2007 Chrysler Pacifica recalls & problems

Recent owner complaints

• Feb 8, 2026Steering
  Front subframe is completely corroded and rusted out. Engine is no longer safely supported. Problem has been confirmed by dealer. Manufacturer has been aware of this issue caused by substandard uncoated and unprotected steel used in the front subfram01e
• Jul 1, 2023Suspension
  Engine Sub Frame-AKA Engine Cradle is rotting out. Vehicle was inspected on July 6, 2023 at Jim Rielh's Chrysler -Jeep Dealership located at 32899 Van Dyke, Warren Michigan 48093. The report came back as " FOUND FRONT ENGINE CRADLE / FRAME ROTTED / RUSTED OUT." This vehicle has been well maintained and has been Safety Inspected by the same dealership in 2021 & 2022 and never advised there was a problem with the Engine Cradle. Now in 2021, three engine mounts were replaced to correct clunking noises when accelerating, but again there was never an advisement of a potential Engine Cradle Rot. The vehicle had 127, 640 miles on it when it was inspected by the dealer. The results were reported to…
• May 15, 2023Structure › Body
  The engine cradle as well as the engine mounts along with the subframe have deteriorated uncommonly fast resulting in the vehicle involuntarily swerving into other lanes of traffic
• Mar 4, 2023Engine
  I am requesting that NHTSA issue a recall for the known defect and serious safety hazard for the 2007 Chrysler Pacifica. These vehicles need to be recalled effective immediately and removed from our highways. The engine cradle rot poses a a risk for accidents and the manufacturer is privy to these problems and had legal action taken against them for a similar notification of different years. The 2007 models should be recalled as well. Please issue the recall and do the right thing. Who knows, you may save someone’s life who is unaware of the dangerous equipment they are driving. Not to mention the manufacturer needs to either to buy back the vehicles, pay for the costly repairs and or…
• Sep 23, 2022 · 187,000 miles · fireFirerelated
  The contact owned a 2007 Chrysler Pacifica. The contact stated that the vehicle had been parked in the driveway for a week when it caught fire. The contact's husband looked outside the window of their residence and noticed that the vehicle had caught fire from the engine. The fire also caused damage to the garage door and siding. The fire department arrived on the scene and extinguished the fire. The fire department determined that the fire started in the engine compartment. Police and fire department reports were filed. The vehicle was towed to a tow yard and was not yet deemed totaled by the insurance company. The manufacturer was not made aware of the failure. Prior to the failure, the…
• Sep 2, 2022Electrical system
  The car has a lot of dangerous problems. For one I had my truck diagnosed and code came back as gas cap. Then it was electric problems after the replacement of the gas cap. Check engine light was still on. So I went for another diagnostic now is coming up power train. Went to 3 to 6 transmission shops and all told me different reasons solenoid, pcm, Tcm, or maybe it’s just shot all together is what the last shop told me. That’s a $3,000 repair and that’s ridiculous after I had all those pieces replaced. My car stills doesn’t shift gears as I’m driving I can’t really go over 40 or 50 mph because of high rpm’s. The car doesn’t shift gears and I’m hearing a loud whining noise…
• Sep 2, 2022Power train › Automatic transmission
  My Chrysler Pacifica 2007 4.0L Shifter Check Engine Light Was On. I Took It To Get Diagnosed It Came Back Ass Gas Cap My Inboard Computer Even Read Gas-cap. So I Replaced It And The Check Engine Light Was Gone. I Say A Week Later My I Was Parked An Tried To Put The Car In Drive I Wouldn't Shift Shifter Broken Only To Find Out It Was A Piece Inside The Shifter. So I Replaced That And After Replacement Of That Now I’m Having Transmission And Electric Problems. The Car Shifts Rough And As I’m Driving The Car Doesn’t Shifts Gears Now Also Will Shift Into Auto-stick On It’s On. I’ll Put My Car Into Drive An As I’m Proceeding To Drive Say At 20mph My Rpm’s A Stay At x2000 I’ll…
• Jul 30, 2022Fuel/propulsion system
  After fueling, especially if the take is full. The engine will die several times in the first 5 or more miles driven. Of course, this also means no power steering. You may be turning at an intersection, on a freeway or just traveling on a surface street. Still, you are without power and no power steering putting the car and occupants in danger. Usually, putting the car in neutral and starting gets you going again, at least until the next event. We have had as many a 5 such events on a 4.5 mile drive home form the gas station. This has now progressed. The last fill up, the nozzle cut of several times and restart over and over to finally fill the take. We knew it could take more fuel,…

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• EA08006 · opened Feb 21, 2008 · closed Apr 15, 2009ENGINE COMPARTMENT FIRE
  THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF CONSUMER COMPLAINTS, FIELD REPORTS, WARRANTY CLAIMS AND OTHER DATA REGARDING ENGINE COMPARTMENT FIRES AND POWER STEERING FLUID LEAKAGE IN MODEL YEAR (MY) 2007 CHRYSLER PACIFICA VEHICLES WITH 4.0L ENGINES.THE AVAILABLE EVIDENCE INDICATES THAT POWER STEERING FLUID LEAKS IN THE SUBJECT VEHICLES AND THE FIRES THAT MAY RESULT FROM THESE LEAKS, OCCURRED EARLY IN THE VEHICLE'S SERVICE LIFE.MOREOVER, CHANGES IN THE ASSEMBLY PROCESS APPEAR TO HAVE REMEDIED THE CONDITION CAUSING THE LEAKS.THE AVAILABLE DATA CONFIRMS A DECLINING TREND FOR BOTH COMPLAINTS AND WARRANTY CLAIMS AS THE SUBJECT VEHICLES REMAIN IN SERVICE. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY THE AGENCY THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. (SEE…
• PE07052 · opened Oct 19, 2007 · closed Feb 21, 2008ENGINE COMPARTMENT FIRE
  COMPLAINANTS ALLEGE THAT A FIRE ERUPTED UNDER THE HOOD, NEAR THE FRONT OF THE VEHICLE.IN CHRYSLER'S RESPONSE TO ODI'S NOVEMBER 2, 2007 INFORMATION REQUEST, CHRYSLER ASSERTS THAT THE ALLEGED DEFECT OCCURS ONLY IN THE 4.0L ENGINES AND THE CONSUMER WILL EXPERIENCE A LOSS OF POWER STEERING FLUID OR A NOISY POWER STEERING PUMP BEFORE SEEING ANY EVIDENCE OF SMOKE OR FIRE.CHRYSLER ALSO STATES THAT A TUBE NUT ON THE HIGH PRESSURE POWER STEERING LINE WAS DISCOVERED TO BE CROSS THREADED DURING THE ASSEMBLY PROCESS AND DID NOT ALLOW PROPER SEALING OF THE O-RING.THE POWER STEERING SYSTEM IN THE 4.0L ENGINE IS ASSEMBLED AT THE CHRYSLER PLANT.THE POWER STEERING SYSTEM FOR THE 3.8L ENGINES ARRIVES AT THE CHRYSLER PLANT PRE-ASSEMBLED.CHRYSLER FOUND THAT IN THE 4.0L ENGINE, IT WAS POSSIBLE TO CROSS-THREAD THE TUBE NUT ON THE HIGH PRESSURE LINE DURING ITS ATTACHMENT TO THE STEERING GEAR, THUS CREATING AN…