1999 Volkswagen Passat recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Seat belts

  Just as I parked, the explosive seatbelt retractor for the rear passenger seat activated. There was a loud pop from the charge and the plastic seatbelt alignment clip flew off, and smoke came out from around the seatbelt. Had the vehicle been in motion there would have been a very serious safety hazard from the distraction, and if someone was in the back, there was the clip that flew off that could have struck them. No one was in the seat at the time of the incident. The seatbelt is now stuck in the retracted position. The component has not been inspected. There were no warning lamps before or after the failure. The climate control system does have an error and is not cooling. The error is…

  Jun 28, 2022
• Vehicle speed control

  I WOS DRIVING FROM WORK TO HOME I TOOK THE PARKWAY I WOS GOING 60 MILES THEN IN HIS OWN THE CAR STARTING INCREASING SPEED SO I MOVE THE SHOULDER I PUT THE CAR NEUTRAL AND STOP THE CAR.THE TOOK ME 3 TRY TO THE CAR GO BACK TO NORMAL. I DONT KNOW IF THIS CAR GOT I RECALL.

  Aug 10, 2019
• Power train

  AFTER STARTING AND BEGINNING MOTION THERE'S A SLOWING IN MOTION AS THOUGH THE BRAKES HAD BEEN SLIGHTLY TAPPED OR AS THOUGH THE ABS HAD TOLD THE TRANSMISSION COMPUTER TO SLOW DOWN. GAS CONSUMPTION WAS 16MPG. AFTER SEVERAL YEARS ONE TECH LISTENED TO ME, ADJUSTED THE 'FEEDBACK' FROM ABS TO THE TRANSMISSION MODULE COMPUTER AND THE SENSATION OF BRAKED SLOWING WAS GONE! AND THE GAS CONSUMPTION BECAME 19MPG! SEVERAL YEARS LATER MY DOOR LOCKS SHORTED OUT AND HAD TO BE REPLACED AFTER DESTROYING TWO BATTERIES. THE TECH THEN REPORTED THAT HE HAD REPROGRAMMED THE ELECTRICAL SYSTEM TO 'FACTORY SPECS' AT THAT POINT THE 'SLOWING (BRAKED)' PROBLEM RECURRED AND THE GAS CONSUMPTION DROPPED BACK TO 16 MPG.…

  Oct 31, 1999
• Visibility/wiper

  DRIVERS SIDE WINDOW FELL PARTIALLY INTO THE DOOR WHILE OPERATING WINDOW POWER CONTROL DURING DRIVING OPERATION ON HIGHWAY. UPON REACHING THE DESTINATION AND TOUCHING THE WINDOW POWER CONTROL, THE WINDOW COMPLETELY FELL DOWN INTO THE DOOR. THIS EVENT IS THE SECOND TIME IT'S HAPPENED ON THIS VEHICLE.

  Aug 5, 2016 · 123,718 miles
• Engine

  TL* THE CONTACT OWNS A 1999 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE HAVING A ROUTINE SERVICE PERFORMED AT AN INDEPENDENT MECHANIC, THE TECHNICIAN DIAGNOSED THE WATER PUMP WAS CRACKED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 179,000.

  May 24, 2015 · 179,000 miles
• EngineFire

  PASSAT BEGAN TO ACCELERATE UNDER NO PRESSURE TO PEDAL. PASSAT STARTED TO ACCELERATE FAIRLY SLOWLY BUT STEADILY AT FIRST, THEN IT INCREASED. IT WASN'T POSSIBLE TO DECELERATE/NO PRESSURE ON THE BRAKE PEDAL STOPPED THE ACCELERATION. IT BEGAN TO REACH AN UNSAFE SPEED THEN I BEGAN TO DOWNSHIFT AND TO APPLY THE BRAKE IN SEQUENCE TO SLOW THE PASSAT, THEN I TRIED TO SLOW THE VEHICLE TO COAST IT ONTO THE SHOULDER, BUT THE SPEED REMAINED TOO HIGH TO HALT THE CAR. HAVING NO OTHER WAY TO SLOW THE VEHICLE, I STARTED TO DOWNSHIFT AND TO APPLY EXTREME PRESSURE TO THE BREAKS, AND WAS ABLE TO SLOW THE VEHICLE ENOUGH AFTER SEVERAL MILES OF DOWNSHIFTING AND RIDING THE BREAKS TO REACH A POINT AT WHICH I COULD…

  Feb 19, 2015 · 205,029 miles
• Fuel/propulsion system

  TL* THE CONTACT OWNS A 1999 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, FUEL FUMES EMITTED IN AND AROUND THE VEHICLE. THE CONTACT MENTIONED THAT WHILE INSPECTING THE VEHICLE, FUEL WAS DISCOVERED LEAKING FROM THE REAR PASSENGER SIDE SUB FRAME. ALSO, THE CONTACT INDICATED THAT THE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 18V156000 (FUEL SYSTEM). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 119,000.

  Feb 15, 2015 · 119,000 miles
• Electrical system

  CAR WAS HAVING A FOUL ODOR. DEALER DID NOT HAVE INFORMATION FOR OTHER COMPLAINTS. AFTER WORK, CAR WOULD NOT START, ALARM WOULD NOT STOP. ALARM KILLED BATTERY. DEALER SAID LEAK IN SUNROOF CAUSED MODULE TO CORRODE AND LEAK INTO INTERIOR. $1,440.00 TO REPAIR. PROBLEM IS IDENTIFIED IN CLASS ACTION BUT OUR CAR IS NOT INCLUDED. I AM LEASING A CAR FOR MY SON TO DRIVE BUT NOW HIS DAUGHTER HAS ECZEMA AND ASTHMA FROM THE MOLD. HOW CAN I GET VW TO FIX MY CAR TOO? *TR

  May 30, 2013 · 154,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• PASSENGER ENGINE COMPARTMENT FIRESClosedLed to recall 08V156000

  THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.

  EA07014 · opened Sep 28, 2007 · closed Jul 7, 2008
• ALLEGED PREMATURE TIE ROD FAILUREClosed

  ON AUGUST 2, 2005, ODI RECEIVED A PETITION SUBMITTED BY MS. MIRIAM SCHNEIDER OF OLNEY, MD, REQUESTING AN INVESTIGATION OF ALLEGEDLY DEFECTIVE TIE RODS IN CERTAIN MODEL YEAR (MY) 1999 VOLKSWAGEN PASSAT VEHICLES NOT INCLUDED IN TWO PREVIOUS SAFETY RECALL CAMPAIGNS (IDENTIFIED HENCEFORTH AS THE SUBJECT VEHICLES).IN A SEPTEMBER 1999 LETTER, VOLKSWAGEN OF AMERICA, INC. (VW) NOTIFIED THE AGENCY THAT AN UNDETERMINED PERCENTAGE OF MY 1998-1999 VOLKSWAGEN PASSAT AND AUDI A4, A6, AND A8 VEHICLES CONTAINED A SAFETY-RELATED DEFECT AFFECTING ALUMINUM TIE ROD ENDS IN THE STEERING SYSTEM.VW INDICATED THAT IT WAS POSSIBLE THAT SOME TIE RODS WOULD NOT SEAL PROPERLY WHICH COULD ALLOW MOISTURE AND DUST PARTICLES TO ENTER THE SWIVEL BEARING MECHANISM, RESULTING IN PREMATURE WEAR.THE APPROXIMATELY 22,200 VOLKSWAGEN AND 29,700 AUDI VEHICLES AFFECTED BY THIS RECALL (IDENTIFIED BY NHTSA RECALL NO. 99V-248)…

  DP05003 · opened Aug 8, 2005 · closed Dec 9, 2005
• STUCK-OPEN THROTTLEClosedLed to recall 04V495000

  VWOA HAS RECALLED APPROXIMATELY 28,300 MY 1998-99 A6 VEHICLES IN COLD WEATHER STATES THAT EXPERIENCED THE HIGHEST RATE OF THROTTLE ICING INCIDENTS IN THE SUBJECT VEHICLES (04V-495).THE FAILURE RATE IN THE A4 AND PASSAT VEHICLES IS MUCH LOWER THAN IN THE RECALLED VEHICLES.ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE A4 AND PASSAT VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE AUDI A4 OR VW PASSAT VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES. FOR FURTHER DETAILS SEE THE ATTACHED CLOSING REPORT.

  EA04017 · opened Jun 30, 2004 · closed Feb 10, 2005
• PASSENGER AIR BAG LID FAILUREClosed

  THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD…

  EA03020 · opened Oct 7, 2003 · closed Apr 23, 2004
• PASSENGER SIR DOOR MOUNTING STUD FAILUREClosed

  ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).

  PE03021 · opened May 23, 2003 · closed Oct 7, 2003
• FUEL TANK PUNCTUREClosedLed to recall 02V026000
  EA00028 · opened Dec 28, 2000 · closed Jan 29, 2002
• FUEL TANK PUNCTUREClosed

  THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.

  PE00033 · opened Aug 10, 2000 · closed Dec 28, 2000
• POWER BRAKE BOOSTER VACUUM BY-PASSClosedLed to recall 99V131001

  There is no summary currently available

  RQ99008 · opened Jun 1, 1999 · closed Nov 14, 2000