Model year record

2006 Dodge Grand Caravan recalls & problems

The 2006 Dodge Grand Caravan has 4 safety recalls and 284 owner complaints on file with NHTSA. The most-reported problem area is steering (61 complaints).

Recalls4safety recalls

Complaints284filed by owners

Crashes · fires12 · 3reported in complaints

Injuries · deaths21 · 0reported in complaints

Safety recalls

SeatsJul 27, 2010

Seats

Recall 10V3380002 vehiclesopened after NHTSA action (ODI)

Problem: DRIVING SPECIALTIES LTD IS RECALLING 2 MODEL YEAR 2006 AND 2007 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
Risk: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Fix: DRIVING SPECIALTIES WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 28, 2010. OWNERS MAY CONTACT DRIVING SPECIALTIES AT 1-707-553-1515.

Air bagsJan 11, 2010

Frontal › Sensor/control module-inactive

Recall 10V008000308,950 vehiclesopened after NHTSA action (ODI)

Problem: CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.
Risk: IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.
Fix: CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

VisibilityDec 11, 2007

Glass, side/rear

Recall 07E1040001,657 vehicles

Problem: CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
Fix: SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

VisibilityMar 8, 2006

Windshield wiper/washer › Motor

Recall 06V067000268,800 vehicles

Problem: ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.
Risk: DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.
Fix: DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2006 Dodge Grand Caravan

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
SteeringRack and pinion; Rack and pinion › Rack	61	0	0	1	53,000 mi
Air bagsFrontal; Frontal › Sensor/control module	55	8	0	9	50,000 mi
Electrical system12v/24v/48v battery	38	1	3	3	84,000 mi
StructureBody › Door; Body	36	1	2	6	62,521 mi
Exterior lightingTurn signal; Turn signal › Switch	29	0	1	0	78,000 mi
Fuel/propulsion system	28	0	0	0	105,000 mi
Latches/locks/linkagesDoors › Latch	22	0	0	0	58,500 mi
Engine	16	1	0	1	95,600 mi
Engine and engine coolingEngine; Cooling system	15	0	0	0	60,625 mi
Power trainAutomatic transmission	12	1	0	1	66,500 mi
Service brakes, hydraulicFoundation components › Disc › Rotor; Foundation components › Disc › Caliper	10	1	0	0	29,001 mi
VisibilityWindshield wiper/washer › Motor; Glass, side/rear	9	0	0	0	44,232 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Engine and engine cooling › Exhaust system › Emission control › Gas recirculation valve (egr valve)
The contact owns a 2006 Dodge Grand Caravan. The contact stated that when the vehicle was purchased in 2010, the vehicle was missing the EGR (Exhaust Gas Recirculation) valve. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle idled roughly, jerked and stalled while driving. The check engine warning light was illuminated. The vehicle was taken to Auto Zone, where it was diagnosed with power train failure. The vehicle was taken to the dealer, where the contact was informed that the vehicle was missing the Exhaust Gas Recirculation (EGR) valve. The contact was provided…
Nov 5, 2013 · 122,000 miles
Power train
The contact owns a 2006 Dodge Grand Caravan. The contact stated while driving 5-10 MPH and pulling out of the parking lot, the vehicle stalled. The contact was able to coast into a gas station. The contact stated that the engine was running, but the vehicle failed to respond while depressing the accelerator pedal. The vehicle was towed to the residence. The contact stated that the failure occurred while driving near the residence. The contact stated that upon turning off and restarting the vehicle, the vehicle responded as needed. Additionally, the contact stated that the sliding doors had failed to close and lock automatically and sometimes opened while driving. Additionally, the contact…
Apr 30, 2025 · 130,000 miles
Service brakes
My complaint involves more than one incident...it is the braking system on this vehicle. One incident was in Panama City Beach, Florida. My entire braking system locked up and I had numerous items replaced. Another more recent incident happened in Alabama. My left front brake heated up to the point it smelled like the vehicle was on fire. I have had several calipers and rotors replaced, numerous brake pads and not all of these repairs has been done by the same garage. I read complaints from others about the manufacturers brake system is too small for this style vehicle. They have experienced the same problems I have had. I bought this vehicle in 2015 and I have 155,000 miles on it. I have…
Mar 27, 2024
Air bags
The contact owns a 2006 Dodge Grand Caravan. The contact stated that on several occasions, the air bag warning light illuminated for two minutes and then disappeared. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 146,032.
May 16, 2023 · 146,032 miles
Exterior lighting
The headlights and taillights come on randomly throughout the day and night while the car is parked and off. The warning dings for accidentally leaving your lights on happens every time you open the doors even though the lights are off. This has been going on since we got the vehicle.
Jun 19, 2021
Air bags
LIGHTS GO OUT WHEN THE RAIN GETS UP UNDER THE CAR FROM SPLASHING ON THE ROAD. YOU HAVE TO PULL OVER TO THE SIDE OF THE ROAD, TURN IT OFF AND TURN IT BACK ON SEVERAL TIMES AND IT STAYS ON FOR A SHORT TIME. PROCEDURE IS REPEATED AGAIN. ONLY IN RAINY WEATHER AND OREGON GETS A LOT OF SPORADIC RAIN. ALSO, THE IGNITION TENDS TO TURN THE AIRBAG LIGHTS ON AND OFF WHENEVER I TURN A CORNER LEFT OR RIGHT OF HIT A BUMP.
Jan 15, 2020 · 168,101 miles
Engine
TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 45 MPH, THE OIL PRESSURE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. ON NOVEMBER 9, 2019, WHILE DRIVING 55 MPH, WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS LOSING SPEED, BUT WAS ABLE TO BE PULLED OVER TO THE SIDE OF THE ROAD. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE CONTACT CALLED THE POLICE DUE TO HER DISABLED HUSBAND BEING IN THE COLD FOR OVER TWO HOURS. A POLICE REPORT WAS FILED. HE WAS…
Dec 1, 2018
Unknown or other
SLIDING DOOR LOCK ACTUATOR FROZE UP.THIS RENDERSTHE SLIDING DOOR COMPLETELY INOPERABLE.IF THAT DOOR WAS NEEDED FOREGRESS,IT WOULDNT BE AVAILABLE!!
Nov 10, 2019

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Engine Stall After RefuelingClosed
This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these…
DP14002 · opened Sep 5, 2014 · closed Apr 6, 2015
Loss of headlight illuminationClosed
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA,…
EA11010 · opened Sep 6, 2011 · closed Nov 29, 2012
Fleet Vehicle Recall Completion AuditClosed
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and…
AQ10001 · opened Nov 18, 2010 · closed Dec 28, 2015
FRONT AIR BAG CRASH SENSOR FAILUREClosedLed to recall 10V008000
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE…
RQ09003 · opened Jul 1, 2009 · closed Feb 18, 2010
FRONT AIR BAG CRASH SENSOR FAILUREClosedLed to recall 07V192000
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE…
EA06003 · opened Mar 8, 2006 · closed May 22, 2007