Biggest recalls
256 recalls filed with NHTSA in 2007, covering about 14,720,000 vehicles. The 200 largest are listed.
1992–2003 Ford E-150, 1992–2003 Ford E-250, 1992–2003 Ford E-350, 1995–2002 Ford F-53 and 17 more
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
1997–2003 Ford E-Series, 1997–2003 Ford Excursion, 1997–2003 Ford F-250 Sd, 1997–2003 Ford F-350 Sd and 2 more
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.
1999–2006 Volkswagen GTI, 1999–2006 Volkswagen Golf, 2001–2007 Volkswagen Beetle, 2001–2005 Volkswagen Jetta and 2 more
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
2002–2006 Nissan Altima, 2002–2006 Nissan Sentra
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANKSHAFT POSITION SENSOR CAN OVERHEAT CAUSING A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT FROM THE SENSOR.
2001–2002 Dodge Dakota, 2001–2002 Dodge Durango, 2001–2002 Dodge Ram Van, 2002 Dodge Ram Pickup
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK"…
2004–2007 Toyota Sequoia, 2004–2006 Toyota Tundra
ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN…
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
1997–2001 Infiniti QX4, 1997–2001 Nissan Pathfinder
ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE…
2005–2008 Volkswagen Jetta, 2006–2008 Volkswagen GTI, 2006–2008 Volkswagen R32, 2006–2008 Volkswagen Rabbit
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM…
ON SOME SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, AN INTEGRATED CIRCUIT IN THE INSTRUMENT CLUSTER THAT CONTROLS INTERIOR LIGHTING MAY OVERHEAT.
2006–2007 Jeep Commander, 2006–2007 Jeep Grand Cherokee, 2007 Dodge Nitro, 2007 Jeep Wrangler
ON CERTAIN SPORT UTILITY VEHICLES, THE SOFTWARE PROGRAMMED INTO THE ABS ELECTRONIC CONTROL MODULE MAY ALLOW A MOMENTARY DELAY IN BRAKING WHEN COASTING UP A HILL DURING CERTAIN CONDITIONS.
2005–2007 Cadillac CTS, 2005–2007 Cadillac SRX, 2005–2007 Cadillac STS, 2006–2007 Pontiac Solstice and 1 more
ON CERTAIN PASSENGER VEHICLES, THE REAR AXLE PINION SEAL DOES NOT MEET ALL OF THE SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.
2005 Chrysler Town and Country, 2005 Dodge Caravan
CERTAIN MINIVANS ARE BEING RECALLED THAT WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE 27 STATES PLUS THE DISTRICT OF COLUMBIA THAT USE GREATER AMOUNTS OF SALT FOR WINTER ROAD DEICING. THE UP-FRONT (UF) AIR BAG SENSORS THAT CONTAIN BRASS BUSHINGS…
ON CERTAIN VEHICLES, THE WHEEL SPEED SENSOR HOUSING USES AN O-RING SEAL TO PREVENT LEAKAGE TO OR FROM THE WHEEL BEARING. IF ASSEMBLED IMPROPERLY, THE O-RING MAY NOT SEAL PROPERLY ALLOWING WATER TO ENTER THE WHEEL BEARING AND EVENTUALLY CAUSE DAMAGE TO THE…
2005–2008 Land Rover LR3, 2006–2008 Land Rover Range Rover Sport
CERTAIN AFTERMARKET THULE HITCH STYLE BICYCLE RACKS WITH FOLD DOWN STYLE BIKE ARMS. A PINCH BOLT EXISTS BETWEEN THE BIKE ARM BRACKET AND THE UPRIGHT ASSEMBLY OF THE HITCH STYLE BICYCLE RACK.
1997–2004 Fleetwood American Eagle, 1997–2004 Fleetwood American Heritage, 1997–2004 Fleetwood American Tradition, 1997–2004 Fleetwood Bounder and 20 more
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS…
2005 Acura RL, 2005 Acura TL, 2005 Acura TSX, 2005 Honda Accord and 2 more
ON CERTAIN VEHICLES, A COIL WIRE INSIDE THE FUEL PUMP RELAY MAY BREAK, CAUSING THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.
2002–2003 Ford E-550, 2003 Ford Excursion, 2003 Ford F-150, 2003 Ford F-250 Sd and 4 more
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH VALEO HEATING, VENTILATION AND AIR CONDITIONING (HVAC), THE BLOWER MOTOR MAY OVERHEAT.
ON CERTAIN VEHICLES, IF A SUFFICIENTLY HOT OBJECT ENTERS THE AIR FILTER HOUSING THROUGH THE ENGINE FRESH AIR INTAKE SYSTEM AND CONTACTS THE ENGINE AIR FILTER, THE FLAMMABILITY CHARACTERISTICS OF THE AIR FILTER MATERIAL ARE SUCH THAT THE FILTER MAY IGNITE.
1999–2007 Chevrolet Silverado, 1999–2007 GMC Sierra 1500, 2000–2006 Chevrolet Suburban 1500, 2000–2006 Chevrolet Tahoe and 13 more
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY…
ON CERTAIN SEDAN AND HYBRID (CNG) VEHICLES, DURING ASSEMBLY, THE TELESCOPIC STEERING COLUMN MECHANISM MAY HAVE BEEN OVER-LUBRICATED WITH SILICONE GREASE. OVER TIME, SOME OF THIS EXTRA GREASE MAY DRIP ON THE BRAKE LIGHT SWITCH CAUSING THE SWITCH TO FAIL.
1997–2003 Forest River All American Sport, 1997–2003 Forest River Auto Master, 1997–2003 Forest River Auto Plus, 1997–2003 Forest River Cardinal and 23 more
CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
1997–2004 Keystone Sprinter, 1998–2004 Keystone Springdale, 1999–2004 Keystone Cabana, 1999–2004 Keystone Cougar and 12 more
CERTAIN FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN CERTAIN TUBING IN THE REFRIGERATOR WHICH COULD ALLOW PRESSURIZED FLAMMABLE COOLANT SOLUTION TO BE RELEASED INTO AN…
1990–1999 Chevrolet P30, 1990–1999 GMC P3500, 1990–1998 GMC G1500, 1990–1998 GMC G2500 and 43 more
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451…
ON CERTAIN POLICE VEHICLES EQUIPPED WITH STEEL WHEELS, SOME OF THE WHEELS MAY DEVELOP CRACKS IN THE RIM NEAR THE WELD LINE THAT CONNECTS THE RIM TO THE DISK.
2003–2008 Volvo Vhd, 2003–2008 Volvo Vnl, 2003–2008 Volvo Vnm, 2005–2008 Volvo VT
ON CERTAIN HEAVY DUTY TRUCKS, THE CIRCUIT PROTECTION (I.E. AUTOMATIC CIRCUIT BREAKERS) USED TO PROTECT THE VEHICLE LIGHTING SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION.
2007–2008 Chrysler Sebring, 2007–2008 Dodge Avenger
ON CERTAIN VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE ENGINE COOLANT MAY BE DRAWN INTO THE LEFT RADIATOR COOLING FAN MOTOR CONNECTOR.
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
2001–2005 SAAB 9-5, 2002–2003 SAAB 9-3, 2000 SAAB 9-3 Convertible
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
2004–2006 Suzuki Forenza, 2004–2006 Suzuki Reno
ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.
ON CERTAIN PICKUP TRUCKS, THE FRONT WHEEL BEARING MAY HAVE RECEIVED AN INSUFFICIENT QUANTITY OF GREASE DURING THE MANUFACTURING PROCESS.
ON CERTAIN VEHICLES, THE SEAT POSITION SENSOR (SPS) DETECTS THE DRIVER'S SEATING POSITION AND ADJUSTS THE AIR BAG INFLATION PRESSURE ACCORDINGLY. THE WIRING HARNESS FOR THE SPS WAS ATTACHED TO THE SEAT FRAME IN THE WRONG LOCATION AND MAY HAVE BEEN OVER…
2007 Dodge Nitro, 2007 Jeep Wrangler
ON CERTAIN VEHICLES, THE TOTALLY INTEGRATED POWER MODULE (TIPM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN OPERATING CONDITIONS.
1998–2002 Mazda B-Series Truck
ON CERTAIN TRUCKS EQUIPPED WITH A SPEED CONTROL SYSTEM, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
2006–2007 Suzuki Forenza, 2006–2007 Suzuki Reno
ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT BELT TONGUE WILL NOT LATCH INTO THE BUCKLE AND, IN RARE CASES, EVEN THE LOCKED TONGUE WILL POP OUT BY LOW STRETCHING FORCE. IF THE BUCKLE DOES NOT LATCH COMPLETELY, THE BUCKLE COULD RELEASE WITHOUT PRESSING THE…
2003–2008 Freightliner Argosy, 2003–2008 Freightliner Business Class M2, 2003–2008 Freightliner Century St, 2003–2008 Freightliner Classic and 10 more
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH…
2007–2008 Chrysler Sebring, 2007–2008 Dodge Avenger
ON CERTAIN VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING POSSIBLY CAUSING THE LATCH TO STICK IN THE UNLATCHED POSITION OR THE LOCK FUNCTION TO BECOME INOPERATIVE.
CERTAIN VEHICLES EQUIPPED WITH 2.5L GASOLINE ENGINES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST THE UNDERHOOD FUEL SUPPLY LINE.
2007 Chevrolet Equinox, 2007 Pontiac Torrent
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIRBAGS OR OPTIONAL SUNROOF FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201,"OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING NHTSA IMPACT TESTS, THE INTERIOR…
2007–2008 Lexus ES350, 2007–2008 Toyota Camry
CERTAIN ALL WEATHER FLOOR MATS (AWFM) SPECIFICALLY SOLD AS AN OPTIONAL ACCESSORY FOR USE ON THE 2007 AND 2008 MODEL YEAR LEXUS ES350 AND TOYOTA CAMRY VEHICLES. THE AWFM INCLUDES TWO GROMMET HOLES AND RETAINING HOOKS (CLIPS) TO SECURE THE MAT TO THE VEHICLE'S…
2007 Harley-Davidson FLSTN, 2007 Harley-Davidson FXST, 2007 Harley-Davidson FXSTC, 2007 Harley-Davidson Flstc and 6 more
CERTAIN MOTORCYCLES WERE BUILT WITH A CONDITION THAT PERMITS THE POSITIVE BATTERY CABLE TO CONTACT A WELD BEAD ON THE OIL TANK. THIS MAY CAUSE THE WELD BEAD TO ABRADE THROUGH THE INSULATION ON THE CABLE AND CAUSE AN ELECTRICAL SHORT FROM THE BATTERY THROUGH…
ON CERTAIN PASSENGER VEHICLES, PROLONGED HIGH UNDER-HOOD TEMPERATURES MAY CAUSE THE POWER STEERING HOSE TO DETERIORATE PREMATURELY CAUSING THE HOSE TO CRACK AND LEAK POWER STEERING FLUID.
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
2007–2008 Freightliner Century St, 2007–2008 Freightliner Columbia, 2007–2008 Freightliner Coronado
ON CERTAIN TRUCKS BUILT WITH A TRW GLOBAL ADJUSTABLE UPPER STEERING COLUMN, TWO UPPER TILT PLATE BOLTS MAY LOOSEN WITH USE AND FALL OUT. THESE FASTENERS HOLD THE UPPER COLUMN ASSEMBLY IN PLACE. THE STEERING COLUMN PIVOT MAY FRACTURE IF THE BOLTS ARE MISSING…
CERTAIN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION. ' THE AUTOMATIC TRANSMISSION SELECTOR LEVER "PARK" LOCK FUNCTION MAY BE INOPERATIVE DUE TO A…
ON CERTAIN PASSENGER VEHICLES, THE REAR QUARTER GLASS ATTACHING FASTENERS MAY PULL THROUGH THEIR MOUNTS AND ALLOW THE GLASS TO SEPARATE FROM THE VEHICLE.
2006–2008 Freightliner Argosy, 2006–2008 Freightliner Business Class M2, 2006–2008 Freightliner Century St, 2006–2008 Freightliner Classic and 5 more
ON CERTAIN TRUCK-TRACTORS EQUIPPED WITH HOLLAND SIMPLEX SE OR SE II FIFTH WHEELS, THE LATCH LEVER PIVOT BOLT ASSEMBLY MAY HAVE BEEN OVER-TIGHTENED WHICH COULD DISTORT THE PIVOT BOLT SPACER SLEEVE. CORROSION OR CONTAMINATES IN THE PIVOT MAY CAUSE IT TO BIND…
ON CERTAIN SPORT UTILITY VEHICLES, UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL MODULE (CCM) MAY RECEIVE A 'SHUT-DOWN SIGNAL' FROM THE ENGINE CONTROL MODULE (ECM) AFTER IGNITION KEY INSERTION. IF THIS CONDITION OCCURS, THE CLIMATE CONTROL FUNCTIONS WILL NOT…
ON CERTAIN CREW CAB MODEL TRUCKS, THE SEAT BACK SHAPE MAY BE SUCH THAT THERE MAY NOT BE SUFFICIENT WEBBING ON THE RETRACTOR SPOOL FOR THE REAR CENTER SEAT BELT TO RELEASE FROM THE AUTOMATIC LOCKING MODE (ALR) AFTER IT IS ENGAGED AND THE SEAT BELT IS…
2006–2007 Harley-Davidson XL1200L, 2006–2007 Harley-Davidson XL1200R, 2007 Harley-Davidson XL1200N, 2007 Harley-Davidson XL50 and 3 more
CERTAIN MOTORCYCLES WERE BUILT WITH A CONDITION WHEREBY THE PANT LEG OF SOME RIDERS CAN HAVE DIRECT CONTACT WITH THE EXHAUST PIPE.
ON CERTAIN VEHICLES, THE HEAT GENERATED BY THE ENGINE CAUSES REPEATED BENDING DEFORMATION OF THE POLYPROPYLENE COOLING FAN INCLUDING ITS RETAINING RING, WHICH STRESSES THE POLYPROPYLENE THEREBY INITIATING CRACKING OF THE BLADES. THE CENTRIFUGAL FORCES…
2003 Audi A4, 2003 Audi A6, 2003 Volkswagen Passat
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
ON CERTAIN VEHICLES, HIGH STRESS AREAS MAY HAVE BEEN CREATED IN TWO SPECIFIC FUEL PIPES LOCATED IN THE ENGINE COMPARTMENT. COMBINED WITH OTHER FACTORS SUCH AS THE PRESENCE OF CORROSIVE AGENTS IN FUEL, A CRACK MAY FORM OVER TIME LEADING TO FUEL LEAKAGE FROM…
ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA,…
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN…
2002–2007 Kawasaki KL650A, 2008 Kawasaki KL650E
ON CERTAIN MOTORCYCLES, INSUFFICIENT TIGHTENING OF THE MUFFLER MOUNTING BOLTS COULD ALLOW THE BOLTS TO LOOSEN.
2002–2005 Land Rover Freelander
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE LIGHTS MAY REMAIN ILLUMINATED EVEN WHEN THE BRAKE PEDAL IS NOT DEPRESSED. HILL DESCENT CONTROL (HDC), TRACTION CONTROL (TC) AND CRUISE CONTROL WARNING LIGHTS MAY ALSO BE ILLUMINATED.
2008 Ford F-250, 2008 Ford F-350, 2008 Ford F-450 Sd, 2008 Ford F-550 Sd
ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, EXCESSIVE TEMPERATURES IN THE DIESEL PARTICULATE FILTER IN THE EXHAUST SYSTEM MAY RESULT FROM EXCESS HYDROCARBONS IN THE EXHAUST.
2003–2004 Volvo S60, 2003–2004 Volvo V70
ON CERTAIN PASSENGER VEHICLES, THE FUEL PRESSURE SENSOR LOCATED ON THE LEFT END OF THE FUEL RAIL MAY, AT TIMES, TRANSMIT INCORRECT SIGNAL REGARDING THE FUEL PRESSURE TO THE ENGINE CONTROL MODULE. IF THE SIGNAL IS OUTSIDE OF THE PRE-PROGRAMMED ALLOWABLE…
ON CERTAIN PASSENGER VEHICLES, CERTAIN PARTS OF THE INTEGRATED MOTOR ASSIST (IMA) SYSTEM ARE LOCATED UNDER A METAL COVER BEHIND THE REAR SEAT-BACK. OVER TIME THE WEIGHT OF REAR SEAT PASSENGERS MAY CAUSE THE METAL COVER TO COME INTO CONTACT WITH A RUBBER CAP…
2004 Kawasaki EX250F18, 2004 Kawasaki EX250F18L, 2005 Kawasaki EX250F19, 2005 Kawasaki EX250F19L and 4 more
ON CERTAIN NINJA MOTORCYCLES, THE FUEL TANK MAY HAVE BEEN PUNCTURED OR WEAKENED BY A FAIRING MOUNTING SCREW OR MANUFACTURING OPERATION.
2006–2008 BMW 550i, 2006–2007 BMW 650i, 2007 BMW X5 Sav
ON CERTAIN VEHICLES EQUIPPED WITH V8 ENGINES, IN CONDITIONS OF BELOW FREEZING TEMPERATURES COMBINED WITH LOW HUMIDITY, IT IS POSSIBLE FOR ELECTROSTATIC DISCHARGE TO OCCUR AT THE FUEL RAILS. IF THIS WERE TO OCCUR, THE ENGINE ELECTRONIC CONTROL UNIT (ECU) COULD…
2007–2008 Jeep Commander, 2007–2008 Jeep Grand Cherokee
ON CERTAIN SPORT UTILITY VEHICLES, FRONT BRAKE CALIPERS IN A CERTAIN LOT MAY HAVE BEEN MANUFACTURED FROM GRAY IRON INSTEAD OF DUCTILE IRON AS DESIGNED AND COULD FRACTURE WITHOUT WARNING.
2002–2007 Suzuki GZ250, 2004–2007 Suzuki GS500
THE REAR REFLEX REFLECTOR ON AFFECTED GS500 MOTORCYCLES AND THE REAR AND SIDE REFLEX REFLECTORS ON AFFECTED GZ250 MOTORCYCLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED…
2005–2006 Freightliner Century St, 2005–2006 Freightliner Columbia, 2005–2006 Freightliner Coronado
CERTAIN FREIGHTLINER SCHOOL BUSES AND TRUCKS MANUFACTURED FROM OCTOBER 23, 2004, TO MARCH 21, 2006. DURING THE STEERING COLUMN MANUFACTURING PROCESS TWO WELDS MAY HAVE BEEN MISSING.
CERTAIN MOTORCYCLES HAVE AN IMPROPER WELDED VENT PIPE IN THE BOTTOM OF THE FUEL TANK. DUE TO VIBRATION THE IMPROPERLY WELDED TANKS MAY CRACK AND DRIP FUEL.
2006–2008 Audi A6, 2007–2008 Audi Q7
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE AUTOMATIC REAR LID INCLUDES AN ELECTRIC MOTOR AND CLUTCH THAT WORK IN CONJUNCTION WITH TWO GAS STRUTS TO OPEN AND CLOSE THE REAR LID, INCLUDING A MANUAL CLOSE FUNCTION. IF ONE OF THE STRUTS HAS A TOTAL LOSS…
2001–2004 Chevrolet Venture, 2001–2004 Pontiac Aztek, 2001–2004 Pontiac Montana, 2002–2004 Buick Rendezvous
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.2L 4-CYLINDER ENGINE, LINKS IN THE ENGINE'S TIMING CHAIN CAN SEPARATE.
2000–2004 Mercedes-Benz CL-Class, 2000–2004 Mercedes-Benz S-Class
ON CERTAIN VEHICLES, CORROSION MAY OCCUR IN THE INNER STEEL PORTIONS OF THE ACTIVE BODY CONTROL'S (ABC) HIGH PRESSURE DISTRIBUTION HOSE DUE TO EXTENSIVE EXPOSURE TO HUMIDITY CAUSING DETERIORATION OF THE HOSE.
2007–2008 Fleetwood Bounder Diesel, 2007–2008 Fleetwood Discovery, 2007–2008 Fleetwood Excursion, 2007–2008 Fleetwood Expedition and 8 more
FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH…
2007 Buick Lucerne, 2007 Cadillac CTS
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, 'POWER OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS.' UNDER THE STANDARD, THE SUNROOF MAY ONLY BE CLOSED WHEN THE IGNITION IS ON, OR AFTER THE…
ON CERTAIN HATCHBACK VEHICLES, THE TERMINALS FOR THE PASSENGER SIDE SEAT BELT TENSION SENSOR HARNESS CONNECTOR MAY HAVE BEEN DAMAGED DURING THE MANUFACTURING PROCESS. THIS COULD RESULT IN A LOSS OF ELECTRICAL CONTINUITY CAUSING THE OCCUPANT DETECTION SYSTEM…
ON CERTAIN ROAD STAR WARRIOR MOTORCYCLES, THE LEAD WIRES FOR THE PICK-UP COIL CAN BREAK WHILE THE ENGINE IS RUNNING, CAUSING THE ENGINE TO STALL AND BE IMPOSSIBLE TO RESTART.
ON CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS, DUE TO THE IMPROPER HEAT TREATMENT OF THE SLIP YOKES THAT HAD BEEN REWORKED DURING THE MANUFACTURING PROCESS, THE HARDNESS OF THE SLIP YOKE MAY BE INSUFFICIENT.
ON CERTAIN VEHICLES EQUIPPED WITH 5-SPEED MANUAL TRANSMISSIONS, DUE TO IMPROPER SHAPE OF THE CLIP, THE RETAINING CLIP THAT KEEPS THE GEAR SHIFT CABLE ATTACHED TO THE GEAR SHIFT LEVER CAN CONTACT THE GEAR SHIFT LEVER HOUSING IF EXCESSIVE LATERAL FORCE IS…
CERTAIN TYC HEADLAMP ASSEMBLIES P/NS 20-6361-00 AND 20-6362-00 SOLD AS AFTERMARKET EQUIPMENT FOR 2003-2006 HONDA ACCORD PASSENGER VEHICLES. THE PHOTMETRIC WERE MISALIGNED WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS,…
2005–2007 Yamaha YP400, 2006–2007 Yamaha CP250
ON CERTAIN MOTORCYCLES, A LEAK AT THE FUEL PUMP SEAL MAY ALLOW FUEL LEAKAGE.
ON CERTAIN MOTORCYCLES, EACH TIME THE IGNITION SWITCH IS TURNED OFF, THE ENGINE CONTROL MODULE (ECM) PRE-SETS THE POSITION OF THE IDLE SPEED CONTROL (ISC) VALVE FOR SUBSEQUENT ENGINE STARTING BY OPENING THE VALVE COMPLETELY AND THEN CLOSING IT TO A START-UP…
1999–2006 Volvo S80, 2001–2006 Chrysler Sebring, 2001–2006 Dodge Stratus, 2001–2007 Toyota Sequoia and 20 more
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED…
2007 GMC Acadia, 2007 Saturn Outlook
ON CERTAIN VEHICLES, THE SENSING AND DIAGNOSTIC MODULE (SDM), WHICH CONTROLS THE FUNCTION OF FRONT AIR BAGS, MAY NOT OPERATE PROPERLY. AS A RESULT, THE FRONT AIR BAGS MAY FAIL TO DEPLOY IN A FRONTAL CRASH. ALSO, THE AIR BAG WARNING LAMP ON THE INSTRUMENT…
ON CERTAIN MOTORCYCLES, THE FUEL HOSE THAT CONNECTS THE TWO METAL FUEL DELIVERY PIPES MOUNTED ON THE THROTTLE BODY MAY HAVE BEEN CLAMPED AT A LOCATION ON THE PIPES THAT IS NOT COMPLETELY ROUND, WHICH COULD ALLOW FUEL LEAKAGE TO OCCUR.
2001 Chevrolet Silverado, 2001 Chevrolet Suburban, 2001 GMC Sierra, 2001 GMC Yukon
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN 8.1L V8 ENGINE, THE CRANKSHAFT POSITION CAN OPERATE INTERMITTENTLY OR FAIL COMPLETELY. IF THE SENSOR OPERATES INTERMITTENTLY, THE SES LIGHT MAY ILLUMINATE AND THE VEHICLE MAY RUN ROUGH. THE ENGINE MAY STALL, AND IF…
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. DS517-B001L AND DS517-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE OPTICEL SURFACE OF THE REFLECTOR IS CORRODED INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS…
ON CERTAIN PASSENGER VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING CAUSING THE DOOR LATCH TO STICK IN THE OPEN POSITION AND NOT BE SECURED TO THE STRIKER.
2008 Ford Expedition, 2008 Nissan Xterra
CERTAIN CONTINENTAL AUTOMOTIVE ABS AND ESC CONTROL MODULES SOLD FOR INSTALLATION ON THE VEHICLES LISTED ABOVE. SOME OF THE HYDRAULIC VALVES IN THE ESC MODULE WERE BUILT WITH EXTRA CHECK BALLS.
2007 Chevrolet Express 1500, 2007 GMC Savana 1500
CERTAIN VANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." WHEN THE BRAKES ARE APPLIED, THE STOP LAMPS WILL ILLUMINATE. WHEN THE BRAKE PEDAL IS RELEASED, THE STOP…
ON CERTAIN MOTOR HOME CHASSIS BUILT USING INLINE POWER STEERING FILTERS, PART NO. 14-16829-000, THE FILTER CAN PLUG DUE TO FAILURE OF THE SCREEN ADHESION TO THE FILTER HOUSING CAUSING A RISE IN RETURN LINE PRESSURE. THIS CAN LEAD TO HOSE SEPARATION FROM THE…
2006–2007 Chevrolet Kodiak, 2006–2007 GMC Topkick, 2006–2007 Isuzu F Series, 2006–2007 Isuzu H-Series
ON CERTAIN STRAIGHT TOWING OR NON-TOWING TRUCKS EQUIPPED WITH BENDIX AIR BRAKES, THE AIR BRAKE PARK CONTROL VALVE MAY DEVELOP EITHER AN INTERNAL AIR LEAK OR AN AIR RESTRICTION. THE PARK BRAKE MAY NOT RELEASE OR MAY RELEASE ONLY PARTIALLY.
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 315-1145L-AS AND 315-1145R-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION THE LAMP REFLECTOR SHAPE DEFORMED CHANGING THE SHAPE OF THE OPTIC SURFACE.…
2007–2008 Volvo VT, 2007–2008 Volvo Vhd, 2007–2008 Volvo Vnl, 2007–2008 Volvo Vnm
ON CERTAIN TRUCKS, THE NUT USED TO RETAIN THE STEERING SHAFT MAY OR MAY NOT BE A LOCK NUT THAT HAS THE LOCKING FEATURE. A LOCK NUT IS REQUIRED TO PROVIDE ADDITIONAL RESISTANCE TO ENSURE THAT THE NUT DOES NOT COME LOOSE.
2008 Ford Crown Victoria, 2007 Lincoln Town Car, 2008 Mercury Grand Marquis
ON CERTAIN PASSENGER VEHICLES, A FRONT WHEEL BEARING AND HUB ASSEMBLY MAY FRACTURE DUE TO IMPROPER HEAT TREATMENT.
ON CERTAIN MOTORCYCLES, WHEN EQUIPPED WITH A WINDSHIELD, THE THROTTLE CABLES CAN KINK AT THE GUIDE BRACKET LOCATED AT THE STEERING HEAD WHEN THE HANDLEBAR IS TURNED ALL THE WAY TO THE LEFT. IN THIS POSITION, A KINKED CABLE CAN CAUSE EITHER A STICKLY THROTTLE…
ON CERTAIN MOTORCYCLES, THE CRANKCASE BREATHER SEPARATOR MAY BE DEFECTED. DURING THE MOLDING PROCESS, THE BREATHER PASSAGE MAY HAVE BEEN BLOCKED BY A THIN LAYER OF THE INJECTED PLASTIC MATERIAL. THIS BLOCKAGE WILL CREATE A BUILD-UP OF PRESSURE INSIDE THE…
ON CERTAIN PASSENGER VEHICLES, AN INCORRECT TEMPORARY ASSEMBLY INSTRUCTION RESULTED IN AN INCORRECT ASSEMBLY OF THE LEFT DOOR HANDLE BOWDEN CABLE ATTACHMENT.
2006 Subaru Forester, 2006 Subaru Impreza
ON CERTAIN VEHICLES, THE WIRING HARNESS FOR THE AIR BAG OCCUPANT DETECTION SYSTEM IN THE FRONT PASSENGER SEAT MAY HAVE BEEN PINCHED DURING PRODUCTION. PINCHING OF THE WIRING HARNESS BETWEEN THE FLOOR CROSSMEMBER AND THE SEAT MOUNTING BRACKET COULD RESULT IN A…
ON CERTAIN MOTORCYCLES, THE FRONT FAIRING SUB-HARNESS (SECTION OF THE WIRING HARNESS) TRANSFERS THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHTS, FRONT TURN SIGNALS, INSTRUMENT PANEL, AND VARIOUS RELAYS TO THE MAIN WIRING HARNESS VIA AN 18-PIN CONNECTOR. UNDER…
2003–2007 BMW K 1200 S, 2004–2007 BMW K 1200 R, 2005–2007 BMW K 1200 GT, 2005–2007 BMW K1200 R Sport
ON CERTAIN MOTORCYCLES, FREQUENT SHORT TRIPS PARTICULARLY DURING COLD TEMPERATURES, CAN CAUSE WATER TO ACCUMULATE IN THE OIL TANK, AND WHEN THE ENGINE IS RUNNING, ESCAPING WATER VAPOR CAN CONDENSE ON THE OIL TANK AIR BLEED VALVE. IN FREEZING TEMPERATURES,…
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THE CAP OF THE BRAKE FLUID RESERVOIR HAS BEEN DESIGNED IN ORDERTO RECOGNIZE A LOW FLUID LEVEL OF THE HYDRAULIC…
ON CERTAIN COMPRESSED NATURAL GAS (CNG) VEHICLES, IN THE EVENT OF A SEVERE INTERIOR FIRE IN THE AREA OF THE REAR SEAT, THE CNG TANK MAY BE HEATED UNEVENLY, PREVENTING THE PRESSURE RELIEF DEVICE FROM VENTING THE CONTENTS OF THE TANK AS DESIGNED.
2007–2008 Volvo VT, 2007–2008 Volvo Vhd, 2007–2008 Volvo Vnl, 2007–2008 Volvo Vnm
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND…
2007 Chevrolet Equinox, 2007 Pontiac Torrent
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." AN INCORRECT PRIMER MAY HAVE BEEN USED WHEN INSTALLING THE WINDSHIELD. THE SAME PRIMER MAY HAVE ALSO BEEN APPLIED TO THE LIFTGATE…
SOME SPORT UTILITY VEHICLES MAY HAVE FUEL TANKS THAT CONTAIN AN INTERNAL BREATHER PIPE THAT WAS NOT MADE TO SPECIFICATION. THIS COULD RESULT IN EXCESSIVE SWELLING AND CRACKING OF A GROMMET AND SUBSEQUENT DETACHMENT OF THE BREATHER PIPE FROM A CONNECTOR TUBE.…
2007 Dodge Sprinter 2500, 2007 Dodge Sprinter 3500, 2008 Fleetwood Icon, 2008 Fleetwood Pulse and 2 more
ON CERTAIN UTILITY VANS, THE CRANKSHAFT SENSOR IN CERTAIN DIESEL ENGINES COULD FAIL DUE TO SEPARATION OF BOND WIRES FROM THE LEAD FRAME IN THE SENSOR. THIS RESULTS IN AN INTERRUPTION IN THE ELECTRICAL CONNECTION IN THE CHIP HOUSING OF THE SENSOR.
2006 Kawasaki VN900B6F, 2006 Kawasaki VN900B6FL, 2006 Kawasaki VN900D6F, 2006 Kawasaki VN900D6FL
CERTAIN MOTORCYCLES MAY STALL UNDER DECELERATION DUE TO AN IMPROPER SETTING OF THE ENGINE CONTROL UNIT (ECU).
CERTAIN VEHICLES FAIL TO COMPLY WITH SOME OF THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE REAR OUTBOARD SEAT BELTS DO NOT COMPLY WITH THE LAP-BELT LOCKABILITY REQUIREMENT WHICH ENABLES THE LAP BELT…
ON CERTAIN PASSENGER VEHICLES, THE NO. 4 LEFT SIDE ENGINE MOUNT BOLT MAY LOOSEN IF A SUDDEN RAPID ACCELERATION IS REPEATEDLY PERFORMED.
CERTAIN PICKUP TRUCKS EQUIPPED WITH 34 GALLON FUEL TANKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL TANK MAY BECOME DAMAGED DURING CERTAIN CRASH CONDITIONS, WHICH COULD ALLOW FUEL…
2008 Freightliner Century St, 2008 Freightliner Columbia, 2008 Freightliner Coronado
ON CERTAIN TRUCKS, THE WIPER MOTOR GROUND WIRE WAS OMITTED IN A NEW HARNESS DESIGN. THE WIPER MOTOR MAY NOT OPERATE OR MAY FUNCTION INTERMITTENTLY.
2005–2006 Freightliner Fb-65, 2005–2006 Freightliner Fs-65
ON CERTAIN SCHOOL BUS AND MOTOR HOME CHASSIS, IMPROPER PINCH BOLT INSTALLATION MAY RESULT IN DECOUPLING OF THE STEERING SHAFT AND A LOSS OF STEERING.
2004–2008 Triumph Rocket III, 2004–2008 Triumph Rocket Iii Classic, 2004–2008 Triumph Rocket Iii Classic Tourin
ON CERTAIN MOTORCYCLES, WHEN THE ENGINE IS RETURNING TO IDLE IT MAY STALL.
CERTAIN TYC HALOGEN TYPE HEADLAMP ASSEMBLIES P/N 20-6644-00 SOLD AS AFTERMARKET EQUIPMENT FOR 2005-2006 NISSAN ALTIMA PASSENGER VEHICLES. THE PHOTOMETRIC WERE MISALIGNED WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS,…
2001–2006 Dodge Sprinter 2500, 2001–2006 Freightliner Sprinter 2500
ON CERTAIN TRUCKS EQUIPPED WITH REAR AIR CONDITIONING SYSTEM, THE INTERIOR LAMP IS EQUIPPED WITH AN 18W LAMP AND A SCATTERING LENS. IN EXTREMELY HOT AND HUMID CONDITIONS, THE COMBINATION OF HEAT AND HUMIDITY, AND THE HEAT FROM THE LAMP DUE TO EXTREME LONG…
2003 Kawasaki VN1600-A1, 2003 Kawasaki VN1600-A1L
ON CERTAIN MOTORCYCLES, THE FUEL TANK IS MOUNTED TO THE CHASSIS BY MEANS OF TABS THAT ARE SPOT WELDED TO THE TANK, THEN BRAISED/WELDED AROUND A PORTION OF THEIR CIRCUMFERENCE.
2007–2008 Freightliner Argosy, 2007–2008 Freightliner Business Class M2, 2007–2008 Freightliner Century St, 2007–2008 Freightliner Classic and 4 more
ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE…
2004–2008 Triumph Tiger 1050, 2005–2008 Triumph Sprint St 1050
ON CERTAIN MOTORCYCLES EQUIPPED WITH AN OPTIONAL ACCESSORY LUGGAGE RACK, UNDERSIZED WASHERS WERE USED WHICH PREVENTS THE SLIDING CARRIAGE FROM MOVING AS INTENDED.
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE DRIVER'S SIDE THIRD ROW SEAT BELT UPPER ANCHOR BRACKET MAY BE CRACKED.
2004–2006 Nissan Armada, 2004–2006 Nissan Frontier, 2004–2006 Nissan Pathfinder, 2004–2006 Nissan Titan and 1 more
CERTAIN HOPKINS AFTERMARKET TRAILER BRAKE CONTROL CONNECTION HARNESSES SOLD FOR USE ON CERTAIN MODELS OF NISSAN VEHICLES WHICH ARE LISTED ABOVE. THE INTERNAL PART NUMBERS WITHIN HOPKINS ARE: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025,…
2003–2007 Dodge Ram 2500, 2003–2007 Dodge Ram 3500
CERTAIN LKI ENTERPRISES, INC., BRAND NAME SUPERLIFT SUSPENSION, PITMAN ARMS SOLD AS REPLACEMENT EQUIPMENT FOR 2003-2007 DODGE RAM 2500 AND 3500 4X4 LIGHT TRUCKS. DUE TO INADEQUATE HEAT TREATMENT DURING PRODUCTION, THE AFFECTED PITMAN ARMS MAY DEVELOP CRACKS…
CERTAIN 4X4 TRUCKS WITH DIESEL ENGINES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, CERTAIN 4X4 TRUCKS WITH DIESEL ENGINES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE…
1996–1998 Buick Skylark, 1996–1998 Chevrolet Cavalier, 1996–1998 Oldsmobile Achieva, 1996–1998 Pontiac Grand AM and 1 more
CERTAIN DELPHI AFTERMARKET FUEL PUMP MODULES / MODULE RESERVOIR ASSEMBLIES (MRA) THAT WERE SOLD FOR USE ON THE ABOVE LISTED VEHICLES. DURING PRODUCTION THE MRAS VENT AND FUEL RETURN TUBES WERE REVERSED. THIS CONDITION CAN RESULT IN THE VEHICLE NOT RUNNING…
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE OWNER'S MANUAL IS MISSING THE TIRE PRESSURE MONITORING SYSTEM (TPMS) WRITTEN INSTRUCTIONS.
2007–2008 Forest River Flagstaff, 2007–2008 Forest River Rockwood
ON CERTAIN FOLDING CAMPING TRAILERS (FCT) EQUIPPED WITH A POWER WINCH UNIT, MODEL P55000, BUILT BY CAREFREE OF COLORADO, AN INCORRECT MATERIAL WAS USED IN THE MANUFACTURE OF THE CABLE SHAFTS ON SOME OF THESE POWER WINCH UNITS. UNDER CERTAIN CIRCUMSTANCES…
ON CERTAIN VEHICLES, STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED THAT A SMALL STATURE ADULT DRIVER NOT WEARING A SEAT BELT AND INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, THE DEPLOYMENT OF THE DRIVER…
2004–2007 Scion Xa, 2004–2007 Scion Xb
CERTAIN ROSTRA CRUISE CONTROLS, P/NOS. 00012-X0486-01, 00015-X0486-01, 00012-X0486-21, 00016-79910, 00016-79910-01, AND 250-1755, INSTALLED AS ORIGINAL EQUIPMENT ON MY 2006-2007 GULF STATES TOYOTA AND SOUTHEAST TOYOTA SCION VEHICLES AND ALSO SOLD AS…
CERTAIN MOTORCYCLES WERE BUILT WITH A CONDITION WHEREBY THE PANT LEG OF SOME RIDERS CAN HAVE DIRECT CONTACT WITH THE EXHAUST PIPE.
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM…
ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA, DUE TO THE COMBINATION OF FUEL QUALITY AND CLIMATE CONDITIONS, THE FUEL PUMP MAY, IN CERTAIN CASES, EXPERIENCE A REDUCED FUNCTIONALITY. THE MOST COMMON…
2007–2008 Fleetwood Arcadia, 2007–2008 Fleetwood Avalon, 2007–2008 Fleetwood Bayside, 2007–2008 Fleetwood Niagara and 7 more
ON CERTAIN RECREATIONAL VEHICLES, THE POWER LIFT ROOF SYSTEM, WHICH CONSISTS OF A POWER LIFT MOTOR AND CURRENT LIMITER CONTROLLER, GENERATES EXCESSIVE AMOUNTS OF IMPACT TORQUE IF THE POWER LIFT IS OPERATED WITH THE 30A POWER CORD PLUGGED INTO A 110V AC POWER…
2008 Volvo VT, 2008 Volvo Vnl, 2008 Volvo Vnm
ON CERTAIN TRUCKS, THE BOLTS THAT ATTACH THE STEERING GEAR TO THE FRAME MAY NOT HAVE BEEN TIGHTENED TO THE SPECIFIED TORQUE.
CERTAIN MOTOR HOME CHASSIS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATION BALLS TO ESCAPE FROM THE RECIRCULATION BALL CIRCUIT RESULTING IN A LOSS…
2007 Chevrolet C7500, 2007 Chevrolet C8500, 2007 Chevrolet Kodiak, 2007 Chevrolet T-Series and 8 more
ON CERTAIN MEDIUM DUTY CONVENTIONAL AND TILT CAB TRUCKS EQUIPPED WITH 7.8L DIESEL ENGINES AND AIR BRAKES, THE AIR COMPRESSOR MAY NOT BUILD ENOUGH AIR PRESSURE TO SUPPORT THE AIR BRAKE SYSTEM.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH OPTIONAL ACCESSORY ALL WEATHER FLOOR MATS, THERE IS INSUFFICIENT CLEARANCE BETWEEN THE FLOOR MAT AND ACCELERATOR PEDAL.
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE WHEEL INFORMATION LABEL LOCATED ON THE REAR DRIVER'S SIDE DOOR…
2007–2008 Fleetwood American Eagle, 2007–2008 Fleetwood American Tradition, 2007–2008 Fleetwood Revolution Le
ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE,…
1998–2007 Chrysler Town and Country, 1998–2007 Dodge Caravan, 1998–2007 Dodge Grand Caravan, 2002–2008 Dodge Ram 1500 and 10 more
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF…
IN CERTAIN VEHICLES, TWO SOFTWARE ERRORS HAVE BEEN FOUND IN THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CONTROL UNIT SOFTWARE. THIS MAY RESULT IN A LATE DEPLOYMENT OF THE INFLATABLE CURTAIN (IC) AND SIDE IMPACT PROTECTION SYSTEM (SIPS) AIR BAGS IN CERTAIN SIDE…
ON CERTAIN MOTOR HOMES, THE EXTERIOR SLIDEOUT STORAGE DRAWER CAN INADVERTENTLY SLIDE OUT DURING NORMAL HIGHWAY OPERATION.
ON CERTAIN MOTORCYCLES, THE ELECTRONIC CONTROL UNIT (ECU) IGNITION TIMING AND IDLE MIXTURE WERE IMPROPERLY SET DURING PRODUCTION CAUSING THE ENGINE SPEED TO DROP AND STALL THE ENGINE WHEN THE TEMPERATURE OF THE COOLING SYSTEM EXCEEDED 180F.
ON CERTAIN TWO WHEEL DRIVE TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE FRONT DRIVESHAFT YOKE MAY BREAK UNDER CERTAIN DRIVING CONDITIONS.
2008 Ford Explorer, 2008 Ford Explorer Sport Trac, 2008 Mercury Mountaineer
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY…
2008 Pontiac Solstice, 2008 Saturn Sky
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." AND STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THESE VEHICLES MAY HAVE ONE TO FOUR INBOARD SEAT STUD FASTENERS THAT DO…
DURING PRODUCTION, A SELECT NUMBER OF VEHICLES UNDERWENT AN OFFLINE INSPECTION AT THE ASSEMBLY PLANT WHERE A BOLT IN THE FRONT SUSPENSION ASSEMBLY WAS REMOVED. ON SOME OF THESE VEHICLES, IT IS POSSIBLE THAT THIS BOLT MAY NOT HAVE BEEN TIGHTENED TO…
2006–2007 Scion Xa, 2006–2007 Scion Xb
CERTAIN ROSTRA PRECISION CONTROLS' SPEED CONTROLS MAY HAVE A FAULTY MODULE. THESE CONTROLS WERE INSTALLED BY GULF STATES TOYOTA (GST) DEALERS OR AT THEIR VEHICLE PROCESSING CENTER ON CERTAIN PASSENGER VEHICLES. WHEN THE SPEED CONTROL "ON/OFF" SWITCH IS…
2007–2008 Freightliner Business Class M2, 2007–2008 Freightliner Columbia, 2007–2008 Freightliner FLD120 Military, 2007–2008 Freightliner FLD120SD
ON CERTAIN TRUCKS EQUIPPED WITH TUFTRAC REAR SUSPENSIONS, THE CENTER CASTING BRACKETS MAY BE OUT OF SPECIFICATION. AN OUT OF SQUARE CASTING MAY HAVE UNACCEPTABLE STRESS IN THE BRACKET WHEN IT IS INSTALLED AND MAY CAUSE IT TO CRACK IN SERVICE.
ON CERTAIN VEHICLES WITH ALL WHEEL DRIVE, THE FUEL TANK STRAPS WERE IMPROPERLY MANUFACTURED AND COULD SEPARATE. THIS CAN CAUSE THE FUEL TANK TO LOOSEN AND LEAK FUEL.
ON CERTAIN SPORT UTILITY VEHICLES, THE ANTILOCK BRAKE SYSTEM/VEHICLE DYNAMIC CONTROL (ABS/VDC) ACTUATOR IS DESIGNED WITH ONE BALL IN THE VALVE SECTION. SOME ABS/VDC ACTUATORS WERE MANUFACTURED WITH MORE THAN ONE BALL IN THE VALVE.
ON CERTAIN FUNERAL COACHES (MARKETED UNDER THE BRAND NAMES OF SUPERIOR, SAYERS AND SCOVILLE, EUREKA, AND MILLER-METEOR), THE FUEL FILLER NECK ASSEMBLY COULD LEAK FUEL.
2008 Ford F-250, 2008 Ford F-350, 2008 Ford F-450 Sd, 2008 Ford F-550 Sd
ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, INSUFFICIENT CLEARANCE OF THE BATTERY POSITIVE (B+) WIRE TO THE RIGHT HAND SPLASH SHIELD BOLT MAY RESULT IN THE BATTERY B+ WIRE CONTACTING THE SPLASH SHIELD BOLT.
2004–2007 Ford E-350 Cutaway, 2004–2007 Ford E-350 Van, 2004–2007 Ford E-450 Cutaway
ON CERTAIN AMBULANCES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE…
2007 Keystone Big Sky, 2007 Keystone Challenger, 2007 Keystone Everest, 2007 Keystone Montana and 2 more
CERTAIN FIFTH WHEEL TRAILERS BUILT WITH 16" STEEL WHEELS MAY LEAK AT THE VALVE STEM DURING INFLATION OR WHEN CHECKING THE AIR PRESSURE DUE TO IMPROPER SEATING OF THE VALVE STEM. SOME MODELS HAVE ALUMINUM WHEELS WITH A STEEL SPARE AND ONLY THE SPARE IS…
2003–2007 Chevrolet Kodiak, 2003–2007 GMC Topkick, 2005–2006 Isuzu Hxr
ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING…
2008 Keystone Freedom Lite, 2007 Keystone Passport
ON CERTAIN TRAVEL TRAILERS, THE LP SUPPLY HOSE FOR THE OUTSIDE RANGE IS CONNECTED TOO CLOSE TO THE RANGE. IN CERTAIN WINDY CONDITIONS, THE HEAT FROM THE RANGE BURNER MAY CAUSE THE HOSE TO MELT.
2008 Volvo VT, 2008 Volvo Vhd, 2008 Volvo Vnl, 2008 Volvo Vnm
ON CERTAIN TRUCKS, THE HOOD RESTRAINT CYLINDER DOES NOT CONTAIN ENOUGH DAMPENING TO ADEQUATELY RESTRAIN THE HOOD.
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." AN INCORRECT PRIMER MAY HAVE BEEN USED WHEN INSTALLING THE WINDSHIELD.
ON CERTAIN MOTORCYCLES, THE LICENSE NUMBER PLATE HOLDER SUPPORT BRACKET POSTS CAN CRACK.
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 317-1131L-AS, 317-1131R-AS, 317-1131L-US, AND 317-1131R-US, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION A SLIGHT DISTORTION OF THE BEZEL CHANGED THE…
2006–2007 Ducati Sport Classic
ON CERTAIN MOTORCYCLES, THE FASTENERS FROM THE FUEL LINE TO THE FUEL FILLER WERE NOT TIGHTENED PROPERLY. THE FUEL PUMP HOSE INSIDE THE FUEL TANK MAY SEPARATE FROM THE FUEL FILTER. THIS CONDITION WILL STOP THE ENGINE FROM RUNNING.
2007–2008 Chrysler Sebring, 2008 Dodge Avenger
ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT TRACK POSITION SENSORS UTILIZED FOR THE AIR BAG SYSTEM MAY NOT FUNCTION PROPERLY.
2007 BMW G650X Challenge, 2007 BMW G650X Country, 2007 BMW G650X Moto
ON CERTAIN MOTORCYCLES, THE FUEL PUMP WIRING SET HAS NOT BEEN MANUFACTURED ACCORDING TO SPECIFICATION. THE CONTACTS IN THE PLUG FOR THE FUEL PUMP CAN BREAK.
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF PART 567, 'CERTIFICATION.' INCORRECT CERTIFICATION LABELS WERE APPLIED TO THESE VEHICLES.
1991–2003 Pontiac Grand Prix, 1991–2001 Chevrolet Lumina, 1995–2005 Chevrolet Monte Carlo, 1996–2005 Buick Century and 23 more
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN…
2004–2006 Ford Freestar Conversion
ON CERTAIN MINI VAN CONVERSIONS, THE BRAKE LINES MAY HAVE BEEN ROUTED INCORRECTLY. THE BRAKE LINES CAN MAKE CONTACT AND CHAFE ON THE STABILIZER BAR.
2008 Ford F-650 Sd, 2008 Ford F-750 Sd
ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR C7 OR C9 DIESEL ENGINES, A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND MAY CAUSE THE TURBOCHARGER TO FAIL AND CAUSE LOSS OF THROTTLE CONTROL WITH WARNING.
2006–2007 Scion Xa, 2006–2007 Scion Xb
CERTAIN ROSTRA PRECISION CONTROLS' SPEED CONTROLS MAY HAVE A FAULTY MODULE. THESE CONTROLS WERE INSTALLED BY SOUTHEAST TOYOTA DEALERS OR AT THEIR VEHICLE PROCESSING CENTER ON CERTAIN PASSENGER VEHICLES. WHEN THE SPEED CONTROL "ON/OFF" SWITCH IS PRESSED ONCE…
2001–2007 Chevrolet 2500HD, 2001–2007 Chevrolet 3500HD
ON CERTAIN VEHICLES EQUIPPED WITH SERIES 0307, HR0307A, HR0307B, HR1000A OR HR1500HB HY--RAIL GUIDE WHEEL EQUIPMENT, THESE STEERING STOPS MAY NOT BE CORRECTLY INSTALLED.
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR…
2007–2008 Volvo VT, 2007–2008 Volvo Vhd, 2007–2008 Volvo Vnl, 2007–2008 Volvo Vnm
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.
CERTAIN AFTERMARKET BMW BIKE CARRIERS, P/N 82110393954, SOLD FOR USE ON MY 2005 BMW X3 AND X5 VEHICLES. A PINCH BOLT EXISTS BETWEEN THE BIKE ARM BRACKET AND THE UPRIGHT ASSEMBLY OF THE HITCH STYLE BICYCLE RACK.
ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.
2007 Ford Crown Victoria, 2007 Ford Grand Marquis
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ANTILOCK BRAKE SYSTEMS (ABS) FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THE FRONT AND REAR RIGHT SIDE BRAKE LINES MAY BE REVERSED AT THE ABS…
2007 Harley-Davidson FXD, 2007 Harley-Davidson FXDC, 2007 Harley-Davidson Fxdb, 2007 Harley-Davidson Fxdl and 6 more
CERTAIN SPORTSTER AND DYNA MODEL MOTORCYCLES WERE BUILT WITH AN INCORRECT FRONT TIRE.
CERTAIN FIFTH WHEEL RECREATIONAL TRAILERS MAY HAVE INCORRECT WIRING TO THE WATER HEATER. IF THE WIRING IS INCORRECT, THE GAS VALVE ON THE WATER HEATER COULD OPEN AND ALLOW LIQUID PROPANE (LP) GAS INTO THE BURNER TUBE WHEN THE ELECTRIC SWITCH IS TURNED ON.
ON CERTAIN CAB/CHASSIS PICKUP TRUCKS EQUIPPED WITH AN OPTIONAL 23 GALLON FUEL TANK, THE FUEL TANK STRAPS WERE IMPROPERLY MANUFACTURED AND COULD SEPARATE. THIS CAN CAUSE THE FUEL TANK TO LOOSEN AND LEAK FUEL.
2008 Harley-Davidson FXD, 2008 Harley-Davidson FXDC, 2008 Harley-Davidson FXDWG, 2008 Harley-Davidson Fxdb and 1 more
ON CERTAIN MOTORCYCLES BUILT AND SHIPPED TO CALIFORNIA, THE CATALYTIC MUFFLER PROTECTIVE HEAT SHIELD WAS NOT INSTALLED. THIS CONDITION COULD ALLOW DIRECT CONTACT WITH THIS MUFFLER AND CAUSE INJURY.
2007 Freightliner Business Class M2, 2007 Freightliner S2
CERTAIN MY 2007 THOMAS BUILT C2 SAF-T-LINER SCHOOL BUSES AND FREIGHTLINER BUSINESS CLASS M2, FCCC B2, AND S2 BUS CHASSIS MANUFACTURED BETWEEN JULY 3 AND NOVEMBER 3, 2006.
ON CERTAIN MOTORCYCLES, DURING LONG PERIODS OF RIDING AT SUSTAINED HIGH ENGINE RPM, VIBRATION WITHIN THE BRAKE FLUID RESERVOIR CAN CAUSE THE BRAKE FLUID TO FOAM. THIS COULD ALLOW AIR TO ENTER THE FRONT BRAKE SYSTEM WHICH COULD LEAD TO A LOSS OF FRONT BRAKING…
ON CERTAIN PASSENGER VEHICLES, THERE IS A PRESENCE OF AN ABNORMAL QUANTITY OF AIR IN THE HYDRAULIC CIRCUIT OF THE FRONT BRAKE. ALSO SOME VEHICLES MAY HAVE ONE OR TWO BRAKE FLUID RESERVOIR CAPS THAT ARE SEALED AND THIS COULD CREATE A VACUUM WHICH COULD LEAD TO…
2007 Dodge Sprinter 2500, 2007 Dodge Sprinter 3500, 2007 Freightliner Sprinter 2500, 2007 Freightliner Sprinter 3500
ON CERTAIN TRUCKS, THE SCREW BOLTS OF THE FUEL TANK FASTENING STRAPS MAY NOT HAVE BEEN TIGHTENED CORRECTLY. AFTER NORMAL PRODUCTION PROCESS, THE VEHICLES ARE DISASSEMBED FOR SHIPMENT TO THE US AND THE BOLTS MAY NOT HAVE BEEN CORRECTLY TIGHTENED WHEN…
2005–2008 Freightliner Century St, 2005–2008 Freightliner Classic Xl, 2005–2008 Freightliner Columbia, 2005–2008 Freightliner Coronado
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE BALL SOCKET ASSEMBLY AT THE INNER END OF THE DRIVER SIDE TIE ROD MAY BE DAMAGED IN A SHARP TURN. EXCESSIVE TIE ROD ANGLES MAY LOOSEN THE TIE ROD IN THE BALL SOCKET OR DAMAGE THE THREADED TIE ROD…
2007 Chevrolet Equinox, 2007 Pontiac Torrent
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." IN THESE VEHICLES, THE RIGHT FRONT PASSENGER SEAT IS BUILT WITH A PASSENGER SENSING SYSTEM. WHEN TESTED WITH A…
ON CERTAIN MOTORCYCLES, THE CLAMPING BLOCKS AND THE TOP FORK BRIDGE WERE NOT MANUFACTURED ACCORDING TO SPECIFICATIONS. CONSEQUENTLY, THE HANDLEBARS MIGHT NOT BE HELD SECURELY IN POSITION.
2005–2008 Freightliner Century St, 2005–2008 Freightliner Classic Xl, 2005–2008 Freightliner Columbia, 2005–2008 Freightliner Coronado
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE TIE ROD ARMS MAY HAVE BEEN INCORRECTLY INSTALLED. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.
2007 Dodge Caliber, 2007 Jeep Compass 4X4, 2007 Jeep Patriot 4X4
CERTAIN PASSENGER VEHICLES EQUIPPED WITH REAR DISC BRAKES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 135, "LIGHT VEHICLE BRAKE SYSTEMS." THE LENGTH OF THE REAR WHEEL HUB MOUNTING BOLTS MAY PREVENT ACTUATION OF THE…
ON CERTAIN VEHICLES, THE HOLE IN THE SHEETMETAL FRONT BULKHEAD THAT SERVES AS THE BASE AND PIVOT POINT FOR THE HOOD SUPPORT ROD WAS NOT PUNCHED TO SPECIFICATION. THE HOOD SUPPORT ROD MAY FAIL TO HOLD THE HOOD IN POSITION DUE TO INSUFFICIENT STRENGTH.
ON CERTAIN MOTORCYCLES, THE BATTERY CAN MOVE SIDE TO SIDE INSIDE THE FUEL TANK MOUNTING COMPARTMENT. THIS MOVEMENT COULD RESULT IN MAIN WIRING HARNESS DAMAGE AT THE BATTERY TERMINAL. THIS CONDITION COULD CAUSE AN ELECTRICAL SHORT CONSEQUENTLY STOPPING THE…
2005–2007 Chevrolet C4500, 2005–2007 Chevrolet C5500, 2005–2007 GMC C4500, 2005–2007 GMC C5500
CERTAIN LINK ULTRARIDE REAR AIR SUSPENSION SYSTEMS, MODEL 8M000070, SOLD FOR INSTALLATION AS AFTERMARKET EQUIPMENT ON GM CHASSIS MODELS 4500 AND 5500, AMBULANCES AND SHUTTLE BUSES. THE AXLE SIDE LATERAL CONTROL BRACKET OF THE SUSPENSION HAS CRACKED IN SOME…
2008 Hummer H2, 2008 Hummer H2 Sut
ON CERTAIN TRUCKS, THE WIRES IN THE ABS WHEEL SPEED SENSOR FRONT OR REAR HARNESS MAY BE REVERSED.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE RIGHT FRONT PASSENGER SEATS IN THESE VEHICLES ARE BUILT WITH A PASSENGER AIR BAG SENSING SYSTEM. WHEN TESTED WITH…
2007 MINI Cooper Convertible, 2007 MINI Cooper S Convertible
CERTAIN CONVERTIBLE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, 'TIRE SELECTION AND RIMS.' THE STANDARD REQUIRES THAT THE TIRE SIZE AND CORRESPONDING TIRE PRESSURE BE INDICATED ON THE LABEL AND THE LABEL DOES…
ON CERTAIN FIFTH WHEEL TRAILERS, WHEN PRESSURE IS APPLIED TO THE TOWEL BAR ON THE GLASS SHOWER DOOR, THE EDGE OF THE BAR MAY CONTACT THE GLASS.
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NO 335-1120L-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION THE LAMP HOUSING SHAPE DEFORMED DISTORTING THE ASSEMBLY ANGLE OF THE REFLECTOR AND INFLUENCED…
2006–2007 BMW F 650 GS, 2006–2007 BMW F650GS Dakar
ON CERTAIN MOTORCYCLES, THE WELD BETWEEN THE SIDE STAND AND THE FRAME BOTTOM SECTION WAS NOT POSITIONED PROPERLY. THE LOAD-BEARING CAPABILITY OF THE SIDE STAND IS AFFECTED. AS A RESULT, THE SIDE STAND COULD FAIL.
ON CERTAIN FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH AN ELECTRIC BED LIFT OPTION, A WASHER MAY HAVE BEEN OMITTED DURING PRODUCTION.
1998–2006 Ford F450 Classic Traveler, 1998–2006 Ford F550 Classic Traveler
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH REYCO GRANNING MODEL 345P AIR RIDE SUSPENSIONS, THE BRACKET SUPPORTING THE HORIZONTAL TRACK ROD AT THE FRAME ATTACHMENT CAN BECOME LOOSE AND EVENTUALLY CRACK AND BREAK.
ON CERTAIN PASSENGER VEHICLES, THE BRAKE SERVO VACUUM SUPPLY HOSE MAY HAVE BEEN MIS-ROUTED DURING ASSEMBLY. THIS CONDITION MAY BRING THE PIPE TOO CLOSE TO THE EXHAUST GAS RECIRCULATION (EGR) VALVE AND ATTACHMENTS ON THE EXHAUST MANIFOLD.
2008 Forest River Salem, 2008 Forest River Wildwood
CERTAIN TRAVEL TRAILERS FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE LABEL LOCATED ON THE LOWER ROADSIDE FRONT OF THE UNIT CONTAINS AN IMPROPER LISTING OF THE TIRE AND RIM.
2008 Fleetwood Jamboree, 2008 Fleetwood Tioga
ON CERTAIN MOTOR HOMES, THE SPARE WHEEL,WHEN INSTALLED ON THE FRONT AXLE, MAY CONTACT THE FRONT BRAKE CALIPER MOUNTING BRACKETS AND THE DRIVER MAY EXPERIENCE A GRINDING/SCRAPING NOISE IN THE FRONT WITH THE SPARE WHEEL INSTALLED.
Vehicle counts are the manufacturer's estimates in its report to NHTSA. Only makes covered by this site are counted, and a recall is counted in the year it was filed.