulty transmission lead frame and power train . I contacted Ford head quarters they were no help even though there is clearly a recall . I also took the truck to ford of valparaiso and had to pay the 1,000 dollars for the lead frame to be replaced which was in the…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
RQ17010 · opened Dec 25, 2017 · closed Oct 22, 2019 · led to recall 19V075000Unexpected Transmission Downshift The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims…
