Model year record

2003 Chevrolet Express recalls & problems

The 2003 Chevrolet Express has 11 safety recalls and 59 owner complaints on file with NHTSA. The most-reported problem area is electrical system (10 complaints).

Recalls11safety recalls

Complaints59filed by owners

Crashes · fires2 · 7reported in complaints

Injuries · deaths1 · 0reported in complaints

Safety recalls

Fuel system, gasolineAug 8, 2012

Storage › Tank assembly › Filler pipe and cap

Recall 12V3880009,389 vehiclesopened after NHTSA action (ODI)

Problem: General Motors (GM) is recalling certain model year 2003-2004 Chevrolet Express and GMC Savana vehicles, equipped with a left side cargo door, and originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Water and road contaminants may become trapped in the protective conduit that covers the fuel filler pipe and may cause the pipe to corrode.
Risk: Significant corrosion may allow fuel to leak during refueling, and in the presence of an ignition source; there is an increased risk of fire.
Fix: GM will notify owners, and dealers will install a new fuel filler neck, free of charge. The safety recall began on October 1, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546 and GMC at 1-866-996-9463.

Exterior lightingApr 7, 2009

Exterior lighting

Recall 09E01200016,270 vehiclesopened after NHTSA action (OVSC)

Problem: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Seat beltsDec 19, 2005

Seat belts

Recall 05V558000425,593 vehicles

Problem: ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
Risk: IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Fix: DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL WILL BE CONDUCTED IN PHASES. THE FIRST PHASE MAILING BEGAN DURING MARCH 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Seat beltsMay 11, 2004

Front › Anchorage

Recall 04V225000736 vehicles

Problem: CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Risk: THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Fix: TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Service brakes, hydraulicFeb 4, 2004

Service brakes, hydraulic

Recall 04V04500068,875 vehicles

Problem: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Risk: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Fix: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.

EquipmentJul 15, 2003

Other › Owners/service/other manual

Recall 03V2500001,707,825 vehicles

Problem: CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Risk: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Fix: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

Exterior lightingJun 10, 2003

Exterior lighting

Recall 03V21700050,225 vehicles

Problem: CERTAIN VANS HAVE A CONDITION IN WHICH WATER MAY ENTER AND CORRODE THE REAR LICENSE PLATE LAMP SOCKET. IF THE LAMP SOCKET WERE TO CORRODE, THE REAR LICENSE PLATE LAMP MAY OPERATE INTERMITTENTLY OR NOT AT ALL, AND THE LEFT REAR TAIL LAMP MAY BECOME INOPERATIVE. THE TEMPERATURE OF THE LICENSE PLATE LAMP SOCKET COULD INCREASE TO THE POINT THAT IT MAY BEGIN TO SOFTEN AND MELT.
Risk: IF THE SOCKET ASSEMBLY WERE TO REACH THE POINT OF MELTING, THE OCCUPANTS OF THE VEHICLE MAY NOTICE AN ODOR AND SMOKE AT THE REAR DOORS OF THE VEHICLE. IF THIS ODOR AND SMOKE WERE IGNORED, THE PLASTIC COULD IGNITE AND A FIRE COULD OCCUR.
Fix: DEALERS WILL INSTALL A NEW SEALED REAR LICENSE PLATE LAMP SOCKET ASSEMBLY. OWNER NOTIFICATION BEGAN JULY 21, 2003. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Seat beltsFeb 14, 2003

Front › Buckle assembly

Recall 03V05000018,327 vehicles

Problem: ON CERTAIN VANS WITH A GROSS VEHICLE WEIGHT OF LESS THAN 8,500 POUNDS, DURING A VEHICLE CRASH SUFFICIENT ENOUGH TO DEPLOY THE SAFETY BELT PRETENSIONER, THE FRONT SAFETY BELT BUCKLES MAY NOT RELEASE AFTER THE VEHICLE CRASH, OR ALTERNATELY MAY EJECT THE SAFETY BELT LATCH DURING THE VEHICLE CRASH.
Risk: THIS COULD RESULT IN INCREASED RISK OF PERSONAL INJURY.
Fix: DEALERS WILL REPLACE THE FRONT DRIVER AND PASSENGER SIDE SAFETY BELT BUCKLE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

SteeringDec 12, 2002

Linkages

Recall 02V3300004,158 vehicles

Problem: ON CERTAIN VANS WITH AN 8,500 LB. OR 8,600 LB. GROSS VEHICLE WEIGHT RATING, THE NUT ATTACHING THE PITMAN ARM TO THE STEERING LINKAGE MAY NOT BE TIGHTENED ADEQUATELY RESULTING IN A POSSIBLE SEPARATION.
Risk: A SEPARATION COULD RESULT IN LOSS OF VEHICLE CONTROL, AND A CRASH COULD OCCUR WITH PRIOR WARNING.
Fix: DEALERS WILL TIGHTEN THE PITMAN ARM NUT TO THE PROPER SPECIFICATION. IF THE NUT IS MISSING, THE DEALER WILL INSTALL A NEW NUT AND TIGHTEN IT CORRECTLY. OWNER NOTIFICATION BEGAN DECEMBER 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

SteeringDec 2, 2002

Linkages › Tie rod assembly

Recall 02V32600018,648 vehicles

Problem: ON CERTAIN VANS, THE RIGHT-HAND TIE ROD END NUT MAY NOT BE TIGHTENED ADEQUATELY. THE NUT CAN LOOSEN RESULTING IN SEPARATION OF THE TIE ROD FROM THE STEERING KNUCKLE.
Risk: SEPARATION OF A TIE ROD CAN CAUSE UNEXPECTED VEHICLE STEERING IN SOME MANEUVERS AND COULD CAUSE A CRASH WITHOUT PRIOR WARNING.
Fix: DEALERS WILL TIGHTEN THE TIE ROD END NUT AND, IF NECESSARY, REPLACE THE TIE ROD END. OWNER NOTIFICATION BEGAN NOVEMBER 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

WheelsNov 14, 2002

Lugs/nuts/bolts/studs

Recall 02V30500018,409 vehicles

Problem: CERTAIN VANS WERE BUILT WITHOUT A WHEEL BEARING ASSEMBLY RETAINING NUT, WHICH COULD LEAD TO A POSSIBLE BEARING SEPARATION.
Risk: IF THIS WERE TO OCCUR, THE AMBER-COLORED ABS TELL-TALE LAMP IN THE INSTRUMENT PANEL WOULD ILLUMINATE AND THE ABS SYSTEM WOULD BE DISABLED. THE DRIVER WOULD ALSO NOTICE A GRINDING NOISE, A DECREASE IN THE VEHICLE SPEED, AND THE STEERING WILL PULL IN THE DIRECTION OF THE AFFECTED BRAKE ASSEMBLY. THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Fix: DEALERS WILL INSPECT THE WHEEL BEARING ASSEMBLY. IF THE INSPECTION REVEALS A MISSING RETAINING NUT, THE WHEEL BEARING ASSEMBLY WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2003 Chevrolet Express Van

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Express 1500/2500 2WD

15mpg combined

City / highway	13 / 18 mpg
Fuel	Regular Gasoline

4.3 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,450/year to fuel

Express 1500/2500 2WD

14mpg combined

City / highway	12 / 17 mpg
Fuel	Regular Gasoline

5.3 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,800/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Electrical systemWiring; Wiring › Front underhood	10	0	6	0	27,400 mi
Service brakes, hydraulicFoundation components › Disc › Rotor; Pedals and linkages	8	1	0	0	30,000 mi
Power trainAutomatic transmission; Axle hubs	6	0	0	0	26,757 mi
Fuel/propulsion system	6	0	0	0	126,600 mi
StructureBody › Door; Body	5	0	0	0	—
Fuel system, gasolineFuel injection system; Storage › Tank assembly › Filler pipe and cap	5	0	0	0	62,000 mi
Air bagsFrontal	4	0	0	1	—
SteeringLinkages › Arm › Idler and attachment; Rack and pinion	4	0	0	0	—
Seat beltsFront › Buckle assembly	4	0	0	0	43,683 mi
Engine	4	0	0	0	206,300 mi
VisibilityWindshield wiper/washer	3	0	0	0	36,800 mi
Vehicle speed controlAccelerator pedal	3	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel system, gasoline
The contact recently purchased a 2003 Chevrolet Express. The contact stated that the check engine warning light was illuminated on the instrument panel due to a corroded catalytic converter. The contact received notification of NHTSA Campaign Number: 12V388000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The manufacturer was made aware of the issue; however, the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 125,000.
Sep 22, 2026 · 125,000 miles
Electrical system › Instrument panel › Speedometer/odometer
Odometer Fraud. The contact purchased a 2003 Chevrolet Express. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was approximately 156,000. It was later discovered that the mileage on July 2, 2024, was 258,051.
Oct 10, 2024 · 258,051 miles
Unknown or other
THE FRAME AND ITS CROSSMEMBERS ARE RUSTED (ROTTED) THRU ABOVE THE GAS TANK MAKING THE VAN USELESS. THE GAS TANK IS EVEN ATTACHED AT THOSE AREAS MAKING IT A TICKING TIME BOMB. THIS IS A KNOW GM FRAME PROBLEM FOR MANY YEARS ON MANY TRUCK BODIES.
Dec 1, 2018 · 190,000 miles
Seat belts
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE CABLE THAT HELD THE SEAT BELTS TOGETHER, LOCATED IN THE REAR MIDDLE ROW, SNAPPED WITHOUT WARNING. AS A RESULT, THE CONTACT WAS CONCERNED THAT, IN THE EVENT OF A CRASH, THE SEAT BELTS WOULD NOT SECURE PROPERLY AND CAUSE AN INJURY. THE CONTACT ALSO STATED THAT THE REAR DRIVER AND PASSENGER SIDE DOOR HINGES FRACTURED. THE CONTACT STATED THAT THE DOORS WERE GLUED SHUT. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 228,000. UPDATED 10/17*LJ UPDATED 10/4/18*JB
Aug 5, 2017 · 228,000 miles
Suspension
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE FRONT OF THE VEHICLE VIBRATED WHENEVER THE VEHICLE WAS BEING DRIVEN OVER 30 MPH OVER A BUMP. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CONTROL ARMS, THE PITMAN ARM, THE TIRES AND THE HUBS WERE REPLACED, BUT THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS 109,000. THE VIN WAS NOT AVAILABLE. ....UPDATED 07/22/15 *BF UPDATED 10/4/2017*CN
Apr 1, 2015 · 109,000 miles
Fuel/propulsion system
I RECEIVED A NOTICE FROM GM ( DOC ID #32202443, #12167 FUEL FILLER PIPE CORROSION) STATING THAT THERE WAS A RECALL ON MY VEHICLE FOR LEAKING GASOLINE. I BROUGHT IT TO SIGHN CHEVROLET IN RIVERSIDE CA AND THE SERVICE MANAGER TOLD ME THAT CA VEHICLES DO NOT QUALIFY. I CONTACTED CUSTOMER COMPLAINTS CASE # [XXX] AND ALL THEY DID WAS CALL THE SAME SERVICE MANAGER AND GOT BACK TO ME SAYING THEY WON'T FIX IT. I BELIEVE I AM DRIVING AROUND WITH A VEHICLE LEAKING GAS ON THE ROAD CREATING AN EXTREMELY DANGEROUS SITUATION FOR MY FAMILY WITH A DIRE FIRE HAZARD. MY CONTENTION IS, WHY WOULD THEY SEND ME A RECALL NOTICE AND THEN TELL ME I DON'T QUALIFY? I DID RECEIVE THE NOTICE AND IT SAID IT HAD TO BE…
Dec 3, 2014 · 72,000 miles
Engine
MY SPEEDOMETER QUICKLY JUMPS FROM ONE INDICATED SPEED TO ANOTHER SPEED THAT IS CLEARLY INACCURATE, DOWN AS LOW AS -0- WHILE DRIVING, ACCOMPANIED BY THE TRANSMISSION ATTEMPTING TO DOWNSHIFT ON IT'S OWN, WHICH CAUSES A SEVERE ENGINE OVER-REV CONDITION OR GOING INTO A NEUTRAL MOMENTARILY WITH NO INPUT FROM ME AS THE DRIVER. THERE ARE NO SPECIFIC ACTIONS I CAN TAKE TO TRIGGER THE ERRATIC SYMPTOM, NOR ANY SPECIFIC ACTION I CAN TAKE TO CAUSE NORMAL OPERATION. WITH SNOW AND ICE ON THE ROADS AT THIS TIME OF THE YEAR THIS IS EXTREMELY DANGEROUS AS IT COULD CAUSE THE VAN TO LOCK UP THE REAR WHEELS ON SLIPPERY PAVEMENT CAUSING LACK OF CONTROL. THIS CONDITION CAN OCCUR REGARDLESS OF WHETHER OR NOT…
Dec 21, 2014 · 15,500 miles
Fuel/propulsion system
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THERE WAS A FUEL LEAK COMING FROM THE VEHICLE. THE CONTACT INDICATED THAT AFTER REFUELING, FUEL PUDDLE UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE FILLER NECK NEEDED TO BE REPLACED AND THE METAL FUEL FILLER PIPE WAS CORRODED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 12V388000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,500.
Aug 7, 2014 · 153,500 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Fuel Filler Pipe Corrosion/LeakageClosedLed to recall 12V388000
On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints…
PE11040 · opened Dec 14, 2011 · closed Aug 16, 2012
HYDRAULIC PUMP FAILRESClosedLed to recall 05V005000
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
EA04012 · opened Apr 30, 2004 · closed Feb 28, 2005