1995 Dodge Grand Caravan recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Engine and engine cooling

  TL* THE CONTACT OWNS A 1995 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS JUMP STARTED AND TAKEN TO A DEALER WHO OFFERED NO ASSISTANCE. THE MANUFACTURER WAS CONTACTED AND THEY ALSO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000. UPDATED 12/20/11*LJ

  May 1, 2011 · 160,000 miles
• Tires › Tread/belt

  IN 2003 I BOUGHT 8 FUTURA PLUS TIRES MADE BY COOPER AND SOLD BY PEP BOYS. THEY WENT ON 2 DIFFERENT VEHICLES. ALL 8 EVENTUALLY SEPARATED. ONE WAS REPLACED BY ANOTHER FUTURA PLUS AND IT HAS JUST SEPARATED ALSO. EACH AROUND 20000 TO 30000 MILES OF USE. IN EACH INSTANCE PEP BOYS REFUSED TO ACKNOWLEDGE THE TIRES WERE SEPARATED EVEN THOUGH YOU CLEARLY COULD FEEL THE BUMP IN THE TIRE , AND DRIVING WITH THE TIRE CAUSED THE STEERING WHEEL TO ROCK BACK AND FORTH AS YOU TOOK OFF THE TO INCREASE TO A BAD VIBRATION. WITH SOME OF THE TIRES THEY REFUSED TO REPLACE THEM, AND I HAD TO GO TO ANOTHER STORE. THE LATEST INCIDENT , WAYNE DOUGLAS AT THE ORANGE PARK FL STORE REFUSED TO REPLACE THE TIRES AND TRIED…

  Jul 14, 2007 · 195 miles
• Vehicle speed control

  1995 DODGE GRAND CARAVAN WENT TO FULL THROTTLE AND NO BRAKES DUE TO A PLASTIC BREAK IN RESTRICTOR JAMMING IN THROTTLE BODY HOLDING VALVE OPEN. RESULT WAS FULL THROTTLE AND NO VACUUM FOR BRAKES. CAR WAS FINALLY STOPPED BY TURNING OFF IGNITION. *NM

  Sep 26, 2005 · 132,403 miles
• Seat belts › Rear/other

  AS I WAS BUCKLING MY CHILD INTO THE FAR REAR, CENTER SEAT, THE SEAT BELT DETACHED FROM THE SEAT, RENDERING THE SEATBELT UNUSABLE. A COUPLE OF WEEKS LATER, WHEN BUCKLING MY CHILD INTO THE FAR REAR, LEFT SEAT, THE LOCKING MECHANISM PART OF THE SEAT BELT DETACHED FROM THE SEAT, RENDERING THAT SEATBELT UNUSABLE AS WELL. NEITHER PART HAS BEEN REPAIRED OR REPLACED.*AK

  Sep 20, 2004
• Fuel system, gasoline › Fuel injection system › Fuel rail

  A CROSS OVER IN THE FUEL RAIL WAS LEAKING. RECALL 00V268000 WAS ISSUED ON THIS PROBLEM. CONSUMER WAS CONCERNED BECAUSE VEHICLE WAS SHOOTING OUT FUEL.WHEN IT FIRST STARTED HAPPENING IT WAS ON THE LEFT SIDE, AND CURRENTLY IT IS ON THE RIGHT SIDE. THERE WERE NO LIGHTS ILLUMINATING ON THE DASHBOARD. *AK

  Nov 1, 2002
• Fuel system, gasoline › Fuel injection system › Fuel rail

  FUEL INJECTION RACKS ON MY 1995 GRAND CARAVAN [XXX] SPLIT, SPILLING FUEL OVER ENGINE. I WAS TOLD THAT OTHER GRAND CARAVANS WERE COVERED BY A RECALL, BUT THAT MINE WAS NOT. FUEL RACKS WERE REPLACED AT A COST OF $560.71 BUT CHRYSLER REFUSES TO REIMBURSE ME EVEN THOUGH THIS FAILURE IS SIMILAR TO THE RECALL. I WOULD LIKE THE NHTSA TO RECONSIDER THE LIMITS OF ITS RECALL FOR THIS FAILURE ON GRAND CARAVANS.*AK UPDATED 07/25/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  Apr 30, 2004 · 174,802 miles
• Visibility › Defroster/defogger/hvac system › Rear window

  WHILE DRIVING AT APPROXIMATELY 55 MPH, WITH THE REAR DEFROSTER ON, BACK WINDOW BLASTED OUT OF THE TAILGATE. THERE WAS NO EVIDENCE OF FOUL PLAY, SUCH AS A PELLET GUN OR STONES.*AK

  Feb 9, 2004 · 150,000 miles
• Unknown or other

  TWO PROBLEMS EXIST WITH OUR GRAND CARAVAN--THE 1ST ONE, I DO NOT KNOW IF IT WOULD BE UNDER THE COMPUTER ASPECTS OF THE VAN OR NOT, BUT THE WINDSHIELD WIPERS COME ON FOR ONE SWIPE WHENEVER THEY WANT TO DO SO. WE TOOK THE VAN IN SHORTLY AFTER PURCHASE AND THEY SUPPOSIDLY PUT A PART ON IT TO CORRECT THE PROBLEM. IT DID NOT WORK, IT WAS DONE ONCE OR TWICE MORE AND TO NO AVAIL IT STILL SWEEPS THE WINDSHIELD AT RANDOM TIMES WITH THE SWITCH NOT IN THE ONE POSITION. WE HAVE HEARD OF THIS PROBLEM FROM OTHER DODGE GRAND CARAVAN OWNERS BUT HAVE NEVER SEEN THE ISSUE ADDRESSED. THE 2ND PROBLEM IS THAT THE HEADLIGHT COVERS ON THE FRONT OF THE VAN ARE VERY DISCOLOURED--TO THE POINT OF BEING YELLOW--THIS…

  Sep 15, 2003 · 60,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• STEERING COLUMN SEPARATIONClosed

  MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR…

  DP03002 · opened May 7, 2003 · closed Jul 22, 2003
• AIR BAG CIRCUIT/WINDSHIELD WIPER MOTORClosed

  There is no summary currently available

  PE97049 · opened Nov 18, 1997 · closed Mar 17, 1998
• INTEGRATED CHILD SEAT BELT LOCKUPClosedLed to recall 97I001000

  THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.

  EA97003 · opened Jan 31, 1997 · closed Aug 19, 1998
• INTEGRATED CHILD SEAT BELT LOCKUPClosed

  ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.

  SQ96016 · opened Sep 18, 1996 · closed Feb 4, 1997
• SAFETY BLT LATCH OPERATIONClosed

  There is no summary currently available

  PE96008 · opened Jan 25, 1996 · closed Jun 28, 1996