The 2008 Ford Expedition has 4 safety recalls and 146 owner complaints on file with NHTSA. The most-reported problem area is structure (34 complaints).
Recalls4safety recalls
Complaints146filed by owners
Crashes · fires24 · 2reported in complaints
Injuries · deaths20 · 2reported in complaints
2008 Ford Expedition in an NHTSA crash test
Safety recalls
Tires › Pressure monitoring and regulating systems
Problem: FORD IS RECALLING 158 MY 2008 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH A TIRE PRESSURE MONITORING SYSTEM (TPMS) AND THE LIMO BUILDERS PACKAGE FOR FAILING TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, Z"TIRE PRESSURE MONITORING SYSTEMS." THE TIRE PRESSURE WAS INCREASED FROM 35 PSI TO 40 PSI WITHOUT A COMMENSURATE UPDATE TO THE TPMS CALIBRATIONS.
Risk: THE TPMS INDICATOR LIGHT WILL NOT ILLUMINATE WHEN A TIRE PRESSURE IS IS 25% BELOW THE 40 PSI VALUE STATED ON THE TIRE PLACARD LABEL OCCURS.
Fix: DEALERS WILL RECONFIGURE THE TPMS THRESHOLDS TO THE APPROPRIATE PRESSURES. THE RECALL BEGAN ON APRIL 23, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Latches/locks/linkages › Doors › Latch
NHTSA recall 08V058000 · Feb 5, 2008 · 123,632 vehicles
Problem: FORD IS RECALLING 123,632 MY 2007-2008 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES. THE DOOR HANDLE HOUSING EMBOSSMENT RETAINING THE BOTTOM OF THE INTERIOR DOOR HANDLE SPRING ON ALL SIDE DOORS MAY FRACTURE DURING NORMAL CUSTOMER USAGE. THIS CAN RESULT IN INSUFFICIENT SPRING FORCE TO RETURN THE HANDLE TO THE FULLY CLOSED POSITION. THE HANDLE MAY BE LOOSE CAUSING A RATTLE OR NOISE AND THE HANDLE MAY NOT RETURN TO THE FULLY CLOSED POSITION. THIS CONDITION MAY ALSO PROVIDE A DELAYED RESISTANCE WHEN ACTUATING THE HANDLE PRIOR TO OPENING THE DOOR.
Risk: IN THE EVENT OF A SIDE IMPACT CRASH, THE INTERIOR DOOR HANDLE MAY CAUSE THE DOOR LATCH TO OPEN INCREASING THE RISK OF INJURY TO A VEHICLE OCCUPANT.
Fix: DEALERS WILL REPLACE THE INTERIOR HANDLE SPRING ON ALL SIDE DOORS. THE RECALL BEGAN ON MARCH 5, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Service brakes, air › Antilock › Control unit/module
NHTSA recall 07E105000 · Dec 13, 2007 · 10,481 vehicles
Problem: CERTAIN CONTINENTAL AUTOMOTIVE ABS AND ESC CONTROL MODULES SOLD FOR INSTALLATION ON THE VEHICLES LISTED ABOVE. SOME OF THE HYDRAULIC VALVES IN THE ESC MODULE WERE BUILT WITH EXTRA CHECK BALLS.
Risk: THE EXTRA CHECK BALLS CAN RESTRICT THE FLOW OF BRAKE FLUID THROUGH THE VALVE AND CAUSE REDUCTION OF BRAKE FORCE.
Fix: EACH VEHICLE MANUFACTURER WILL FILE A DEFECT REPORT AND REMEDY PLAN FOR THEIR VEHICLES WHICH INCLUDED THESE MODULES AS ORIGINAL EQUIPMENT. VEHICLES WILL BE REPAIRED AT NO COST TO THE OWNER. OWNERS CAN CONTACT EITHER THEIR VEHICLE MANUFACTURER OR CONTINENTAL AUTOMOTIVE AT 248-393-5300 FOR FURTHER INFORMATION.
Air bags › Frontal › Driver side › Inflator module
NHTSA recall 07V541000 · Nov 21, 2007 · 45 vehicles
Problem: CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS SPECIFIED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE DRIVER AIR BAG MODULE MAY NOT HAVE BEEN PROPERLY ASSEMBLED.
Risk: THIS CONDITION MAY PREVENT THE DRIVER AIR BAG FROM PROPERLY DEPLOYING AND REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH.
Fix: DEALERS WILL REPLACE YOUR DRIVER AIR BAG MODULE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 20, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
NHTSA side barrier crash test
2008 Ford Expedition Extended 4-DR. w/SAB
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
★★★★★
Rollover risk
19.8%
2008 Ford Expedition 4-DR. w/SAB
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
★★★★★
Rollover risk
19.8%
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
Expedition 2WD
14mpg combined
City / highway
12 / 18 mpg
Fuel
Regular Gasoline
5.4 L · 8 cyl · Automatic 6-spd · Rear-Wheel Drive · about $4,800/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
Power train Automatic transmission; Automatic transmission › Lever and linkage › Floor shift
14
5
0
1
41,000 mi
Vehicle speed control
13
6
1
6
44,382 mi
Electrical system
9
0
0
0
94,000 mi
Unknown or other
9
5
0
2
96,000 mi
Visibility Power window devices and controls
7
1
0
0
25,000 mi
Electronic stability control (esc)
7
0
0
0
54,000 mi
Fuel/propulsion system
7
0
0
0
103,000 mi
Suspension Front › Macpherson strut
6
0
0
0
62,000 mi
Engine
5
0
0
0
96,000 mi
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Feb 1, 2026Suspension › Front › Macpherson strut Right Rear Rancho Strut failed. Available till I return it. Could have lost control of vehicle. Confirmed by mechanic. Inspected by mechanic. No warnings at all. Discovered issue Feb 2026. Installed June 2021.
Mar 23, 2023Electrical system I purchased this vehicle in March 2023 from a private owner from Craigslist that was listed at 130,000 miles. Iâm currently in the process of selling and found out through a car history report that my vehicle passed an emission inspection at 230,000 miles in February 2023 and was also purchased from an auction, a month before I purchased it. The owner did not give any of this information and tampered with the odometer. I ran a vehicle history report today August 20, 2025 and retrieved all of this information that was not presented to me during this transaction.
Jul 19, 2025 · crashService brakes The brake is so far left, it is unsafe to drive. It is in the position the clutch would in an a Manual transmission and my right foot has trouble moving that far over and its unsafe to use my left as i'm never braked with my left foot.
Jul 30, 2009Fuel/propulsion system Since I have owned this vehicle when ever you fill up with fuel when the gas pump clicks off fuel spews back out the filler tube. I have asked dealers if anyone else has this problem and am told no. I believe this is a safety hazzard when gasoline runs down the side of vehicle and onto the ground. Ford does not acknowlege and problem. I'm sure there are other vehicles with the same problem.
Dec 13, 2021Fuel/propulsion system When filling the gas tank, even at the slowest setting on the gas pump, when the pump clicks to indicate the tank is full, 5 seconds later the tank burps fuel everywhere and the tank is only 3/4 full. The fumes are a safety risk to people, the fuel on the ground is bad for the environment, and there have been instances when I have been sprayed with fuel. I took the vehicle to my local mechanic and they were not able to find anything wrong. I took the vehicle to the local Ford dealership and they indicated everything was working properly. I took the vehicle back to Ford again and I was told the only other possible thing to do would be to replace the fuel tank, but the fuel tank is not…
Dec 13, 2021Unknown or other One day, out of nowhere, my dash displayed âtire pressure sensor faultâ.
Feb 23, 2022Electrical system I received a 2008 Expedition Eddie Bauer edition as a birthday gift last October. By January, the passenger window completely quit working. One warm, sunny day, we decided to open the sunroof. We have never had issues with the sunroof malfunctions. A storm moved in and temperatures quickly dropped (we are on the TN/AL stateline, we get all four seasons in one day sometimes). The sunroof would NOT close. It would move forward maybe halfway and then back to completely open. We struggled for HOURS, had to purchase bags, duct tape, and several other items to close the opening. I had to purchase a hotel room for the night because there was no way it would stay in place for another 100 miles. The…
Feb 22, 2022 · 200,000 miles · crashUnknown or other The contact owns a 2008 Ford Expedition. The contact stated while driving approximately 25 MPH downhill, the brake pedal was depressed and the vehicle spun out of control. The rear-end of the vehicle clipped a telephone pole and spun around in the other direction, the vehicle then went down an embankment and crashed into a rock wall. The contact stated that the air bags deployed as needed. The contact stated that she had a fractured ankle but was unsure whether the injury was from the crash or prior to the crash. A police report was filed. The vehicle was towed to a tow yard and then towed to the contactâs grandmotherâs home. The vehicle was not repaired. The cause of the failure was…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
PE08060 · opened Oct 14, 2008 · closed Apr 9, 2009TIRE VALVE CRACKING ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES…
