Biggest recalls
209 recalls filed with NHTSA in 2001, covering about 13,666,428 vehicles. The 200 largest are listed.
2001 Ford Crown Victoria, 2001 Ford Excursion, 2001 Ford Expedition, 2001 Ford F-150 and 9 more
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA…
2000–2001 Ford Excursion, 2000–2001 Ford Expedition, 2000–2001 Ford F-150, 2000–2001 Ford F-250 and 11 more
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER…
ON CERTAIN PICKUP TRUCKS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING "SALT BELT" STATES: MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA,…
1995 Ford Mustang, 1995 Ford Taurus, 1995 Mercury Sable
VEHICLE DESCRIPTION: TAURUS/SABLE VEHICLES EQUIPPED WITH 3.0L AND 3.8L ENGINES AND MUSTANG VEHICLES WITH 3.8L AND 5.0L ENGINES. IT IS POSSIBLE FOR THE ENGINE COOLING FAN BEARING TO SEIZE.
VEHICLE DESCRIPTION: MINI VANS. CONTAMINANTS SUCH AS WATER, SALT, AND WINDSHIELD WASHER SOLUTION CAN ENTER THE WIPER MOTOR COVER ASSEMBLY THROUGH PINHOLES ON THE EXTERIOR OF THE COVER THAT ARE USED IN THE MOLDING PROCESS. IN ADDITION, ON CERTAIN OF THE…
2000–2002 Chevrolet Blazer, 2000–2001 GMC Jimmy, 2000–2001 Oldsmobile Bravada
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT…
1997–2001 Chevrolet Venture, 1997–2001 Oldsmobile Silhouette, 1998–2001 Pontiac Montana, 1997–1998 Pontiac Trans Sport
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A…
1996–1999 Chevrolet Astro, 1996–1999 GMC Safari
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED…
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH AUXILIARY REAR AIR-CONDITIONING. IF THE AUXILIARY AIR-CONDITIONING BLOWER MOTOR STOPS TURNING WHILE IN THE MEDIUM-LOW BLOWER SPEED SETTING, THERE IS THE POTENTIAL THAT THE RESISTOR MAY BECOME HOT AND SMOKE.
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK,…
2000–2001 Dodge Neon, 2000–2001 Plymouth Neon
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IN THE PRESENCE OF OIL AND HEAT, THE BRAKE BOOSTER VACUUM HOSE COULD SWELL AND LOOSEN FROM THE INTAKE MANIFOLD.
1996–1998 Ford Contour, 1996–1998 Mercury Mystique, 1999 Mercury Cougar
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL…
2000–2001 Chrysler 300M, 2000–2001 Chrysler Concorde, 2000–2001 Chrysler LHS, 2000–2001 Dodge Intrepid
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES (NON-SUNROOF ONLY) FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
1999–2001 Mitsubishi Galant, 2000–2001 Mitsubishi Eclipse, 2001 Mitsubishi Eclipse Spyder
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. A HOSE WAS MIS-MANUFACTURED AND COULD WEAKEN OVER TIME, WHICH COULD RESULT IN LEAKAGE OF THE AUTOMATIC TRANSMISSION FLUID.
1997–2001 Chevrolet Venture, 1997–2001 Oldsmobile Silhouette, 1998–2001 Pontiac Montana, 1997 Pontiac Trans Sport
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET…
1997–2001 Dodge Ram, 1997–2000 Dodge Dakota, 1997–2000 Dodge Durango, 2000–2001 Dodge Ram 1500 and 2 more
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000…
ON CERTAIN MINIVANS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE…
1995–1999 Subaru Legacy, 1995–1999 Subaru Outback
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT COIL SPRINGS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW…
1999 Chrysler Concorde, 1999 Chrysler LHS, 1999 Chrysler Town and Country, 1999 Dodge Caravan and 5 more
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES. THE THROTTLE CABLE COULD UNRAVEL (FRAY) OR BREAK RESULTING IN LOSS OF THROTTLE CONTROL.
2000–2001 Ford Taurus, 2000–2001 Mercury Sable
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS. IF THE GREASE FROM THE ADJUSTABLE PEDAL ASSEMBLY ENTERS THE STOP LAMP SWITCH, IT CAN CONTAMINATE THE CONTACTS LEADING TO CARBON BUILD UP, AND POTENTIALLY, A SHORT CIRCUIT.
1997–2001 Ford E-150, 1997–2001 Ford E-350
VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35…
1997–1998 Chevrolet Malibu, 1997–1998 Oldsmobile Cutlass
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE,…
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION,…
VEHICLE DESCRIPTION: SEDANS AND COUPES. THE HOSE CLAMPS ON THE FILLER NECK TUBE HAVE INSUFFICIENT CLAMPING FORCE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 2.5L V6 ENGINES. THE BATTERY CABLE WAS MISROUTED AND ITS ATTACHMENT TO THE ALTERNATOR CABLE WAS UNDER-TORQUED. IF MISROUTED, THE CABLE COULD CONTACT THE POWER STEERING LINE AND THE INSULATION COULD WEAR,…
2000–2001 Buick Century, 2000–2001 Buick Regal, 2000–2001 Oldsmobile Intrigue
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH SUNVISOR LOCATED AIR BAG LABELS, FAIL TO CONFORM TO FEDERAL MOTOR VEHICLES SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE A MESSAGE AREA LESS THAN 30 CM WHICH DOES NOT…
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE COOLING HOLES IN THE STEEL WHEEL MAY HAVE BURRS ON THEIR EDGES AS A RESULT OF IMPROPER MANUFACTURING. THESE BURRS CAN CAUSE CRACKS AS THE VEHICLE IS BEING DRIVEN. CRACKS CAN PROPAGATE BETWEEN ADJACENT COOLING…
1998 Ford Contour, 1998 Mercury Mystique
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW…
VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS. THE FRONT OUTBOARD LOWER SEAT BELT ANCHOR BOLTS MAY NOT BE TIGHTENED CORRECTLY.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 1.8 LITER ENGINE. THE ENGINE COULD STOP RUNNING WHILE BEING DRIVEN DUE TO A DEFECTIVE CRANK POSITION SENSOR. THIS COULD ALSO RESULT IN THE "SERVICE ENGINE SOON" WARNING LIGHT COMING ON OR REDUCED ENGINE…
1999–2001 Ford F-450 Sd, 1999–2001 Ford F-550 Sd
VEHICLE DESCRIPTION: TRUCKS EQUIPPED WITH COMMERCIAL TRUCK TIRES THAT HAVE STEEL CORDS IN THE TIRE SIDEWALL. THE VALVE STEMS MAY HAVE BEEN TORN OR DAMAGED DURING ASSEMBLY AND COULD LEAK CAUSING SIDEWALL DAMAGE.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. IN THE EVENT OF A SEVERE FRONTAL OFFSET COLLISION, SHARP EDGES ON THE POWER STEERING PRESSURE HOSE BRACKET COULD CUT THE FRONT IMPACT SENSOR WIRING INSULATION CAUSING A SHORT CIRCUIT IN THE WIRING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ONE OR MORE OF THE THREE BOLTS USED TO ATTACH EACH FRONT SUSPENSION LOWER CONTROL ARM TO THE BODY ON THE LEFT AND RIGHT SIDES MAY NOT HAVE BEEN PROPERLY MANUFACTURED.
VEHICLE DESCRIPTION: VANS AND WAGONS NOT EQUIPPED WITH POWER FRONT SEATS. IN THE PRESENCE OF ROAD SALT, WATER, AND POSSIBLY OTHER DEBRIS, THE POWER SEAT CONNECTOR LOCATED BENEATH THE DRIVER'S SEAT COULD DEVELOP A HIGH RESISTIVE SHORT CIRCUIT THAT CYCLES THE…
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT COULD ILLUMINATE DUE TO MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR THAT MOUNT TO THE ADJUSTABLE SEAT…
2001 Dodge Dakota, 2001 Dodge Durango
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE ELECTRIC SHIFT TRANSFER CASE MAY NOT FULLY ENGAGE INTO GEAR WHEN THE OPERATOR MOVES THE TRANSFER CASE SELECTOR SWITCH.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE VEHICLES WERE MISSING TAMPERPROOF CAPS THAT PREVENT HORIZONTAL…
2002 Chevrolet Trailblazer, 2002 GMC Envoy
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE CALIBRATION OF THE TRANSFER CASE CONTROL MODULE COULD CAUSE INSUFFICIENT HIGH SPEED GEAR ENGAGEMENT.
2001 Chevrolet C10, 2001 Chevrolet C20, 2001 GMC Sierra 1500, 2001 GMC Sierra 2500
VEHICLE DESCRIPTION: CERTAIN 2-WHEEL DRIVE PICKUP TRUCKS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE PROBLEM WAS CAUSED BY A COMPUTER ERROR THAT RESULTED IN THE CERTIFICATION…
2001 BMW 325Ci, 2001 BMW 325IT, 2001 BMW 325i, 2001 BMW 330Ci and 18 more
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE…
2001 Chevrolet Venture, 2001 Oldsmobile Silhouette, 2001 Pontiac Aztek, 2001 Pontiac Montana
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
1999–2000 Freightliner Argosy, 1999–2000 Freightliner Century, 1999–2000 Freightliner Fld, 1999–2000 Freightliner Fln and 2 more
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN MERITOR AXLES. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.
2000 Ford Excursion, 2000 Ford Taurus, 2000 Mercury Sable
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. DUE TO THE USE OF INCORRECT MATERIAL BY A SUPPLIER, THE HEADLAMP SWITCH KNOB CAN FRACTURE AND SEPARATE FROM THE HEADLAMP SWITCH.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE DRIVER'S SIDE KNEE BLOCKER TRIM PANEL ASSEMBLY CAN DISENGAGE, FALL, AND STARTLE THE OPERATOR.
1999–2000 Toyota Tacoma, 1999–2000 Toyota Tundra
EQUIPMENT DESCRIPTION: THIS RECALL IS FOR TRAILER TOWING WIRE HARNESS CONVERTERS INSTALLED BY DEALERS OR FOR INSTALLATION ON 1999-2000 TOYOTA TUNDRA AND TACOMA VEHICLES. THE CONNECTORS INTEGRATE THE VEHICLE'S TAIL LIGHTS, BRAKE LIGHTS, AND TURN SIGNAL LIGHTS…
1998–2001 Audi A6, 2000–2001 Volkswagen Passat
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE…
1998–1999 Mercedes-Benz C-Class
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH HOPPECKE BATTERIES. THE BATTERY MAINTENANCE SCHEDULE COULD BE LESS THAN NEEDED TO MAINTAIN PROPER ELECTROLYTE LEVELS.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER TEMPERATURES BELOW -25 DEGREES, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. FUEL SYSTEM PRESSURE COULD INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THESE VEHICLES EXCEED THE MAXIMUM ALLOWABLE HEAD INJURY CRITERION VALUE SPECIFIED IN THE STANDARD FOR PASSENGER-SIDE…
ON CERTAIN SEDANS, A SMALL AMOUNT OF WATER MAY HAVE BEEN LEFT IN THE FUEL PUMP ELECTRICAL CONNECTOR AFTER TESTING. THIS RESIDUAL WATER COULD CAUSE THE FUEL PUMP TO FAIL DUE TO CORROSION.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL AND V6 ENGINES, AND BUILT AT ONE OF TWO LINES AT THE KENTUCKY PLANT. THE ACCELERATOR CABLE HOUSING COULD BE DEFORMED AT THE CRUISE CONTROL ACTUATOR-TO-THROTTLE BODY CONNECTION. THE…
2002 Chrysler Town and Country, 2002 Chrysler Voyager, 2002 Dodge Caravan, 2002 Dodge Grand Caravan
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD…
2002 Ford Explorer, 2002 Mercury Mountaineer
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE FUEL INLET CHECK VALVE COULD STICK IN THE PARTIALLY OPEN POSITION. THIS CONDITION COULD CAUSE FUEL TO SPILL OUT OF THE FILLER TUBE DURING REFUELING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.5 LITER OR 1.6 LITER ENGINES THAT WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, MAINE, MASSACHUSETTS, MICHIGAN, MINNESOTA,…
1996–1997 Chevrolet Blazer, 1996–1997 GMC Jimmy, 1996–1997 Oldsmobile Bravada
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO,…
VEHICLE DESCRIPTION: CERTAIN SEDANS, HEARSE, AND LIMOUSINE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THESE VEHICLES HAVE SUNVISOR CENTER SUPPORTS WITH CERTAIN RADII LESS THAN THE 3.2MM REQUIRED BY…
VEHICLE DESCRIPTION: SEDAN AND COUPE MODEL VEHICLES EQUIPPED WITH A BOSE AUDIO SYSTEM THAT HAD SEPARATE SPEAKER AMPLIFIERS MOUNTED BEHIND THE REAR SEAT BACK. A TRANSISTOR IN THE SPEAKER AMPLIFIER COULD OVERHEAT.
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH AN ADJUSTABLE PEDAL OPTION. THE DRIVER FLOOR MAT COULD INTERFERE WITH THE ACCELERATOR PEDAL.
2000–2001 SAAB 9-3, 2000–2001 SAAB 9-5
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE AIR BAG ALERT LABELS MAY NOT BE PERMANENTLY AFFIXED AS REQUIRED BY THIS STANDARD.
2002 Chrysler PT Cruiser, 2002 Jeep Grand Cherokee
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES ARE BEING RECALLED FOR A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER MICROPROCESSOR. UNDER CERTAIN CONDITIONS, THE CLUSTER, WITH THE MAJORITY OF ITS GAUGES, ILLUMINATION, AND WARNING LAMPS, COULD BECOME…
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DRIVER AND FRONT PASSENGER SEAT BELTS MAY NOT EXTEND AND RETRACT SMOOTHLY THROUGH THE D-RING GUIDES MOUNTED ON THE BODY PILLARS AFT OF THE DOORS. IF THE SEAT BELTS DO NOT EXTEND AND RETRACT SMOOTHLY, THEY MAY TWIST…
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION. DUE TO A UNIQUE COMBINATION OF CONDITIONS WHICH CONSIST OF COLD AMBIENT TEMPERATURES, LOAD APPLIED FROM AIR CONDITIONER AND OTHER ELECTRICAL DEVICES, AND IMMEDIATELY AFTER…
2001 Chrysler Town and Country, 2001 Chrysler Voyager, 2001 Dodge Caravan, 2001 Dodge Grand Caravan
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
VEHICLE DESCRIPTION: SPORT UTIITY VEHICLES. THE RESERVOIR FILLER CAP OF THE BRAKE MASTER CYLINDER MAY INDUCE A VACUUM, INTRODUCING SOME AIR INTO THE BRAKE MASTER CYLINDER RESERVOIR. THIS COULD CAUSE ABNORMAL BRAKE NOISE AND INCREASED PEDAL STROKE WHEN THE…
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE ACCUMULATOR THAT IS INSTALLED ON THE HYDRAULIC BRAKE BOOSTER MAY HAVE BEEN IMPROPERLY MANUFACTURED. OVER A PERIOD OF TIME, THIS COULD RESULT IN LEAKAGE OF THE PRESSURIZED NITROGEN GAS FROM INSIDE THE…
2001–2002 Chevrolet Silverado 2500, 2001–2002 Chevrolet Silverado 3500, 2001–2002 GMC Sierra 2500, 2001–2002 GMC Sierra 3500
VEHICLE DESCRIPTION: CERTAIN PICKUP TRUCKS EQUIPPED WITH 6.6L DIESEL ENGINES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THESE VEHICLES HAVE A BRAKE SYSTEM WARNING LIGHT IN THE INSTRUMENT CLUSTER THAT MAY NOT…
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE ONBOARD VAPOR RECOVERY SYSTEM VENT HOSE MAY HAVE BEEN MISROUTED. THIS COULD ALLOW WATER TO ENTER THE CANISTER WHICH CAN CAUSE FUEL TO SPILL OUT OF THE FILLER TUBE WHEN REFUELING THE TANK.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE LAMP SWITCH TERMINALS COULD OVERHEAT.
2001 Infiniti QX4, 2001 Nissan Pathfinder
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. SOME OF THE BRACKETS USED TO ATTACH THE TWO GAS STRUTS TO THE REAR DOOR (HATCH) MAY HAVE BEEN IMPROPERLY MADE. AT HIGH AMBIENT TEMPERATURES, THE INCREASE IN GAS PRESSURE IN THE STRUT(S) COULD CAUSE ONE OR BOTH…
2002 Chevrolet Trailblazer, 2002 GMC Envoy, 2002 Oldsmobile Bravada
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CIRCUMSTANCES THE FRONT LOWER CONTROL ARM BRACKETS MAY FRACTURE. THIS FRACTURE COULD RESULT IN SEPARATION OF THE FRONT LOWER CONTROL ARM FROM THE FRAME.
2001 Chrysler Sebring, 2001 Dodge Stratus
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. A HOSE MANUFACTURING PROCESS ALLOWED THE REINFORCEMENT YARD TO BREACH THE INNER LAYER OF SOME AUTOMATIC TRANSMISSION HOSES WEAKENING THE INNER WALL WHICH COULD RESULT IN LEAKAGE OF…
VEHICLE DESCRIPTION: PASSENGER SEDANS WITH FACTORY OR DEALER-INSTALLED DECK LID SPOILERS WITH LED CENTER HIGH MOUNTED STOP LAMPS (CHMSL). VEHICLES PRODUCED WITH SPOILERS WERE MANUFACTURED FROM MARCH 1 THROUGH OCTOBER 31, 2000; AND VEHICLES WITH SPOILERS…
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A WIRING HARNESS, LOCATED BENEATH THE CARPET IN THE FRONT PASSENGER FLOOR AREA, CAN BECOME DAMAGED BY PASSENGER TRAFFIC AS THE WIRE HARNESS IS RUBBED AGAINST A BODY SEAM IN THE FLOOR PANEL.
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 -…
2000 Mitsubishi Eclipse, 2000 Mitsubishi Galant
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT WITH V6 ENGINES TO FEDERAL EMISSION STANDARDS. THE POWER STEERING FLUID FEED TUBE CAN COME IN CONTACT WITH AN EXHAUST MANIFOLD MOUNTED HEAT SHIELD CAUSING A HOLE TO BE WORN THROUGH THE POWER STEERING PIPE ALLOWING…
2001 Harley-Davidson Dyna Glide
VEHICLE DESCRIPTION: MOTORCYCLES. THESE MOTORCYCLES WERE BUILT WITH A FUEL HOSE THAT COULD COME OFF THE CARBURETOR.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FIRESTONE FIREHAWK GTA-02 , SIZE P205/55R16 89H TIRES. THE RECALLED TIRES ARE IDENTIFIED BY DOT SERIAL #W2 T2 VF3 XXX OR W2 T2 VF3 XXXX; WHERE XXX MAY BE 289, 299, 309, 319, 329, 339, 349, 359, 369, 379,…
2002 Lexus ES300, 2002 Toyota Camry
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A THREE-SPOKE STYLE STEERING WHEEL. DURING AIR BAG DEPLOYMENT, IT IS POSSIBLE THAT THE BOTTOM SEAM OF THE FRONT DRIVER'S SIDE AIR BAG MODULE COVER (HORN PAD) COULD BE TORN AWAY ALLOWING THE BOTTOM PORTION…
VEHICLE DESCRIPTION: CERTAIN MINI VANS WITHOUT ANTI-LOCK BRAKING SYSTEMS (ABS) FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." DUE TO INAPPROPRIATE BRAKE PIPE LAYOUT, THESE VEHICLES DO NOT…
1999–2001 Mitsubishi Montero Sport
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 3.5L ENGINES. THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 106, "BRAKE HOSES." THESE VEHICLES ARE EQUIPPED WITH NONCOMPLIANT BRAKE VACUUM HOSES.
2001 Volvo S40, 2001 Volvo V40
VEHICLE DESCRIPTION: SEDAN AND WAGON PASSENGER VEHICLES. A DIODE IN THE ELECTRONIC CLIMATE CONTROL SYSTEM MAY HAVE A REDUCED SERVICE LIFE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BOLT SECURING THE CRANKSHAFT PULLEY CAN BECOME LOOSE AND THE PULLEY COULD FALL OFF THE VEHICLE.
2000–2001 Honda Accord, 2000–2001 Honda Civic
VEHICLE DESCRIPTION: CERTAIN SEDANS AND COUPES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." CERTAIN REAR SEAT BELT BUCKLES WERE IMPROPERLY MANUFACTURED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SIDE AIR BAG WIRE HARNESS FOR THE DRIVER POSITION COULD BE MIS-ROUTED, WHICH COULD RESULT IN IT BEING PINCHED OR CUT BY THE SEAT CUSHION TILT MECHANISM.
VEHICLE DESCRIPTION: WAGONS. THE BOLTED JOINT, USED FOR ATTACHING THE BRACKET THAT IS PART OF THE INSTALLATION HARDWARE FOR THE ISOFIX-TYPE CHILD RESTRAINT, MAY HAVE BEEN INCORRECTLY TIGHTENED.
1999 Freightliner Argosy, 1999 Freightliner Cargo, 1999 Freightliner Century, 1999 Freightliner FLB and 5 more
VEHICLE DESCRIPTION: TRUCKS, SCHOOL BUS AND MOTOR HOME CHASSIS, AND TRANSIT BUSES EQUIPPED WITH TIE ROD ASSEMBLIES MANUFACTURED BY TRW. THE SUSPECT TIE RODS CONTAIN 24-DL MODEL BALL SOCKETS. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A…
VEHICLE DESCRIPTION: SOME SPORT UTILITY VEHICLES DO NOT COMPLY WITH THE CERTAIN REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE PRESENTATION OF SOME OF THE INFORMATION ON THE TIRE INFORMATION LABEL…
VEHICLE DESCRIPTION: 4.4I SPORT UTILITY VEHICLES. OVER AN EXTENDED PERIOD OF TIME, ABRASION PARTICLES COULD DEPOSIT ON THE ELECTRICAL CONTACTS WITHIN THE SWITCH, CAUSING A DISRUPTION OF THE ELECTRIC CURRENT THROUGH THE CONTACTS. IF THE DISRUPTION OCCURS WHEN…
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DURING ASSEMBLY OF THESE VEHICLES, THE LOWER END OF THE SPINDLE MAY NOT HAVE BEEN INSERTED COMPLETELY INTO THE COUPLING. IN SUCH A CASE, THE FASTENING BOLT USED TO SECURE THE CONNECTION MAY NOT COMPLETELY ENGAGE THE…
VEHICLE DESCRIPTION: 4.4I SPORT UTILITY VEHICLES. THERE IS A PLASTIC CARRIER TO WHICH THE OIL FILTER HOUSING IS ATTACHED. OIL SUPPLY AND RETURN LINES ARE ATTACHED TO THE FILTER HOUSING. OVER TIME, THIS CARRIER COULD SAG SLIGHTLY. IF THIS HAPPENS, ONE OF THE…
1999 Yamaha XV1600AL, 2000 Yamaha XV1600AM, 1999 Yamaha XV1600ATL, 2000 Yamaha XV1600ATM
VEHICLE DESCRIPTION: ON CERTAIN ROAD STAR MOTORCYCLES, IF THE BOLTS HOLDING THE EXHAUST SYSTEM ARE ALLOWED TO LOOSEN, THE BRACKET HOLDING THE MUFFLERS CAN BREAK.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME LEFT SIDE REAR BRAKE HOSES WERE DAMAGED DURING ASSEMBLY. BRAKE FLUID LEAKAGE COULD OCCUR.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. STATIC ELECTRICITY CAN BUILD UP WITHIN THE PASSENGER-SIDE AIR BAG MODULE AND CREATE ENOUGH OF A CHARGE TO CAUSE AN INADVERTENT AIR BAG DEPLOYMENT. MOST OF THESE INADVERTENT DEPLOYMENTS HAVE OCCURRED IN COOLER, DRY…
VEHICLE DESCRIPTION: SEDANS EQUIPPED WITH AN "AUTO-UP" POWER WINDOW FEATURE ON THE DRIVER'S DOOR. THE DRIVER'S SIDE POWER WINDOW CONTROL UNIT CAN FAIL, AND DEPENDING ON THE FAILURE MODE, THE WINDOW COULD BECOME INOPERATIVE, OPEN OR CLOSE INDEPENDENT OF SWITCH…
2001 Chevrolet C Series, 2001 Chevrolet Suburban, 2001 Chevrolet Tahoe, 2001 GMC C Series and 3 more
VEHICLE DESCRIPTION: PICKUP AND UTILITY TRUCKS. SOME OF THESE VEHICLES HAVE AN INTERNAL COMPONENT IN THE OUTBOARD SEAT BELT RETRACTORS FOR THE 2ND AND 3RD ROW OF SEATS THAT COULD BE CRACKED. WITH REPEATED ACTUATION OF THE LOCKING MECHANISM, THE CRACK COULD…
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." CERTAIN DRIVER AND PASSENGER SEAT BELT BUCKLES WERE IMPROPERLY MANUFACTURED.
VEHICLE DESCRIPTION: BUS CHASSIS VEHICLES. AN ELECTRICAL PASS-THROUGH CONNECTOR MAY NOT FIT IN THE FIREWALL MOUNTING HOLE CORRECTLY, RESULTING IN THE CONNECTOR DISLODGING AND AN ELECTRICAL TERMINAL CONTACTING THE FIREWALL.
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACTS." THESE VEHICLES HAVE A CONSOLE COVER/ARMREST LID LATCH THAT COULD RELEASE AT LESS THAN THE 10G VERTICAL LOAD…
VEHICLE DESCRIPTION: THE FOLLOWING VEHICLES WERE REPAIRED WITH INCORRECT PARTS: 2002 ACURA 3.2TL SEDANS WITH REPLACEMENT BUCKLES INSTALLED PER RECALL 01V-166001; CERTAIN 2000 ACURA 3.2TL VEHICLES WITH REPLACEMENT BUCKLES INSTALLED AS PRODUCT UPDATE REPAIRS;…
VEHICLE DESCRIPTION: MOTORCYCLES EQUIPPED WITH A NEWLY DESIGNED PULSE ROTOR. THE CRANKSHAFT PULSE ROTOR, A DEVICE USED FOR IGNITION TIMING, COULD FAIL AND CAUSE THE ENGINE TO STALL.
1999–2000 Ford Mustang Cobra, 2000 Ford Mustang Cobra R
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE BALL JOINT ASSEMBLY IN THE REAR KNUCKLE, WHERE THE LOWER CONTROL ARM ATTACHES, IS DISPLACED LONGITUDINALLY FROM ITS INSTALLED POSITION, IT CAN CAUSE HIGHER STRESS LEVELS IN THE KNUCKLE CASTING. IF THIS OCCURS,…
2001 Ford Usps Stripped Chassis
VEHICLE DESCRIPTION: US POSTAL SERVICE STRIPPED CHASSIS. FASTENERS FOR THE SUSPENSION MOUNTING BRACKETS LOCATED ON THE LEFT AND RIGHT FRAME RAIL MAY HAVE BEEN IMPROPERLY INSTALLED RESULTING IN EITHER LOOSE OR MISSING FASTENERS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES USED EXTENSIVELY IN TRACK TYPE RACING EVENTS AND SUBJECTED TO AGGRESSIVE DRIVING CONDITIONS COULD EXPERIENCECRACKING OF THE STEERING RACK MOUNTING BRACKETS.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH AUTOMATIC SEAT BELT PRETENSIONS. THE CR-V IS EQUIPPED WITH TWO SEAT BELT PRETENSIONERS - RETRACTOR AND BUCKLE - IN BOTH THE DRIVER AND FRONT PASSENGER SEATING POSITIONS. SOME BUCKLE PRETENSIONERS USE A…
VEHICLE DESCRIPTION: MOTORCYCLES EQUIPPED WITH A NEWLY DESIGNED ENGINE STOP SWITCH. THE ENGINE STOP SWITCH IS SENSITIVE TO ACCIDENTAL CONTACT OR STRONG JOLTING, SUCH AS HITTING A POTHOLE OR RIDING OVER RAILROAD TRACKS,WHICH COULD CAUSE THE ENGINE TO CUT OUT…
1999–2000 Chevrolet B Series, 1999–2000 Chevrolet C Series(medium), 1999–2000 Chevrolet F6, 1999–2000 Chevrolet F7 and 4 more
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS EQUIPPED WITH TIE ROD ASSEMBLIES CONTAINING 24-DL MODEL BALL SOCKETS AND MANUFACTURED BY TRW. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS,…
1999–2000 Chevrolet B Series, 1999–2000 Chevrolet C Series(medium), 1999–2000 Chevrolet F6, 1999–2000 Chevrolet F7 and 4 more
VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS EQUIPPED WITH AXLE ASSEMBLIES WHICH MAY HAVE BEEN MANUFACTURED WITH TRW MODEL 20EDL BALL SOCKETS. THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW SPECIFICATION CASE DEPTH AND/OR HARDNESS WHICH CAN LEAD TO PREMATURE WEAR…
2000 Kawasaki ZX1200-A1, 2001 Kawasaki ZX1200-A2
VEHICLE DESCRIPTION: MOTORCYCLES. THE NUTS SECURING THE TIRE VALVE STEMS TO THE WHEELS CAN FAIL, RESULTING IN A LOSS OF TIRE AIR PRESSURE.
1999–2000 Freightliner Vcl, 1999–2000 Freightliner Xc, 1999–2000 Freightliner Xcs
VEHICLE DESCRIPTION: RECREATIONAL VEHICLE CHASSIS. A LOSS OF THROTTLE CONTROL (ENGINE WILL RETURN TO IDLE) COULD OCCUR WHEN THE EXHAUST BRAKE HAS BEEN ACTIVATED, THE BRAKES ARE APPLIED, AND THE VEHICLE IS COMING TO A STOP.
VEHICLE DESCRIPTION: PASSENGER VEHICLES USED EXTENSIVELY IN TRACK TYPE RACING EVENTS AND SUBJECTED TO AGGRESSIVE DRIVING CONDITIONS COULD EXPERIENCE CRACKS AT THE WELDS OF THE REAR DIFFERENTIAL MOUNTING BRACKET.
2001 Ford Taurus, 2001 Mercury Sable
VEHICLE DESCRIPTION: PASSENGER CARS. THE SEAT BELT BUCKLE TONGUE MAY NOT FULLY EJECT FROM THE BUCKLE ASSEMBLY WHEN THE RELEASE BUTTON IS PUSHED SLOWLY. THIS CONDITION COULD ALSO RESULT IN A PARTIAL LATCH OF THE TONGUE IN THE BUCKLE.
2000–2001 Freightliner Argosy, 2000–2001 Freightliner Business Class, 2000–2001 Freightliner Century, 2000–2001 Freightliner Fld and 1 more
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH CERTAIN HALDEX BRAKE SYSTEM TWO AND FOUR PORT RELAY VALVES. THE VALVE MAY STICK OPEN WHEN A HIGH-PRESSURE APPLICATION IS RELEASED.
2000–2001 Winnebago Adventurer, 2000–2001 Winnebago Brave, 2000–2001 Winnebago Brave Se, 2000–2001 Winnebago Chieftain and 4 more
VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
1991–1992 Audi 100, 1991–1992 Audi 200, 1991–1992 Audi V8
VEHICLE DESCRIPTION: PASSENGER VEHICLES. AN ELECTROLYTIC CAPACITOR CONTAINED IN THE AMPLIFIER FOR EACH REAR SPEAKER COULD LEAK AN ELECTROLYTE, WHICH MAY IN TIME AND IN THE PRESENCE OF HUMIDITY, CAUSE AN UNWANTED CONDUCTIVE PATH.
2000 Ford 7000, 2000 Ford 8000, 2000 Ford F-650, 2000 Ford F-750
VEHICLE DESCRIPTION: TRUCKS EQUIPPED WITH DRAG LINK ASSEMBLIES CONTAINING 24-DL MODEL BALL SOCKETS AND MANUFACTURED BY TRW. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF…
VEHICLE DESCRIPTION: 4X2 PICKUP TRUCK CONVERTIBLES EQUIPPED WITH V6 ENGINES (BUILT FROM NOVEMBER 1988 - JUNE 1990) AND 4X2 PICKUP TRUCKS EQUIPPED WITH THE SHELBY PACKAGE (BUILT OCTOBER 1988 - JUNE 1989). THE FRAME CAN CRACK AT THE STEERING GEAR ATTACHMENT…
VEHICLE DESCRIPTION: PASSENGER VEHICLES. MOISTURE COULD ENTER THE REAR TRACK CONTROL ARM'S MOUNTING BUSHING AND BOLT COMBINATION AND CAUSE CORROSION.
VEHICLE DESCRIPTION: MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS N841, N821, N641, AND N621. THESE REFRIGERATORS CAN EXPERIENCE A COOLING SYSTEM LEAK CAUSED BY OPERATION IN THE AC ELECTRIC MODE. IF A LEAK…
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUALLY-ADJUSTABLE (NON-POWERED) SEATS. CERTAIN INNER FRONT SLIDE RAIL LATCH MECHANISMS MAY HAVE BEEN IMPROPERLY WELDED.
2000–2001 Triumph Daytona 955I, 2000–2001 Triumph Speed Triple, 2000–2001 Triumph Sprint RS, 2000–2001 Triumph Sprint ST and 2 more
VEHICLE DESCRIPTION: MOTORCYCLES. THE CLUTCH CONTROL CABLE CAN FRAY AND FAIL. THE BARREL AT THE END OF THE INNER CABLE SEIZES IN THE CONTROL LEVER BORE, THEREBY STRESSING THE INNER CABLE.
2001 Mercedes-Benz CL-Class, 2001 Mercedes-Benz S-Class
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SHEATHING MATERIAL ON THE ELECTRICAL CONNECTION OF THE HEATED WINDSHIELD WASHER BOTTLE HOSE COULD OVERHEAT.
VEHICLE DESCRIPTION: MOTORCYCLES EQUIPPED WITH CHROME-PLATED FRAMES. COPPER RESIDUE CAN REMAIN IN THE TAPPED HOLE WHERE THE UPPER FORK BRIDGE ATTACHES TO THE FRAME. MOISTURE CAN CAUSE CORROSION TO OCCUR BETWEEN THE COPPER RESIDUE AND THE ALUMINUM FRAME. THE…
2001 Volvo S80, 2001 Volvo V70
VEHICLE DESCRIPTION: SEDANS AND WAGONS. THE REAR OUTBOARD SEAT BELT ANCHORAGE BOLTS MAY HAVE BEEN INCORRECTLY TIGHTENED.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 110. THESE VEHICLES DO NOT HAVE THE CORRECT TIRE PRESSURE PLACARD ATTACHED.
2000–2001 BMW M5, 2001 BMW 740i, 2001 BMW 740iL, 2001 BMW 750iL
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 18-INCH TIRES. (18-INCH TIRES ARE STANDARD EQUIPMENT ON THE M5 AND OPTIONAL EQUIPMENT ON THE 7-SERIES MODELS). THE MACHINE USED TO MOUNT AND INFLATE THE TIRES ON THE WHEELS AT THE ASSEMBLY PLANT MAY HAVE…
2001 Kawasaki ZR1200-A1/L, 2001 Kawasaki ZR1200A1, 2001 Kawasaki ZRX1200-A
VEHICLE DESCRIPTION: MOTORCYCLES. A SECTION OF THE WIRING HARNESS LOCATED ABOVE THE HEADLIGHT IS ROUTED INCORRECTLY.
VEHICLE DESCRIPTION: MOTORCYCLES. THE DISTANCE BETWEEN THE BRAKE LINE AND THE SPEEDOMETER DRIVE CABLE COULD BE TOO SMALL. DUE TO COMPRESSION AND REBOUND OF THE FORK, THE SPEEDOMETER CABLE COULD CONTACT AND CHAFE THE BRAKE LINE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES (ALLROAD). WHEN ACTIVATING THE WINDSHIELD WIPER UNDER HEAVY LOAD CONDITIONS SUCH AS FREEZING, SNOW OR HEAVY RAIN, ONE WIPER COULD BE DELAYED BEHIND THE OTHER WIPER.
2001 Freightliner Business Class, 2001 Freightliner Vcl, 2001 Freightliner Xb, 2001 Freightliner Xc and 1 more
VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS, FIRE TRUCKS, AND TRANSIT BUSES AND SCHOOL BUSES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES. THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT…
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TWO SCREWS THAT SECURE THE PARKING BRAKE CABLE MOUNTING BRACKET TO THE BACKING PLATE WERE NOT TIGHTENED PROPERLY. AS A RESULT, THE SCREWS COULD LOOSEN AND EVENTUALLY FALL INTO THE PARKING BRAKE DRUM.
VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS EQUIPPED WITH A CAMPER PACKAGE AND OVERLOAD SPRINGS. THE REAR AXLE SPACER PLATE COULD LEAD TO DEFORMATION OF THE UPPER SPRING PLATE DURING ASSEMBLY OF THE AXLE TO THE VEHICLE RESULTING A SOFT JOINT.
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH AN ANTI-LOCK BRAKING SYSTEM (ABS). SOME VEHICLES MAY HAVE INADEQUATE CLEARANCE BETWEEN THE FRONT TIRE/WHEEL AND THE BRAKE HOSE/ABS SENSOR WIRE ASSEMBLY. DURING FULL LOCK TURNS, IT IS POSSIBLE FOR THE TIRE OR…
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IMPROPERLY MANUFACTURED POWERTRAIN CONTROL MODULES (PCM) WERE INSTALLED IN SOME VEHICLES. THE IMPROPERLY MANUFACTURED PCMS CONTAINED A CONDENSER THAT WAS NOT CORRECTLY INSTALLED ONTO THE PCM PRINTED CIRCUIT BOARD. THE…
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LEFT FRONT BRAKE TUBE MAY HAVE BEEN DEFORMED PRIOR TO VEHICLE DELIVERY DUE TO IMPROPER INSTALLATION OF A COIL SPRING SPACER THAT WAS INSTALLED TO PREVENT DAMAGE TO THE VEHICLE DURING TRANSPORTATION.
VEHICLE DESCRIPTION: HEAVY DUTY CLASS 8 VEHICLES. UNDER CERTAIN OPERATING CONDITIONS, THE WEIGHT CERTIFICATION LABEL WHICH CONTAINS FRONT GROSS AXLE WEIGHT RATING (GAWR) INFORMATION PURSUANT TO THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR…
2000–2001 Winnebago Adventurer, 2000–2001 Winnebago Brave, 2000–2001 Winnebago Sun Cruiser
VEHICLE DESCRIPTION: MOTOR HOMES. THE COPPER LINE SUPPLYING LIQUID PROPANE GAS (LPG) TO THE FURNACE MAY HAVE BEEN IMPROPERLY CLAMPED, WHICH COULD CAUSE THE LINE TO COME IN CONTACT WITH A METAL FLANGE.
VEHICLE DESCRIPTION: STEP VANS. WATER COULD ENTER THE ELECTRICAL RELAYS RESULTING IN AN ELECTRICAL SHORT.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE ROD END RETAINING NUTS MAY NOT HAVE BEEN PROPERLY TIGHTENED AT THE FACTORY.
VEHICLE DESCRIPTION: STEP VANS. THE BACK-UP BRAKE PUMP WAS WIRED TO A 25 AMP FUSED CIRCUIT INSTEAD OF THE REQUIRED 50 AMP FUSED CIRCUIT. IF THE BACK-UP HYDRAULIC BRAKE PUMP WERE TO ENGAGE DUE TO A FAILURE IN THE PRIMARY BRAKE ASSIST SYSTEM OR THE BRAKES ARE…
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH HYDRAULIC BRAKES AND A DURAPARK PARK BRAKE SYSTEM MANUFACTURED BY ARVINMERITOR. AIR IS ENTERING THE HYDRAULIC REAR BRAKE CYLINDERS THROUGH AN UNKNOWN PATH AND THE REAR SELF-ADJUSTING BRAKES MAY NOT BE…
2002 BMW 525IA Sport Wagon, 2002 BMW 525i, 2002 BMW 525iA, 2002 BMW 530i and 3 more
VEHICLE DESCRIPTION: DURING THE TIRE MOUNTING PROCESS ON CERTAIN PASSENGER VEHICLES BUILT WITH STANDARD (NON-SPORT) SUSPENSION AND EQUIPPED WITH CONTINENTAL CONTITOURINGCONTACT CH95 ECOPLUS TIRES, SIZE 225/65R16 95H, HAVING DOT CODES 4001, 4101, OR 4201, THE…
1996–1998 Winnebago Journey, 2000–2002 Winnebago Journey Dl, 2000–2002 Winnebago WKP36L, 2000–2002 Winnebago WKP36LD
VEHICLE DESCRIPTION: MOTOR HOMES (MODELS WKP36L, WKP36LD, AND IKP36LD). FOUR NUTS MAY HAVE LOOSENED FROM THE FOUR BOLTS THAT CONNECT THE LIQUID PROPANE (LP) TANK TO THE MOTOR HOME. IF THE ATTACHMENT HARDWARE IS LOOSENED, THE ROAD VIBRATION COULD PRODUCE UNDUE…
VEHICLE DESCRIPTION: ELECTRIC LIGHT DUTY PICKUP TRUCKS. IF THE TRANSAXLE ATTACHING BOLTS BEGIN TO LOOSEN, THE DRIVER COULD NOTICE A JERKING MOTION AND/OR A CLUNKING SOUND. IF NOT SERVICED PROMPTLY, ALL NINE BOLTS COULD ULTIMATELY FALL OUT OR FRACTURE AND THE…
VEHICLE DESCRIPTION: MOTORCYCLES. UNDER CERTAIN RIDING CONDITIONS WHEN THE REAR BRAKE AND THE THROTTLE ARE APPLIED SIMULTANEOUSLY, THE REAR BRAKE CALIPER SUPPORT COULD BEND, LEADING TO CONTACT BETWEEN THE BRAKE HOSE CONNECTING PIECE ON THE REAR CALIPER AND…
VEHICLE DESCRIPTION: MOTORCYCLES. THE FLEXIBLE FUEL HOSE LEADING FROM THE FUEL DISTRIBUTOR CAN CHAFE AGAINST THE RIGID LINES OF THE FUEL FEED AND THE RETURN LINES. CONTINUED CHAFING OF THE FLEXIBLE FUEL HOSE CAN LEAD TO FUEL LEAKAGE.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. MISLABELED SEAT BELTS INTENDED FOR 2-DOOR MODEL VEHICLES WERE INSTALLED IN THE 4-DOOR FRONT PASSENGER SEAT BELT LOCATION. FOR THE PASSENGER SEAT SAFETY BELT, IF THE CHILD SEAT MODE HAS BEEN ENGAGED OR THE BELT IS…
VEHICLE DESCRIPTION: MOTORCYCLES. A TRANSISTOR IN THE IGNITION MODULE CAN OVERHEAT, DISABLING THE IGNITION WITHOUT WARNING.
VEHICLE DESCRIPTION: POLICE MOTORCYCLES EQUIPPED WITH DUNLOP SPORTMAX A REAR TIRES, SIZE 160/60 ZR18. THESE TIRES MAY HAVE BEEN INSTALLED ON SOME OF THE VEHICLES AS REPLACEMENT EQUIPMENT. THE CAMPAIGN IS LIMITED TO THOSE SPORTMAX A REAR TIRES HAVING DATE…
VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY, AXLE BACK MODEL VEHICLES. THE DESIGN OF THE LOWER STEERING COLUMN SHAFT UNIVERSAL JOINT BOOT COULD ALLOW THE BOOT TO GET ENTANGLED IN THE UNIVERSAL JOINT.
1994–1997 Ford Mustang, 1995–1997 Lincoln Town Car
EQUIPMENT DESCRIPTION: PASSENGER VEHICLES THAT HAVE HAD THE DRIVER'S AIR BAG MODULE REPLACED AFTER APRIL 5, 2000. THE REPLACEMENT DRIVER'S AIR BAG MODULE INFLATOR MAY HAVE INSUFFICIENT WELDS THAT COULD PREVENT PROPER INFLATION OF THE AIR BAG.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS. IT IS POSSIBLE THAT THE CLUTCH PRESSURE LINE COULD LEAK IN THE AREA OF ITS CONNECTION WITH THE CLUTCH CYLINDER.
2002 Chevrolet Camaro, 2002 Pontiac Firebird
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION," AND NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES MAY HAVE WELDS NEAR THE LOWER DRIVER'S SIDE DOOR HINGE THAT DO NOT MEET…
2002 Chevrolet Trailblazer, 2002 GMC Envoy
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES (4 WHEEL-DRIVE). SOME OF THESE VEHICLES WERE BUILT WITH A RANGE SHIFT COLLAR IN THE TRANSMISSION TRANSFER CASE THAT CONTAINS CRACKS.
2002 Mercedes-Benz ML320, 2002 Mercedes-Benz ML500, 2002 Mercedes-Benz ML55
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LEFT FRONT UPPER CONTROL ARM MAY NOT MEET THE SPECIFIED STRENGTH REQUIREMENTS.
1999 Volvo Acl, 1999 Volvo Wah, 1999 Volvo Wg, 1999 Volvo Wx and 2 more
VEHICLE DESCRIPTION: HEAVY DUTY, CLASS 8, TRUCKS EQUIPPED WITH TIE ROD ASSEMBLIES CONTAINING 24-DL MODEL BALL SOCKETS AND MANUFACTURED BY TRW. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO…
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. AN INTERNAL NUT IN THE STEERING GEAR ASSEMBLY COULD LOOSEN AND CAUSE THE STEERING GEAR TO LOCK UP.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH RACING OPTION (ACR OR GT2). THE 5-POINT RACING SEAT BELT HARNESS, WHICH IS OPTIONAL EQUIPMENT ON THE VIPER MAY NOT MEET THE VOLUNTARY LOAD SPECIFICATIONS SET FORTH BY THE FIA (FEDERATION INTERNATIONALE DE…
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES FAIL TO CONFORM WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." WHEN THE LOW BEAM HEADLAMPS ARE ACTIVATED, THE XENON LAMPS ARE AIMED TO ILLUMINATE THE ROAD…
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A FUEL AND VAPOR LEAK DETECTION SYSTEM. A "BLIND COVER" AT THE FILLER NECK OF THE FUEL TANK MAY NOT SEAL PROPERLY ALLOWING FUEL VAPOR TO ESCAPE.
VEHICLE DESCRIPTION: HEAVY DUTY CLASS 8 TRUCKS. THE WRONG STEERING COLUMN TO STEERING GEAR SHAFT MAY HAVE BEEN INSTALLED IN THESE VEHICLES. USING THE SHORTER VNM STEERING SHAFT COULD RESULT IN STEERING SHAFT BEING OPERATED (STEERING COLUMN EXTENDED…
VEHICLE DESCRIPTION: HEAVY DUTY CLASS 8 TRUCKS. THE LOWER STEERING SHAFT MAY SIDE-LOAD THE STEERING GEAR INPUT SHAFT. THIS CONDITION COULD RESULT IN NON-UNIFORM STEERING WHEEL EFFORTS WHEN TURNING THE STEERING WHEEL. IN ADDITION, ONCE THE STEERING WHEEL TURN…
2001 Toyota Avalon, 2001 Toyota Camry, 2001 Toyota Sienna
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT SUB FRAME ASSEMBLY HAS NOT BEEN ADEQUATELY WELDED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IT IS POSSIBLE THAT THE FUEL SUPPLY LINE COULD LEAK DUE TO CHAFFING WITH THE INTAKE MANIFOLD AND/OR THE FUEL RETURN LINE COULD LEAK DUE TO CHAFFING WITH A SPRING BAND CLAMP USED TO SECURE A COOLANT LINE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN ALL ACTIVITY MODULE II (AAM II) COULD HAVE A SUB-COMPONENT THAT COULD CAUSE THE MODULE TO INTERMITTENTLY NOT FUNCTION PROPERLY. THE AAM II CONTROLS A NUMBER OF SYSTEMS INCLUDING THE HIGH BEAM LIGHTS, INSTRUMENT…
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." SOME VEHICLES WERE PRODUCED WITH REAR OUTER SEAT BELT SHOULDER GUIDE ANCHOR BOLTS THAT WERE INCORRECTLY INSTALLED.
2001 GMC Yukon Denali, 2001 GMC Yukon Xl Denali
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH A MISROUTED POSITIVE BATTERY CABLE ASSEMBLY THAT COULD COME IN CONTACT WITH THE STEERING SHAFT UNIVERSAL JOINT.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DURING THE ASSEMBLY PROCESS, THE AIR CLEANER BOX COVER MAY HAVE BEEN DAMAGED, AND A BROKEN PLASTIC PIECE COULD TRAVEL INTO THE INTAKE CHAMBER.
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS CONVERTED FROM SLEEPER CABS TO DAY CABS FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
2001 Ford Excursion, 2001 Ford Expedition, 2001 Ford F-150, 2001 Ford F-250 and 2 more
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
2000 Freightliner Fld, 2000 Freightliner Fln, 2000 Freightliner Sterling
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CHALMERS 1000 AND 800 SERIES SUSPENSION KITS. THESE SUSPENSION KITS MAY HAVE INSUFFICIENT PENETRATION OF THE WELD ATTACHING THE TORQUE ROD EYE TO THE TORQUE ROD TUBE.
VEHICLE DESCRIPTION: VANS. A SUBSTITUTE WHEEL LUG NUT TIGHTENING PROCESS MAY NOT HAVE BEEN SUFFICIENT TO ASSURE PROPER TORQUE OF THE LUG NUTS.
2001 Harley-Davidson Harley Davidson
VEHICLE DESCRIPTION: MOTORCYCLES. THESE MOTORCYCLES WERE BUILT WITH A BRAKE SYSTEM THAT COULD CONTAIN OUT OF SPECIFICATION BRAKE FLUID.
1999–2000 Isuzu FSR, 1999–2000 Isuzu FTR, 1999–2000 Isuzu FVR
VEHICLE DESCRIPTION: COMMERCIAL VEHICLES EQUIPPED WITH TIE ROD ASSEMBLIES CONTAINING 24-DL MODEL BALL SOCKETS AND MANUFACTURED BY TRW. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO…
1999–2000 Isuzu FSR, 1999–2000 Isuzu FTR, 1999–2000 Isuzu FVR
VEHICLE DESCRIPTION: COMMERCIAL VEHICLES EQUIPPED WITH AXLE ASSEMBLIES WHICH MAY HAVE BEEN MANUFACTURED WITH TRW MODEL 20EDL BALL SOCKETS/DRAG LINKS. THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW SPECIFICATION CASE DEPTH AND/OR HARDNESS WHICH CAN LEAD TO…
VEHICLE DESCRIPTION: MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE ON TOP OF THE AUTOMATIC TRANSMISSION CAUSING ABRASION TO THE CABLE INSULATION.
2001 Mitsubishi Eclipse, 2001 Mitsubishi Eclipse Spyder, 2001 Mitsubishi Galant
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A BULGE IN THE FUEL TANK CAUSED BY THE MANUFACTURING PROCESS RESULTED IN THINNING OF THE MATERIAL DURING A WELDING OPERATION, INCREASING THE RISK OF FUEL LEAKAGE.
2001 Chevrolet C Series(medium), 2001 GMC C Series(medium)
VEHICLE DESCRIPTION: MEDIUM DUTY C SERIES VEHICLES EQUIPPED WITH AN IMPCO LIQUEFIED PETROLEUM GAS (LPG) CONVERSION KIT. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE ENGINE COULD BACKFIRE AND FRACTURE THE PLASTIC INLET ELBOW WITHIN THE ENGINE…
2001 Ford F-350, 2001 Ford F-Super Duty
VEHICLE DESCRIPTION: F-SUPER DUTY CREW CAB PICKUP TRUCKS (F-350 SHORT WHEELBASE TRUCKS EQUIPPED WITH A 6 3/4' PICKUP BOX AND DUAL REAR WHEELS) WERE BUILT AFTER A CHANGE WAS IMPLEMENTED TO DELETE A CLAMP, AND LATER A BRACKET THAT PROVIDED A GROUND FOR THE FUEL…
2000 Volvo Acl, 2000 Volvo Wg, 2000 Volvo Wx, 2000 Volvo Wxll
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH ACCURIDE 22.5 X 8.25 15 TUBELESS DEMOUNTABLE RIMS, PART NO. 32051. CERTAIN RIMS CONTAIN A NON-FUSION AREA IN THE BUTT-WELD OF THE MOUNTING RING. UNDER CERTAIN CIRCUMSTANCES, THE DEFECT COULD DEVELOP INTO A…
VEHICLE DESCRIPTION: MOTORCYCLES. THE SINGLE FRONT SPRING STRUT IS MOUNTED BETWEEN THE FRAME AND THE FRONT SUSPENSION ARM, AFT OF THE FRONT FORK TUBES. DUE TO A WELDING PROBLEM DURING PRODUCTION OF THE SPRING STRUT, THE LOWER SPRING SEAT ON THE STRUT COULD…
2001 Fleetwood Mallard 39D, 2001 Fleetwood Prowler 39D, 2001 Fleetwood Terry 39D, 2001 Fleetwood Wilderness 39D
VEHICLE DESCRIPTION: TRAVEL TRAILERS EQUIPPED WITH THE BEDROOM SLIDE OPTION #966. THESE TRAVEL TRAILERS CAN EXPERIENCE TOWING INSTABILITY AT SPEEDS IN EXCESS OF 55 MPH.
1999 Forest River Forest River
VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON SPARTAN CHASSIS EQUIPPED WITH AXLE ASSEMBLIES WHICH MAY HAVE BEEN MANUFACTURED WITH TRW MODEL 20EDL BALL SOCKETS/DRAG LINKS. THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW SPECIFICATION CASE DEPTH AND/OR HARDNESS WHICH…
2001 Winnebago Adventurer, 2001 Winnebago Sun Cruiser, 2001 Winnebago WPG35U, 2001 Winnebago WPG37G
VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON A WORKHORSE CHASSIS. THE BLACK PIPE SUPPLYING LIQUID PROPANE (LP) GAS TO THE FURNACE WAS NOT LONG ENOUGH, WHICH COULD CAUSE THE COPPER LINE THAT IS CONNECTED TO THIS PIPE TO COME IN CONTACT WITH THE END OF THE LEAF…
VEHICLE DESCRIPTION: CERTAIN 2500 WAGONS WERE EQUIPPED WITH INCORRECT LOAD RANGE TIRES.
VEHICLE DESCRIPTION: CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE WIRING TO THE HEADLAMP ASSEMBLIES IS INCORRECT CAUSING A LOW BRIGHTNESS OF THE HEADLAMPS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT WITH 15" WHEELS, EQUIPPED WITH AN R/T PACKAGE. CERTAIN VEHICLES WERE EQUIPPED WITH AN INCORRECT TIRE PLACARD. THE VEHICLES WERE EQUIPPED WITH P195/50R16 TIRES BUT THE TIRE PLACARD INDICATED THAT THE RECOMMENDED…
VEHICLE DESCRIPTION: MOTORHOMES. THE HOSE SUPPLYING LIQUID PROPANE GAS (LPG) TO THE REFRIGERATOR IN THE SLIDEOUT OF THE UNIT DID NOT HAVE ADEQUATE HOSE "LOOP" AT THE EXTENSION MECHANISM. THE INSUFFICIENT AMOUNT OF HOSE IN THIS LOOP COULD CAUSE DAMAGE TO THE…
VEHICLE DESCRIPTION: CERTAIN CLASS A MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MOTOR HOMES WERE NOT EQUIPPED WITH RED REFLEX REFLECTORS ON THE REAR AND RED REFLEX…
2001 Chevrolet C6H042, 2001 GMC C6H042
VEHICLE DESCRIPTION: CERTAIN MEDIUM DUTY CONVENTIONAL TRUCKS EQUIPPED WITH EATON 19060S SINGLE SPEED REAR AXLES AND MICHELIN 245/70R19.5G XZE TIRES ON THE REAR WHEELS FAIL TO COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN…
VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON A FORD CHASSIS. THESE VEHICLES MAY HAVE THE INCORRECT LIQUID PROPANE (LP) GAS TANK BRACKET. DEPENDING ON HOW THE TANK WAS INSTALLED, THERE MAY NOT BE ADEQUATE CLEARANCE BETWEEN THE TANK AND A BOLT HEAD ON THE…
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT WITH AN INCORRECT POWER BRAKE BOOSTER AND MASTER CYLINDER ASSEMBLY.
VEHICLE DESCRIPTION: MOTORCYCLES. A TRANSMISSION CIRCLIP WAS NOT SEATED CORRECTLY AND COULD ALLOW GEARS TO LOCK.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO AN ASSEMBLY ERROR DURING VEHICLE PRODUCTION, ANY OF THE THREE BOLTS THAT SECURE THE PULLEY TO THE PUMP MAY HAVE BEEN INADEQUATELY TIGHTENED.
2001 Mitsubishi Eclipse, 2001 Mitsubishi Eclipse Spyder, 2001 Mitsubishi Galant
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A NUMBER OF INCORRECT DRIVER SIDE SEAT MOUNTING BOLTS WERE INSTALLED INTO VEHICLES.
VEHICLE DESCRIPTION: 4X2 TRUCKS EQUIPPED WITH TU4 WHITE LETTER TIRE UPGRADE OPTION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. TIRE DAMAGE MAY HAVE OCCURRED DUE TO IMPROPER…
2001 Chevrolet Lumina, 2001 Chevrolet Venture, 2001 Pontiac Aztek, 2001 Pontiac Grand Prix and 2 more
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND…
Vehicle counts are the manufacturer's estimates in its report to NHTSA. Only makes covered by this site are counted, and a recall is counted in the year it was filed.