*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Unknown or other
I was driving approximately 70 mph on the highway when I came up behind a vehicle whose three brake lights were completely inoperative. The vehicle suddenly stopped, but there was no brake light illumination to warn following traffic. The only reason I realized the vehicle was stopping was because I was traveling on a slope and could see the vehicles ahead of it also slowing down. If the roadway had been level, I likely would not have known the vehicle was braking and could have rear-ended it at highway speed. This created a serious safety hazard and put me and other drivers at significant risk of a high-speed collision.
Jun 30, 2026Electrical system › Instrument panel › Speedometer/odometer
Odometer Fraud. The contact owns a 2006 Chevrolet Express. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 178,000, and at the time of registration, it was discovered that the mileage was 394,745.
Mar 11, 2026 · 394,745 milesSuspension
TL* THE CONTACT OWNS A 2006 CHEVROLET EXPRESS. WHILE DRIVING 30 MPH, THE VEHICLE VIBRATED SEVERELY AND STOPPED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE WAS NOT FOUND. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000.
Dec 15, 2007 · 40,000 milesElectronic stability control (esc)
I BOUGHT A CHEVROLET VAN EXPRESS WITH A 6.0 V8 ENGINE A YEAR AGO WITH ONLY 37000 MILES. APPROXIMATELY 2 MONTHS AFTER PURCHASE, I BEGAN HAVING TROUBLE WITH THE ENGINE AND STABILITRAK SYSTEM IN ADDITION TO THE LOW BEAM HEADLIGHT FAILURE DETAILED BELOW SAME ACROSS THE ENTIRE V8 6.0 ENGINES PRODUCED BY CHEVROLET. THE VAN VEHICLE SHOOK VIOLENTLY STRESSING ALL THE OCCUPANTS. WHILE TRAVELING ON THE HIGHWAY MY CHECK ENGINE AND TRACTION LIGHT ILLUMINATED SIMULTANEOUSLY. I WAS ALSO ALERTED THAT "ENGINE POWER WAS REDUCED" AND MY VEHICLE SHUT DOWN TWO TIMES IN A 30 MINUTE SPAN OF TIME. NOW WITH ONLY 41,000 MILES I HAVE PARKED THE VAN UNTIL A RECALL CORRECTS THE DANGEROUS SAFETY PROBLEMS. AGAIN WHILE…
May 18, 2016 · 41,000 milesElectrical system › Ignition
TL* THE CONTACT OWNS A 2006 CHEVROLET EXPRESS. WHILE DRIVING 50 MPH, THE VEHICLE JERKED AND STALLED. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO THE DEALER. THE TECHNICIAN STATED THAT THE IGNITION NEEDED TO BE REPAIRED. THE IGNITION WAS ORIGINALLY REPAIRED AT 54,322 MILES. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 70,000.
Dec 1, 2012 · 70,000 milesAir bags
MY FRONT PASSENGER AIRBAG SEAT SENSOR IS NOT FUNCTIONING. IT WILL NOT TURN ON AT ALL WHEN PEOPLE OF ALL DIFFERENT SIZES ARE IN THE SEAT. IF AN ACCIDENT WERE TO HAPPEN THE AIRBAG WOULD NOT DEPLOY. *TR
May 31, 2010 · 95,000 milesAir bagsCrash2 injuries
ON APRIL 29, 2011, A PASSENGER AND I WERE INVOLVED IN A VERY SERIOUS NEAR-FATAL MOTOR VEHICLE ACCIDENT. I WAS THE DRIVER OF THE VEHICLE, WHICH WAS A 2006 CHEVY EXPRESS CARGO VAN. WE WERE DRIVING FROM MEDFORD, OREGON TO KLAMATH FALLS, OREGON ON HWY 140 EAST. THE ACCIDENT OCCURRED NEAR MILE MARKER 59 AT APPROXIMATELY 8 A.M. THIS STRETCH OF HIGHWAY RUNS PARALLEL TO KLAMATH LAKE. THE VEHICLE SPUN OUT OF CONTROL WHEN WE DROVE OVER A PATCH OF UNSEEN BLACK ICE. AS THE VEHICLE SPUN OUT OF CONTROL WE WENT ACROSS THE HIGHWAY AND INTO THE LAKE WHERE WE COLLIDED HEAD ON INTO A HUGE BOLDER (NOT A ROCK) THAT WAS PROTRUDING FROM THE WATER. THE IMPACT CAUSED THE VEHICLE TO ROLL OVER LENGTH WISE AND THEN…
Apr 29, 2011 · 64,500 milesService brakes, hydraulic
THE ABS BRAKING SYSTEM ACTIVATES FOR NO REASON AND GREATLY EXTENDS THE STOPPING DISTANCE. THIS HAS PUT OUR DRIVERS IN VERY DANGEROUS SITUATIONS. WE HAVE SEVERAL GM LIGHT DUTY VANS AND TRUCKS AND THIS HAS BEEN A PROBLEM WITH ALMOST ALL OF THEM. THE WHEEL SENSOR MECHANISM IS A FAULTY DESIGN AND CAUSES A VERY DANGEROUS SITUATION FOR THE DRIVERS. GM SHOULD RECALL AND REPLACE ALL OF THESE WITH A NEWLY DESIGNED UNIT THAT WORK SAFELY. *TR
Nov 25, 2010 · 25,620 miles
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
