The 2002 Ford E-350 has 5 safety recalls and 53 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (17 complaints).
Recalls5safety recalls
Complaints53filed by owners
Crashes · fires2 · 1reported in complaints
Injuries · deaths10 · 0reported in complaints
Safety recalls
Vehicle speed control
NHTSA recall 09V399000 · Oct 13, 2009 · 4,500,000 vehicles · opened after NHTSA action (ODI)
Problem: FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Fix: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Vehicle speed control › Cruise control
NHTSA recall 08V051000 · Feb 4, 2008 · 225,000 vehicles
Problem: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Risk: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Fix: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Vehicle speed control
NHTSA recall 07V336000 · Aug 3, 2007 · 3,600,000 vehicles · opened after NHTSA action (ODI)
Problem: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Fix: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Equipment adaptive/mobility
NHTSA recall 04V589000 · Dec 15, 2004 · 501 vehicles · opened after NHTSA action (ODI)
Problem: ON CERTAIN VANS BUILT ON FORD E250/E350 CHASSIS AND EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.
Risk: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.
Fix: DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR ACCUBUILT AT 419-222-1501.
Equipment › Other › Labels
NHTSA recall 04V232000 · May 13, 2004 · 28,456 vehicles
Problem: CERTAIN VANS AND WAGONS FAIL TO CONFORM TO THE REQUIREMENTS OF PART 567, "CERTIFICATION." FOR CERTAIN 2003 E250 VANS BUILT WITH LT225/75R16E TIRES, THE REAR AXLE RATING IS INCORRECTLY LISTED ON THE LABEL. IN ADDITION, THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES ON CERTAIN 2002 E350 WAGONS AND FOR THE FRONT TIRES ON CERTAIN 2002 E250 VANS BUILT WITH THESE TIRES.
Risk: FAILURE TO FOLLOW PROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION RECOMMENDATION CAN RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Fix: OWNERS WILL BE PROVIDED WITH SUPPLEMENTARY TIRE LABELS CONTAINING CORRECT INFORMATION AND INSTALLATION INSTRUCTIONS. IF AN OWNER SO DESIRES, THEIR DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON JULY 8, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Engine and engine cooling Engine; Engine › Gasoline
17
0
0
0
95,000 mi
Tires Tread/belt; Sidewall
8
1
0
10
42,800 mi
Electrical system Ignition; Wiring
6
0
1
0
96,446 mi
Service brakes, hydraulic Antilock/traction control/electronic limited slip
4
0
0
0
—
Fuel system, diesel
4
0
0
0
65,000 mi
Engine
4
0
0
0
110,000 mi
Seat belts Front › Retractor
3
0
0
0
—
Suspension Front
3
0
0
0
—
Steering Hydraulic power assist system
2
0
0
0
—
Vehicle speed control
2
0
0
0
—
Structure Frame and members; Body
2
1
0
0
—
Fuel/propulsion system
2
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Jul 17, 2018 · 114,000 milesEngine HEAD ON VEHICLE STRIPPED BECAUSE OF THE WAY IT IS MADE. THERE WAS A RECALL ON REGULAR E350 BUT MINE IS AN RV. IT WAS IN MOTION WHEN THE SPARK PLUG POPPED OUT WHILE DRIVING DOWN THE HIGHWAY ON I-65 IN BIRMINGHAM ALABAMA.
Feb 1, 2010Engine THIS 350 ECONOLINE, 8CYL., EXTENDED BODY VAN WAS PURCHASED NEW, AND I AM THE ORIGINAL OWNER. THE VEHICLE HAS ONLY 120K MILES ON IT SINCE 2002. BEGINNING SEVERAL YEARS AGO, MY MECHANIC COMPLAINED OF SEVERE FRAME EROSION, HAVING HAD TO REINFORCE AND RE-WELD SEVERAL PARTS BACK ONTO THE FRAME, INCLUDING BUT NOT LIMITED TO THE BRACKETS WHICH SUPPORT THE REAR LEAF SPRINGS. (TWO OCURRANCES-- LEFT AND RIGHT SIDES). LAST WEEK, MY EMPLOYEE COMPLAINED OF SOME REAR END SWAYING AT MODERATE SPEED CORNERING. WE DISCOVERED A CROSS-TIE CONNECTION BETWEEN THE SIDE RAILS AT THE REAR OF THE VEHICLE'S FRAME HAD ROTTED AWAY, THUS CAUSING SOME UNWANTED FRAME MOVEMENT. IF IT WEREN'T FOR A HEAVY-DUTY TOWING PACKAGE…
Jan 18, 2017 · 120,000 milesFuel/propulsion system BLOWING OUT SPARK PLUGES.
Aug 1, 2015 · 240,000 milesFuel/propulsion system WHILE TRAVELING ON AN INTERSTATE HIGHWAY, THE VAN STARTED SHOWING SYMPTOMS OF FUEL STARVATION AND WITH THE FAMILY AND A SEMI ON MY BUMPER THINGS GOT QUITE HAIRY AND STARTED AND ARGUMENT WITH MY WIFE! I EXITED THE HIGHWAY AND PUT CLEAN DIESEL FUEL AND FUEL ADDITIVE TO GET ME BACK HOME; THIS DID NOT WORK AS THE VAN ACTED UP AGAIN SEVERAL MILES DOWN THE ROAD. AFTER STOPPING AND STARTING NUMEROUS TIMES ON A SIDE STREET, I GOT TO A PLACE WHERE I COULD CHANGE THE FUEL FILTER; I NOTICED THAT IT WAS FULL OF RUST AND ALUMINUM FLAKES. THE VAN WOULD NOT MOVE ANY FURTHER, I HAD TO TRAILER IT HOME, THE NEXT DAY. UPON FURTHER INVESTIGATION, I DISCOVERED THAT THE ALUMINUM COATING THE FUEL TAKE HAD COME…
Jul 14, 2015 · 108,362 milesTires › Tread/belt TL* THE CONTACT OWNS A 2002 FORD E-350 EQUIPPED WITH MICHELIN LT24575R16 TIRES, SIZE: 245/756/16 (NA). WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT FELT VIBRATIONS FROM THE FRONT TIRES. THE CONTACT NOTICED THAT THE TREAD FROM THE FRONT PASSENGER SIDE TIRE WAS SEPARATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE TIRE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13T012000 (TIRES). THE VIN WAS UNKNOWN. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 108,362 AND THE APPROXIMATE TIRE FAILURE MILEAGE WAS 20,000.
Jun 23, 2014 · 60,000 milesEngine TL*THE CONTACT OWNS A 2002 FORD E-350. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT ABLE TO RESTART. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.
Feb 17, 2011 · 110,000 milesEngine TL* THE CONTACT OWNS A 2002 FORD E-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED THREE TIMES OVER A PERIOD OF FOUR YEARS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSIS OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Jan 16, 2013 · 150,000 milesExterior lighting › Turn signal › Switch TL* THE CONTACT OWNS A 2002 FORD E-350. THE CONTACT STATED THAT THE TURN SIGNALS AND HAZARD LIGHTS WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE TURN SIGNAL SWITCH WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
EA10003 · opened Apr 13, 2010 · closed Mar 5, 2012HVAC Switch Failures This investigation was opened based on one complaint and reports from four transportation fleets alleging 182 blower motor control switch failures.ODI was concerned that these melting and burning switches could lead to an open flame that could spread throughout the vehicle.After a comprehensive review of all data related to overheating blower motor control switches in the subject vehicles, ODI did not identify the existence of a safety defect trend.ODI reviewed 1,036 complaints, claims, and field reports of failed blower motor control switches and determined that only two fires were likely to have been caused by a failing subject blower motor control switch.This represents a failure rate of 0.2 R/100K on a population of 1,076,975 vehicles that have been in service for up to 14 years.ODI has found that when the subject switches do fail and begin to melt, they are constructed in a manner…
PE09055 · opened Dec 7, 2009 · closed Apr 21, 2010HVAC Switch Failures ODI has received 1 complaint and reports from 4 transportation fleets alleging 182 switch failures.Each fleet operates mini buses built on a Ford E350 or E450 cutaway chassis.The OEM HVAC blower switches have melted, smoked, burned or experienced open flame and become inoperable on vehicles in each fleet.Some drivers have reported a burning smell or smoke coming from the dash.One fleet reported a vehicle fire.No injuries were sustained.However, the bus was carrying special needs children when the driver noticed smoke coming from the dash.The driver was able to evacuate the children prior to the vehicle becoming engulfed in flames.This PE has been upgraded to an Engineering Analysis (EA) to determine if the blower motor switch failures create a situation where a vehicle fire is possible and presents a safety risk to the driver and other passengers.
DP05005 · opened Sep 22, 2005 · closed Jan 4, 2006SPARK PLUG EJECTION FROM CYLINDER HEAD ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…