Model year record

1997 Dodge Grand Caravan recalls & problems

The 1997 Dodge Grand Caravan has 5 safety recalls and 583 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (125 complaints).

Recalls5safety recalls

Complaints583filed by owners

Crashes · fires29 · 39reported in complaints

Injuries · deaths37 · 1reported in complaints

Safety recalls

Air bagsNov 7, 2002

Frontal

Recall 02V2930001,500,521 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Risk: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Fix: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Fuel system, gasolineSep 13, 2000

Fuel injection system

Recall 00V2680001,163,000 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Fix: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Child seatAug 6, 1998

Child seat

Recall 98V185000157,000 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Risk: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Fix: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.

TiresNov 13, 1997

Bead

Recall 97V20000025,000 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Risk: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Fix: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.

Service brakes, hydraulicOct 29, 1996

Foundation components › Master cylinder

Recall 96V21500018,997 vehicles

Problem: THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Risk: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Fix: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1997 Dodge Grand Caravan

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Engine and engine coolingEngine › Gasoline; Engine › Gasoline › Belts and associated pulleys	125	2	26	0	94,483 mi
Electrical systemHorn; 12v/24v/48v battery	117	3	25	3	109,750 mi
Air bagsFrontal; Side/window	111	11	1	18	91,000 mi
Power trainAutomatic transmission; Automatic transmission › Park/neutral start interlock switch	85	4	0	2	102,000 mi
VisibilityWindshield wiper/washer; Windshield wiper/washer › Motor	66	1	0	0	105,000 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Rotor	60	3	2	1	101,000 mi
Vehicle speed controlAccelerator pedal; Cruise control	49	3	1	4	99,750 mi
SteeringHydraulic power assist system; Hydraulic power assist › Pump	40	1	6	0	135,995 mi
Fuel system, gasolineStorage › Tank assembly; Fuel injection system	31	1	4	2	113,500 mi
Exterior lightingHeadlights; Headlights › High/low beam dimmer switch	21	3	1	4	130,000 mi
SuspensionFront; Front › Macpherson strut	20	0	0	0	127,997 mi
StructureBody › Door; Body	18	0	0	1	149,883 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Service brakesFire
MY VAN WAS PARKED OUT SIDE LUCKYS ON MITALDA NEAR W MAUDE AVENUE IN SUNNYVALE CA 94086 I WAS USING THE WATER REFILLING STATION AND STARTED TO SMELL SMOKE WHEN I TURNED AROUND I IMIDEATLLY NOTICED THAT THE DRIVERS SIDE REAR TAILLIGHT WAS ON FIRE. NOT HAVING A FIRE EXTINGUISHER I TOOK THE BOTTLE OF WATER I HAD IN MY HANDS AND STARTED TO THROW WATER ON IT UNTIL THE FLAMES WENT OUT. WHAT IN THE HELL WOULD MAKE THAT HAPPEN? IS MY VAN UP FOR RECALL? I JUST PURCHASED THE VAN JUST A WEEK AGO. IT HAS BEEN A NIGHT MARE FOR ME NOT TO MENTION EXTREMELY COSTLY REPLACING EVERYTHING'S THAT'S BEEN GOING OUT. THE A/C CLUSTER THE DASH CLUSTER THE POWER WINDOW MOTOR. THE REAR VENT MOTOR. COUNTLESS BULBS AND…
Jul 21, 2020 · 158,182 miles
Engine
CAR SUDDENLY LOST POWER WHILE DRIVING ON THE FREEWAY AT 60MPH; ENGINE REMAINED ON. I PULLED OVER, TURNED OFF THE CAR, AND IT STARTED BACK UP AGAIN AND DROVE FINE FOR ABOUT 2 MILES. 'SERVICE ENGINE SOON' LIGHT CAME ON. WHEN IT LOST POWER AGAIN, I SLOWED AND THEN TRIED TO REACCELERATE, AND IT DROVE FINE FOR ABOUT 5 MILES, ENOUGH TO GET ME OFF THE FREEWAY AND TO A SAFE LOCATION. I CHECKED THE OIL AND TRANSMISSION LEVELS, WHICH WERE OK, AND THERE WAS NOTHING LEAKING UNDER THE CAR. WENT TO AN APPOINTMENT, AND CAME BACK TO THE CAR, WHICH STARTED UP AND DROVE OK FOR ABOUT A HALF MILE, THEN IT SHUT DOWN COMPLETELY AT A TRAFFIC LIGHT. THIS TIME IT WOULDN'T START BACK UP AGAIN, SO I PUSHED IT ONTO A…
Nov 26, 2019 · 104,233 miles
SteeringCrash
SERPENTINE BELT COMES OFF WHILE DRIVING IN SNOW CAUSING LOSS OF POWER STEERING ON SLIPPERY ROAD SURFACES. LOSS OF VEHICLE CONTROL AND ABILITY TO REGAIN VEHICLE CONTROL WAS COMPROMISED BY LACK OF STEERING ASSIST CAUSING THE VEHICLE TO LEAVE THE ROADWAY. I CONTACTED CHRYSLER AND THEY SAID THERE IS NO RECALL FOR MY VEHICLE.THIS WAS A VERY DANGEROUS SITUATION AS A SCHOOL BUS WAS NEAR MY VEHICLE WHEN THIS INCIDENT HAPPENED. THIS ISSUE NEEDS TO BE ADDRESSED AND A RECALL SHOULD BE MANDATED. *TR
Dec 15, 2016 · 271,000 miles
Service brakes
PART 1.... I USED TO BE A MECHANIC AND TOW TRUCK OPERATOR. MY MINI VAN "LIKE MOST OTHERS" IS USUALLY DRIVEN BY A FEMALE & WITH A LOAD OF CHILDREN. IF DRIVING IN RAIN OR THROUGH A WATER PUDDLE THE BELT JUMPS OFF CAUSING LOSS OF POWER STEERING OVERHEATING BATTERY DRAIN ETC, IS A DANGEROUS EVEN DEADLY PROBLEM, IF A TURN IS NEEDED AT THE TIME THIS BELT JUMPS OFF, EVEN A STRONG HEALTHY MAN CAN LEAVE THE LINE OF INTENDED TRAVEL AND HIT WHAT EVER IS IN THE WAY, A CURB, A PEDESTRIAN OR EVEN CAUSE A HEAD ON COLLISION. THIS MOSTLY HAPPENS DURING RAINY/NASTY DAYS & BECAUSE OF THE COMPLEXITY OF REPLACING THE BELT, AND THE DAMAGE THAT IS CAUSED WHEN IT COMES OFF, THE VEHICLE USUALLY REQUIRES A TOW 4…
Jul 21, 2015
Service brakes
PART 1 1/2 THE GAS LINE DECAYING AND THE SUSPENSION STRUT MOUNTS RUSTING AWAY, BOTH OF THESE ARE DEADLY, A RUSTY/CORRODED BREAK LINE WILL JUST LEAK A DROP AT THE TIME, MOST PEOPLE JUST REFILL THE FLUID RESERVOIR AND NEVER THINK ABOUT AGAIN, EVENTUALLY THE BREAK LINE FAILS ALL AT ONCE, THIS IS BECAUSE YOU ACTUALLY PUT MORE PRESSURE ON THE LINES THAN USUAL AND THE WEAK SPOT RUPTURES LIKE A WEAK SPOT IN A BALLOON WOULD. THAT MEANS THAT YOU WERE IN A BAD SITUATION ALREADY AND NOW YOU DON'T HAVE ANY BREAKING POWER AT ALL. WHAT DO YOU THINK HAPPENS NEXT??? ALL BREAK LINES ARE STAINLESS STEAL SO AS TO RESIST RUST AND CORROSION, THE ONLY REASON A BREAK LINE FAILS IN THIS LITTLE AMOUNT OF TIME IS…
Jul 21, 2015
Service brakes
PART 1 1/2 THE GAS LINE DECAYING AND THE SUSPENSION STRUT MOUNTS RUSTING AWAY, BOTH OF THESE ARE DEADLY, A RUSTY/CORRODED BREAK LINE WILL JUST LEAK A DROP AT THE TIME, MOST PEOPLE JUST REFILL THE FLUID RESERVOIR AND NEVER THINK ABOUT AGAIN, EVENTUALLY THE BREAK LINE FAILS ALL AT ONCE, THIS IS BECAUSE YOU ACTUALLY PUT MORE PRESSURE ON THE LINES THAN USUAL AND THE WEAK SPOT RUPTURES LIKE A WEAK SPOT IN A BALLOON WOULD. THAT MEANS THAT YOU WERE IN A BAD SITUATION ALREADY AND NOW YOU DON'T HAVE ANY BREAKING POWER AT ALL. WHAT DO YOU THINK HAPPENS NEXT??? ALL BREAK LINES ARE STAINLESS STEAL SO AS TO RESIST RUST AND CORROSION, THE ONLY REASON A BREAK LINE FAILS IN THIS LITTLE AMOUNT OF TIME IS…
Jul 21, 2015
Service brakes
PART 2 I'VE READ ON HERE THAT GATES HAS A BELT/PULLEY FIX FOR THIS PROBLEM. IF THEY HAVE ONE, CHRYSLER CAN MAKE ONE. THIS IS A DANGEROUS PROBLEM THAT CAN HAPPEN ANY TIME TO MANY DODGE VANS, IT RESULTS IN OTHER DAMAGES, SUDDEN LOSS OF POWER STEERING CONTROL, POSSIBLE INJURY EVEN DEATH TO MANY PEOPLE AT ONE TIME. MANY OTHER VEHICLES HAVE SERPENTINE BELTS WITHOUT THIS PROBLEM SO IT CAN BE FIXED. IT'S A REPEATED DESIGN FLAW & SHOULD BE CORRECTED IMMEDIATELY. A NTSB RULE GOES SOMETHING LIKE THIS "A COMPANY IS RESPONSIBLE FOR ANY FORESEEABLE PROBLEMS IN THEIR PRODUCT" THE SAME GOES FOR THE BRAKE LINES CORRODING ENOUGH FOR FAILURE TO OCCUR IN JUST A FEW YEARS, THIS IS ALSO UNACCEPTABLE. THIS IS A…
Jul 21, 2015
Electrical system › Instrument cluster/panel
TL* THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. WHILE DRIVING AT 62 MPH, THE VEHICLE STALLED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INSTRUMENT CLUSTER AND THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 77,000.
Jun 29, 2015 · 77,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

AIR BAG CLOCKSPRINGClosedLed to recall 02V293000
There is no summary currently available
EA01007 · opened Feb 21, 2001 · closed Nov 22, 2002
DC MINIVAN FUEL INJECTOR RAIL LEAKClosedLed to recall 00V268000
There is no summary currently available
RQ00008 · opened Mar 9, 2000 · closed Mar 18, 2002
POST COLLISION FUEL SYSTEMClosed
EA99013 · opened Jun 11, 1999 · closed Aug 10, 2001
POST-COLLISION FUEL SYSTEM INTEGRITYClosed
There is no summary currently available
PE99010 · opened Feb 3, 1999 · closed Jun 11, 1999
INTEGRATED CHILD SEAT BELT LOCKUPClosedLed to recall 97I001000
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
EA97003 · opened Jan 31, 1997 · closed Aug 19, 1998
INTEGRATED CHILD SEAT BELT LOCKUPClosed
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
SQ96016 · opened Sep 18, 1996 · closed Feb 4, 1997