Model year record

1997 Ford E-350 recalls & problems

The 1997 Ford E-350 has 5 safety recalls and 79 owner complaints on file with NHTSA. The most-reported problem area is tires (25 complaints).

Recalls5safety recalls

Complaints79filed by owners

Crashes · fires5 · 6reported in complaints

Injuries · deaths9 · 2reported in complaints

Safety recalls

Vehicle speed controlOct 13, 2009

Vehicle speed control

Recall 09V3990004,500,000 vehiclesopened after NHTSA action (ODI)

Problem: FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Fix: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Vehicle speed controlFeb 4, 2008

Cruise control

Recall 08V051000225,000 vehicles

Problem: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Risk: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Fix: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Vehicle speed controlAug 3, 2007

Vehicle speed control

Recall 07V3360003,600,000 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Fix: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Equipment adaptive/mobilityNov 26, 2004

Equipment adaptive/mobility

Recall 04V5620001,660 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.
Risk: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.
Fix: DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.

Fuel system, gasolineApr 5, 2001

Storage › Tank assembly

Recall 01V114000151,000 vehicles

Problem: VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL TANK COULD DEVELOP A CRACK WHERE IT CONTACTS THE FRAME CROSS MEMBER. IF THE FUEL TANK CRACKS, FUEL LEAKAGE COULD OCCUR.
Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Fix: DEALERS WILL INSPECT THE FUEL TANK AND, IF CRACKED, WILL REPLACE THE TANK. INSULATOR PADS WILL BE INSTALLED ON ALL VEHICLES TO REDUCE THE STRESS LEVELS IN THE FUEL TANK. OWNER NOTIFICATION BEGAN APRIL 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
TiresTread/belt; Sidewall	25	3	0	6	—
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components	15	0	0	0	—
Engine and engine coolingEngine; Engine › Gasoline	15	0	4	0	108,817 mi
SuspensionRear › Springs › Leaf spring assembly; Front	6	1	0	2	—
Vehicle speed control	4	1	1	0	—
Electrical systemWiring; Horn	4	0	1	0	—
Power trainAutomatic transmission; Driveline › Driveshaft	4	0	0	0	—
Fuel system, gasolineDelivery › Hoses, lines/piping, and fittings; Storage › Tank assembly › Filler pipe and cap	4	0	0	0	62,500 mi
StructureBody; Frame and members	3	0	0	0	—
Air bags	3	0	0	1	—
Parking brake	2	0	0	0	—
VisibilityRearview mirrors/devices; Defroster/defogger/hvac system	2	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Structure › Body
The rear passenger compartment outside and inside door handles broke such that rear seating passengers cannot exit the vehicle and are trapped inside. In case of an accident, the emergency responders will have to resort to drastic time consuming measures such as ripping the doors off to save the trapped passengers. Apparently all years of Ford Econoline vans have this dangerous problem because there are numerous fix it videos all over the internet showing how to replace the cheap handle-latch failure prone plastic parts with non-breakable METAL parts.
Nov 1, 2023
Air bags
AIR BAG LIGHT CAME ON AND BRAKE LIGHT CAME ON
Apr 3, 2020
Structure › Body
12/11/2019
Dec 11, 2019 · 11 miles
Air bags
THIS YEAR BOTH THE AIRBAGS IN MY 1997 FORD E350 VAN HAVE SPONTANEOUSLY DEPLOYED ON TWO SEPARATE OCCASIONS--EACH OCCURRING WHILE THE VAN WAS IN 'PARK'. ON 1/31/18 THE DRIVER'S BAG DEPLOYED WHEN THE VAN WAS WARMING UP IN A PARKING LOT. MY ADULT DAUGHTER STARTED THE VAN, PLUGGED HER PHONE INTO THE TOP CAR ADAPTER, AND ABOUT A MINUTE LATER (THE VAN WAS STILL PARKED) THERE WAS A BIG 'BOOM' FROM UNDER HER SEAT AND HER SEATBELT TIGHTENED. WITH THE SEATBELT STILL ON, SHE LEANED TO HER RIGHT TO SEE WHAT WAS CAUSING THE SMOKE FROM UNDER HER SEAT WHEN SUDDENLY THE DRIVER'S STEERING WHEEL AIRBAG DEPLOYED. THANKFULLY SHE WAS SPARED ANY INJURY. SHE HAD THE VAN TOWED TO A FORD DEALERSHIP, BUT THEY COULD…
Jan 31, 2018 · 89,820 miles
Air bags1 injury
MY VEHICLE HAD BEEN PARKED FOR ABOUT THREE OR FOUR WEEKS AND I WENT TO START IT UP TO RUN THE ENGINE AND CHARGE THE BATTERIES AS I DID NOT PLAN TO USE IT FOR ANOTHER FEW WEEKS. WHEN I TURNED THE KEY THE DRIVER SIDE AIRBAG DEPLOYED AND HIT ME HARD. ALSO THE PASSENGER SIDE SEAT BELT BUCKLE PRETENSIONER FIRED OFF BREAKING THE HOUSING. THE VEHICLE WAS STATIONARY BEFORE, DURING, AND AFTER THE INCIDENT. THERE HAS NEVER BEEN AN ACCIDENT AND I CAN SEE NO DAMAGE TO THE OUTSIDE AT ALL. I HAVE CONTACTED FORD AND THEY WILL NOT ASSIGN A CASE NUMBER UNTIL IT IS INSPECTED AND CHECKED BY A FORD DEALER. THE CLOSEST FORD DEALER THAT SAID THEY WERE CAPABLE OF DOING THIS IS BOOKED UP AND CAN NOT LOOK AT IT FOR…
Oct 5, 2017 · 60,000 miles
Vehicle speed control
CRUISE CONTROL STUCK ON WHEN TURNED OFF, THEN WOULD WORK ONLY SOMETIMES & STEERING VIBRATED. *TR
Oct 29, 2013 · 47,333 miles
Tires
TL* THE CONTACT OWNS A 1997 FORD E-350 EQUIPPED WITH COOPER ADVENTURE HT TIRES (N/A), SIZE 265/75/16R. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE TIRE TREAD SEPARATED ON THE REAR DRIVER SIDE TIRE. THE FAILURE HAD OCCURRED PREVIOUSLY WITH FOUR OTHER TIRES, WHICH HAD BEEN REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 15,000. THE VEHICLE FAILURE MILEAGE WAS 76,000. THE VIN WAS NOT AVAILABLE. THE TIRE #8 WENT BAD. THE CONSUMER STATED THE TIRE REPLACEMENT ALSO WENT BAD.
May 9, 2013 · 76,000 miles
Tires
WHILE DRIVING AT 52 MPH (PULLING A SMALL U-HAUL TRAILER) THE LEFT REAR TIRE ON MY VAN SUFFERED COMPLETE TREAD SEPARATION. THE TREAD SUBSEQUENTLY WRAPPED AROUND THE AXLE AND HAD TO BE PRIED LOOSE. THE TREAD WAS WHOLE AND INTACT (A COMPLETE CIRCLE), BUT THE CARCASS OF THE TIRE SHREDDED. THE TIRE IS (WAS( A UNIROYAL LT 245/75 R16 APPROXIMATELY 4 YEARS OLD. I MANAGED TO PULL TO THE SIDE OF THE FREEWAY ON MY RIM. THIS OCCURRED ON SATURDAY, AUGUST 25. *TR
Aug 25, 2012 · 84,488 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

HVAC Switch FailuresClosed
This investigation was opened based on one complaint and reports from four transportation fleets alleging 182 blower motor control switch failures.ODI was concerned that these melting and burning switches could lead to an open flame that could spread throughout the vehicle.After a comprehensive review of all data related to overheating blower motor control switches in the subject vehicles, ODI did not identify the existence of a safety defect trend.ODI reviewed 1,036 complaints, claims, and field reports of failed blower motor control switches and determined that only two fires were likely to have been caused by a failing subject blower motor control switch.This represents a failure rate of 0.2 R/100K on a population of 1,076,975 vehicles that have been in service for up to 14 years.ODI has found that when the subject switches do fail and begin to melt, they are constructed in a manner…
EA10003 · opened Apr 13, 2010 · closed Mar 5, 2012
HVAC Switch FailuresClosed
ODI has received 1 complaint and reports from 4 transportation fleets alleging 182 switch failures.Each fleet operates mini buses built on a Ford E350 or E450 cutaway chassis.The OEM HVAC blower switches have melted, smoked, burned or experienced open flame and become inoperable on vehicles in each fleet.Some drivers have reported a burning smell or smoke coming from the dash.One fleet reported a vehicle fire.No injuries were sustained.However, the bus was carrying special needs children when the driver noticed smoke coming from the dash.The driver was able to evacuate the children prior to the vehicle becoming engulfed in flames.This PE has been upgraded to an Engineering Analysis (EA) to determine if the blower motor switch failures create a situation where a vehicle fire is possible and presents a safety risk to the driver and other passengers.
PE09055 · opened Dec 7, 2009 · closed Apr 21, 2010
SPARK PLUG EJECTION FROM CYLINDER HEADClosed
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…
DP05005 · opened Sep 22, 2005 · closed Jan 4, 2006
ALLEGED BRAKE HOSE FAILURESClosed
FORD HAS RECEIVED NO OWNER REPORTS OF FAILURE, OTHER THAN THE FOUR ODI REPORTS THAT CAME FROM A SINGLE FLEET IN NEW YORK STATE.FORD ALSO REPORTS THAT IT HAS RECEIVED NO FIELD REPORTS AND DID NOT IDENTIFY ANY WARRANTY CLAIMS ALLEGING THE SUBJECT PROBLEM.FORD ESTIMATES THAT THE 86,910 SUBJECT VEHICLES (THAT HAVE OVER 6 YEARS EXPOSURE), HAVE ACCUMULATED OVER SIX BILLION MILES OF SERVICE AND THAT THE VIRTUAL LACK OF REPORTS INDICATES THAT THERE IS NO DEFECT TREND.BASED ON FORD'S DATA, A SAFETY RELATED DEFECT TREND DOES NOT APPEAR TO EXIST AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THE SUBJECT VEHICLES IF WARRANTED BY THE CIRCUMSTANCES.ODI WILL CONTINUE TO MONITOR FIELD REPORTS FOR THIS…
PE02070 · opened Oct 1, 2002 · closed Jan 9, 2003