Biggest recalls
225 recalls filed with NHTSA in 2006, covering about 11,698,283 vehicles. The 200 largest are listed.
1994–2002 Ford F-250, 1994–2002 Ford F-350, 1994–2002 Ford F-450 Sd, 1994–2002 Ford F-550 Sd and 9 more
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
2006–2007 Honda CN250, 2006 Acura MDX, 2006 Acura RL, 2006 Acura RSX and 40 more
ON CERTAIN PASSENGER VEHICLES AND MOTORCYCLES, THE OWNER'S MANUALS CONTAIN INCORRECT CONTACT INFORMATION FOR THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S (NHTSA) VEHICLE SAFETY HOTLINE.
ON CERTAIN TRUCKS, THE CONSTANT TENSION FRONT LOWER BALL JOINTS MAY EXPERIENCE CONTAMINATION. IF THE VEHICLE IS OPERATED FOR AN EXTENDED PERIOD WITH THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE WEAR AND LOOSENESS.
1999–2000 Chevrolet Silverado, 1999–2000 GMC Sierra
CERTAIN PICKUP TRUCKS HAVE GALVANIZED-BRAIDED-STEEL TAILGATE SUPPORT CABLES USED TO SUPPORT THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION. OVER TIME THESE CABLES CAN CORRODE AND FRACTURE WHEN LOADS ARE APPLIED TO THEM.
1998–2002 Volkswagen Beetle, 1999–2002 Volkswagen Jetta
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
2004–2006 Chevrolet Colorado, 2004–2006 GMC Canyon, 2006 Isuzu i-280, 2006 Isuzu i-350
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME…
2004–2005 Lexus RX330, 2004–2005 Toyota Highlander, 2006 Lexus Rx Hybrid, 2006 Toyota Highlander Hybrid
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH…
2003–2004 Nissan Altima, 2003–2004 Nissan Sentra
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L ENGINE, THE CRANK ANGLE SENSOR IS AFFECTED BY TEMPERATURE VARIATIONS. UNDER CERTAIN DRIVING CONDITIONS, THESE VARIATIONS IN TEMPERATURE CAN BE LARGE ENOUGH TO CAUSE A BRIEF INTERRUPTION IN THE SIGNAL OUTPUT…
1990–2006 Honda Accord, 1992–2006 Honda Civic, 1997–2006 Ford F-150, 1992–1998 BMW 3 Series and 20 more
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS,…
2005–2006 Chrysler Town and Country, 2005–2006 Dodge Caravan, 2005–2006 Dodge Durango, 2005–2006 Dodge Grand Caravan
ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.
1999–2000 Chrysler Cirrus, 1999–2000 Dodge Stratus, 1999–2000 Plymouth Breeze
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT AGE AND DEVELOP A LEAK.
2005–2006 Ford F-150, 2006 Lincoln Mark LT
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR…
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO THE LOCATION OF THE FORWARD EDGE OF THE FUEL TANK, IN THE EVENT THAT A VEHICLE FRONT TIRE RUNS OVER A SMALL, SHARP OBJECT IN THE ROAD, CATCHES IT AND PROPELS IT TOWARDS THE REAR OF THE VEHICLE, IT MAY STRIKE AND…
ON SOME SPORT UTILITY VEHICLES, IN CERTAIN HIGH SPEED FRONTAL CRASHES, THE WEBBING OF A REAR OUTBOARD SEAT BELT MAY CONTACT THE REAR SEAT BACK HINGE WHERE IT CAN BE CUT BY THE SHARP EDGE OF THE METAL PORTION OF THE HINGE.
ON CERTAIN SPORT UTILITY VEHICLES, THE PLASTIC BLADES OF THE ELECTRIC MOTOR DRIVEN COOLING FAN MAY SEPARATE AND PENETRATE THE SHROUD.
THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.
1999–2002 Volvo C70, 1999–2002 Volvo C70 Convertible, 1999–2002 Volvo V70, 1999–2001 Volvo S80 and 4 more
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE FRONT PASSENGER SEAT BELT MAY NOT BE ABLE TO TIGHTEN SECURELY ON CERTAIN MODEL CHILD SEATS.
ON CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION. THE PASSENGER AIR BAG MAY DEPLOY WITH EXCESSIVE FORCE WHEN CERTAIN MODEL REAR FACING CHILD SEATS ARE INSTALLED IN THE…
2005–2006 Ford Freestyle, 2005 Ford Five Hundred, 2005 Mercury Montego
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW…
2005 Ford Escape, 2005 Mercury Mariner
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM…
ON CERTAIN SPORT UTILITY VEHICLES, DURING STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED IF A SMALL STATURED ADULT DRIVER, NOT WEARING A SEAT BELT, IS INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH,…
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE AND THE POWER TRAIN CONTROL MODULE (PCM) SOFTWARE MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN OPERATING CONDITIONS.
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS…
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HEATED SEATS, THE FRONT PASSENGER SEAT ELECTRIC HEATER ELEMENT COULD OVERHEAT.
2003–2006 Infiniti FX35, 2003–2006 Infiniti FX45
DURING A CANADIAN COMPLIANCE TEST, CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' THE HEADLAMP ASSEMBLIES DO NOT MEET THE HEADLAMP…
2003–2006 Infiniti FX35, 2003–2006 Infiniti FX45
DURING A CANADIAN COMPLIANCE TEST, CERTAIN SPORT UTILITY VEHICLES FAILED TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' A REAR COMBINATION LAMP ASSEMBLY DID NOT MEET THE…
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT…
1990–2005 Chevrolet Astro, 1990–2005 Chevrolet Suburban, 1991–2005 GMC Safari, 1992–2005 GMC Yukon and 88 more
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR…
1992–2006 Honda Prelude, 1990–2002 Honda Accord, 1990–2001 Acura Integra, 1992–2003 BMW E36 and 18 more
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108,…
2006 Nissan Altima, 2006 Nissan Sentra
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5L ENGINES MAY EXPERIENCE EXCESSIVE ENGINE OIL CONSUMPTION AS A RESULT OF IMPROPER PERFORMANCE OF THE PISTON RINGS.
2006 Dodge Dakota, 2006 Dodge Durango, 2006 Mitsubishi Raider
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, A STATIC ELECTRICITY SPARK BETWEEN THE OPERATOR AND THE VEHICLE CAN CAUSE THE TURN SIGNAL, HEADLAMPS OR WINDSHIELD WIPERS TO MALFUNCTION WITHOUT WARNING.
2003 Audi A4, 2003 Audi A6, 2003 Volkswagen Passat
ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO…
1998–2004 Audi A6, 2001–2005 Audi allroad
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE…
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." DURING AN INSPECTION OF SOME VEHICLES AT THE ASSEMBLY PLANT, IT WAS FOUND THAT THE STEERING WHEEL WAS LOCKED WITH THE…
1990–2005 Chevrolet Astro, 1990–2003 Honda Civic, 1990–2003 Jeep Wrangler, 1992–2005 Mitsubishi Eclipse and 71 more
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE…
2005–2006 Freightliner Argosy, 2005–2006 Freightliner Century Class, 2005–2006 Freightliner Columbia
ON CERTAIN TRUCKS, THE PROTECTIVE COVER FOR THE CAB POWER DISTRIBUTION MODEL (PDM) MAY BE MISSING OR IMPROPERLY INSTALLED.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.0L ENGINE WITH 147 KW MAY HAVE A VACUUM LINE THAT MAY FRACTURE AND BECOME DISCONNECTED AT LOW AMBIENT TEMPERATURES.
1998–2006 Ford Crown Victoria, 1998–2006 Mercury Grand Marquis, 1999–2006 Jaguar S-Type, 1999–2005 Ford F-150 and 26 more
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE…
ON CERTAIN '6' GENERATION PASSENGER VEHICLES, THE WIPER MOTOR MAY FAIL DURING HEAVY RAIN DUE TO EXCESSIVE MOISTURE ENTERING THE WIPER MOTOR. IF THIS HAPPENS, THE WIPERS CAN BECOME INOPERATIVE.
2007 Chrysler 300, 2007 Chrysler Sebring, 2007 Dodge Caliber, 2007 Dodge Charger and 7 more
ON CERTAIN VEHICLES, THE ANTILOCK BRAKE SYSTEM (ABS) CONTROL MODULE SOFTWARE MAY CAUSE THE REAR BRAKES TO LOCK UP DURING CERTAIN BRAKING CONDITIONS.
2005–2006 Land Rover LR3, 2006 Land Rover Range Rover Sport
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION.' WHEN THE IGNITION IS SWITCHED OFF, AFTER A PERIOD OF TIME, IT IS POSSIBLE TO REMOVE THE IGNITION KEY WHEN THE TRANSMISSION SHIFT LEVER…
1994–2003 Dodge Ram 1500, 1994–2002 Dodge Ram 2500, 1997–2003 Dodge Dakota, 1997–2003 Dodge Durango
CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS…
2006 Chrysler 300, 2006 Dodge Charger, 2006 Dodge Magnum
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.7 LITER ENGINES AND MK25E BRAKING SYSTEMS MAY EXHIBIT INADEQUATE CLEARANCE BETWEEN THE REAR BRAKE TUBES AND THE EXHAUST GAS RECIRCULATION TUBE. CONTACT BETWEEN THE BRAKE TUBES AND EXHAUST GAS RECIRCULATION TUBE OVER…
ON CERTAIN PASSENGER VEHICLES, THE AIR BAG WARNING LABEL INSTALLED ON THE SUNVISORS HAD LOST ADHESION TO THE SUNVISORS AND HAD DISTORTED OR SEPARATED FROM THE SUN VISORS.
ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.
2002–2005 Yamaha XV1700, 2003–2005 Yamaha FJR1300, 2004–2005 Yamaha FZS600, 2004–2005 Yamaha YZF-R1
ON CERTAIN MOTORCYCLES, AN IMPROPERLY DESIGNED THROTTLE POSITION SENSOR COULD CAUSE AN INTERMITTENTLY UNSTABLE IDLE WHEN THE ENGINE IS AT IDLING SPEED WHEN THE MOTORCYCLE IS STOPPED OR DURING LOW-SPEED OPERATIONS. THE ENGINE COULD STALL AS A RESULT.
2006 Dodge Dakota, 2006 Dodge Ram 1500, 2006 Dodge Ram 2500, 2006 Dodge Ram 3500 and 1 more
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), THE ABS ELECTRONIC CONTROL UNIT (ECU) MAY CAUSE A LOSS OF FRONT TO REAR BRAKE BALANCE, AND THE REAR BRAKES COULD LOCK UP PREMATURELY DURING CERTAIN BRAKING CONDITIONS.
1995–2000 Chrysler Cirrus, 1995–2000 Chrysler Sebring, 1995–2000 Dodge Stratus, 1995–2000 Plymouth Breeze and 1 more
CERTAIN TIGAS FUEL PUMP MODULES MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006, SOLD UNDER VARIOUS BRAND NAMES AND P/NOS. THESE FUEL PUMP MODULES ARE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN…
2004–2006 Chevrolet Silverado, 2004–2006 GMC Sierra, 2004–2006 GMC Yukon XL, 2005–2006 Chevrolet Avalanche 1500 and 5 more
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
1998–2006 Suzuki VL1500, 2005–2006 Suzuki VL1500T
ON CERTAIN MOTORCYCLES, STRESS AROUND THE RIGHT FRONT FUEL TANK MOUNTING POINT CAN CAUSE HAIRLINE FATIGUE CRACKS TO FORM. THIS CAN RESULT IN A FUEL LEAK.
2000–2005 Mercedes-Benz CL-Class, 2000–2005 Mercedes-Benz S-Class
ON CERTAIN VEHICLES, THE INSTRUMENT CLUSTER IS EXPERIENCING ELECTRICAL MALFUNCTIONS. THE INSTRUMENT CLUSTER CONTAINS GAUGES AND INDICATORS THAT MUST BE ILLUMINATED WHENEVER THE VEHICLE IS IN OPERATION.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.
2001–2002 Toyota Echo, 2001–2002 Toyota Prius
ON CERTAIN PASSENGER VEHICLES, DUE TO IMPROPER MOLDING OF THE RESIN BODY OF THE CRANKSHAFT POSITION SENOR INSTALLED ON THE ENGINE BLOCK, ENGINE OIL MAY PENETRATE THE SEAL AND ENTER THE SENSOR WIRING CONNECTOR. THE WIRE HARNESS CONNECTOR MAY NOT BE…
2003–2006 Volvo Vhd, 2003–2006 Volvo Vnl, 2003–2006 Volvo Vnm
ON CERTAIN TRUCKS EQUIPPED WITH D12D ENGINES, THE EXHAUST GAS RECIRCULATION (EGR) COOLER INLET PIPES OR THE PIPES THAT CONNECT THE EGR VALVES TO THE COOLER MAY CRACK OR BREAK.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." WHEN USED WITH CERTAIN CHILD SEATS, THE AUTOMATIC LOCKING RETRACTOR (ALR) FUNCTION IN THE REAR OUTBOARD SEATBELT…
CERTAIN ZF TRADING NORTH AMERICA AFTERMARKET WHEEL BEARING KITS, LEMFOERDER P/N 1402301, SOLD FOR INSTALLATION ON 1992-2001 MERCEDES BENZ SL500 (R129) VEHICLES AFTER APRIL 1, 2005. THE CALIPER MOUNTING BOLTS USED IN THE WHEEL BEARING KIT MAY BE DEFECTIVE,…
ON CERTAIN 2005-2006 CHEVROLET CORVETTES EQUIPPED WITH PAINTED ROOFS, THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE.
ON CERTAIN VEHICLES, THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS MAY INADVERTENTLY DEPLOY. THIS CONDITION CAN OCCUR IF THE DOOR FOR THAT SIDE OF THE VEHICLE IS CLOSED WITH A HIGH RATE OF FORCE WHILE THE VEHICLE'S IGNITION IS IN THE "ON" POSITION OR…
ON CERTAIN PASSENGER VEHICLES, IF THE FRONT SEAT BELT RETRACTORS (BOTH DRIVER AND FRONT PASSENGER) BECOME LOCKED, THEY MAY NOT RELEASE DUE TO A COMPONENT OF THE EMERGENCY LOCKING SYSTEM. IF THE SEAT BELT IS LOCKED IN THIS CONDITION, THE OCCUPANT MAY NOT BE…
ON CERTAIN PASSENGER VEHICLES, AS A RESULT OF A PROBLEM IN THE PRODUCTION PROCESS OF THE IGNITION SWITCH, THE ANCHOR POINT OF THE SPRING MAY CRACK. THIS COULD POTENTIALLY CAUSE THE RETURN SPRING FORCE TO BE INSUFFICIENT FOR RETURNING THE IGNITION KEY TO THE…
1990–2004 Ford Mustang, 1990–2002 Toyota 4Runner, 1990–2001 Acura Integra, 1990–2001 Honda Accord and 43 more
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO…
1996–1999 Chrysler Sebring, 1995–1997 Chrysler Cirrus, 1998–2000 Dodge Caravan, 1998–2000 Dodge Grand Caravan and 4 more
CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED…
ON CERTAIN SPORT UTILITY VEHICLES, THE INTEGRATED RETRACTOR BRACKET EDGE ON THE THIRD ROW SEAT MAY CONTACT THE SEAT BELT DURING CERTAIN OPERATING CONDITIONS CAUSING DAMAGE TO THE BELT WEBBING.
CERTAIN VEHICLES FAIL TO COMPLY WITH THE "VERTICAL GRADIENT" AND "HEADLAMP PHOTOMETRIC VALUES" REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.'
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOON ROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM…
2005 Cadillac SRX, 2005 Cadillac STS
CERTAIN VEHICLES HAVE A LEFT OR RIGHT REAR SUSPENSION TOE LINK THAT COULD SEPARATE BECAUSE OF AN INCORRECT WELD.
1999–2001 Yamaha Midnight Star, 1999–2001 Yamaha Road Star, 1999–2001 Yamaha Road Star Mm Limited, 1999–2001 Yamaha Road Star Silverado
ON CERTAIN MOTORCYCLES, CERTAIN TRANSMISSION COMPONENTS MAY NOT MEET YAMAHA QUALITY-CONTROL STANDARDS, WHICH COULD ALLOW ABNORMAL WEAR THAT EVENTUALLY RESULTS IN A BROKEN RETAINING CIRCLIP.
ON CERTAIN MOTORCYCLES, A BATTERY CADDY BOLT MAY LOOSEN UNDER NORMAL RIDING CONDITIONS. SHOULD THIS OCCUR, THE BOLT CAN BACK OUT WHICH ALLOWS THE BATTERY TO SHIFT POSITION AND THEN HOLD THE BATTERY IN A POSITION WHICH MAY ALLOW THE BATTERY TERMINALS TO…
2005–2006 Volvo S60, 2005–2006 Volvo S80, 2005–2006 Volvo V70
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.
1997–2003 Ford F-150, 1997–2002 Ford Expedition, 1997–1999 Ford F-250
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE…
ON CERTAIN MUSTANG COBRA PASSENGER VEHICLES, THE REAR SURFACE OF THE ACCELERATOR PEDAL MAY COME INTO CONTACT WITH FLOOR CARPETING DURING HEAVY THROTTLE APPLICATION. THE UNIQUE SURFACE PROFILE OF THE ACCELERATOR PEDAL MAY CATCH IN THE CUTOUT ON THE FLOOR…
2007 Harley-Davidson XL1200C, 2007 Harley-Davidson XL1200L, 2007 Harley-Davidson XL1200R, 2007 Harley-Davidson XL50 and 4 more
ON CERTAIN MOTORCYCLES, AS A RESULT OF A GREATER BODY THICKNESS THAN USED IN PREVIOUS MODEL YEARS, THE VOLTAGE REGULATOR MAY CONTACT THE FRONT FENDER UNDER CERTAIN CONDITIONS. IN SOME CASES THIS CONTACT MAY ALLOW THE FRONT FENDER TO CATCH ON THE TOP SIDE OF…
ON CERTAIN SPORT UTILITY VEHICLES, THE OWNER'S MANUAL DOES NOT CONTAIN THE REQUIRED HIGHER ROLLOVER RISK WARNING INFORMATION.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF…
2005–2006 Cadillac CTS, 2005–2006 Cadillac STS
CERTAIN VEHICLES EQUIPPED WITH V6 ENGINES MAY HAVE A CONDITION WHERE FUEL IS NO LONGER SUPPLIED TO THE ENGINE. THIS CONDITION OCCURS WITHOUT THE ILLUMINATION OF THE FUEL LEVEL LOW INDICATOR LIGHT OR THE WARNING CHIME.
CERTAIN GUIDE REPLACEMENT HEADLAMPS, P/NOS. 16526133 AND 16526134, MANUFACTURED FROM JANUARY 1 TO JULY 11, 2006, SOLD FOR USE ON MY 1999-2002 CHEVROLET SILVERADO PICKUP TRUCKS. THE HEADLAMP FAIL TO COMPLY WITH THE PHOTOMETRY REQUIREMENT OF FEDERAL MOTOR…
2004–2006 Volvo S40, 2004–2006 Volvo V50
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.
CERTAIN EAGLE EYES REPLACEMENT HEADLAMPS, MODEL NOS. GM159-B001L AND GM159-B001R, SOLD FOR USE ON 1999-2002 CHEVROLET SILVERADO MODEL VEHICLES. THE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108,…
ON CERTAIN TWO WHEEL DRIVE SPORT UTILITY VEHICLES EQUIPPED WITH 3.7 LITER ENGINES, THE LEFT OXYGEN SENSOR WIRING HARNESS MAY CONTACT THE EXHAUST PIPE.
ON CERTAIN SPORT UTILITY VEHICLES, THE INFLATOR CONNECTOR FOR THE DRIVER'S AIR BAG MAY HAVE BEEN INCORRECTLY ASSEMBLED.
1997–2004 Ford F-150, 1997–2004 Ford F-250
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR…
ON CERTAIN SPORT UTILITY VEHICLES, A FITTING FOR VAPOR RECIRCULATION, WHICH IS WELDED ON THE FUEL TANK, MAY COME OFF THE FUEL TANK BECAUSE INCORRECT MATERIAL WAS USED.
SOME PASSENGER VEHICLES MAY HAVE FUEL TANKS IN WHICH THE FUEL DELIVERY MODULE (FDM), JET PUMP MODULE (JPM), AND/OR CLUSTER VALVE (CV) SEALS ARE NOT PROPERLY RETAINED IN THE FUEL TANK. THIS MAY RESULT IN ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL), OR…
2004–2006 BMW R 1200 GS, 2005–2006 BMW K 1200 S, 2006 BMW K 1200 R, 2006 BMW R 1200 RT and 1 more
ON CERTAIN MOTORCYCLES, UNDER RAPID, REPEATED, AND UNUSUALLY HARSH BRAKING, LOSS OF ABS CAPABILITY COULD TEMPORARILY OCCUR.
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THE BRAKE FLUID RESERVOIR CAP IS MISSING PART OF THE REQUIRED BRAKE FLUID WARNING.
ON CERTAIN PASSENGER VEHICLES, THE REAR CALIPER BRAKE HOSES MAY BE OUT OF POSITION. AN IMPROPERLY POSITIONED REAR CALIPER BRAKE HOSE MAY CONTACT REAR SUSPENSION COMPONENTS AND OVER TIME BREACH THE INTEGRITY OF THE HOSE.
ON CERTAIN MOTORCYCLES, THE AIR FILTER MOUNTING SCREWS MAY COME LOOSE AND FALL OUT.
2006 Buick Lucerne, 2006 Cadillac DTS
ON CERTAIN VEHICLES EQUIPPED WITH A V8 ENGINE,THE POWER STEERING HOSE CONNECTORS MAY HAVE BEEN INADEQUATELY CRIMPED WHICH COULD RESULT IN A FLUID LEAK.
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 332-1182L-AS AND 332-1182R-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 1999-2000 CHEVROLET SILVERADOS. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY…
2005–2006 Ford Freestar, 2005–2006 Mercury Monterey
ON CERTAIN VANS EQUIPPED WITH THE POWER LIFTGATE OPTION, THE POWER LIFTGATE MOTOR AUTOMATICALLY DISENGAGES AFTER THE LIFTGATE IS POWERED OPEN.
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
2006 BMW 5 Series, 2006 BMW 6 Series, 2006 BMW 7 Series
ON CERTAIN PASSENGER VEHICLES, THE LOWER RUBBER MOUNT OF THE REAR SHOCK ABSORBERS MAY NOT HAVE BEEN MANUFACTURED TO SPECIFICATIONS AND MAY NOT ADHERE CORRECTLY TO ITS HOUSING WITHIN THE SHOCK ABSORBER.
2006 Land Rover Range Rover Sport
ON CERTAIN VEHICLES FITTED WITH 9J-19 INCH DIAMETER WHEELS, DURING CERTAIN VEHICLE MANEUVERS WHEN THE STEERING SYSTEM IS ON FULL LEFT LOCK AND THE SUSPENSION IS MOVING TOWARDS FULL COMPRESSION, THE LEFT FRONT BRAKE HOSE AND/OR THE ABS WHEEL SPEED SENSOR LEAD…
2007 Harley-Davidson FXDWG, 2006 Harley-Davidson Fxdwgi
ON CERTAIN MOTORCYCLES, THE INTERNALLY WIRED HANDLEBARS HAVE A POTENTIAL TO CRACK AT THE HOLE WHERE THE WIRES EXIT THE HANDLEBARS BETWEEN THE HANDLEBAR CLAMPS.
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW…
2004–2005 Harley-Davidson Sportster 1200R, 2004–2005 Harley-Davidson Sportster 883R
ON CERTAIN MOTORCYCLES, THE FRONT MASTER BRAKE CYLINDER ASSEMBLY HAD BEEN BUILT WITH INADEQUATE LUBRICATION ON THE SECONDARY CUP. THIS COULD CAUSE THE SLIDING RESISTANCE OF THE PISTON TO BE EXCESSIVE, WHICH IN TURN COULD CAUSE THE RETURN OF THE PISTON TO BE…
CERTAIN PASSENGER VEHICLES EQUIPPED WITH AN 'INTELLIGENT KEY' FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." DURING AN INSPECTION OF SOME VEHICLES AT THE ASSEMBLY PLANT, IT WAS FOUND THAT THE STEERING…
2000–2006 Keystone Tail-Gator, 2002–2006 Keystone Hideout, 2004–2006 Keystone Raptor, 2006 Keystone Nrg
ON CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH A 9 VOLT BATTERY OPERATED CARBON MONOXIDE (CO) DETECTOR, IF THE BATTERY IN THE DETECTOR GOES DEAD OR IS REMOVED, THE DETECTOR WILL NOT FUNCTION AND THEREFORE CAN NOT WARN THE OCCUPANTS IF CO REACHES A HARMFUL…
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH EITHER BRIDGESTONE DUELER OR DUNLOP GRANDTREK TIRES, THERE IS A POSSIBILITY THAT THE INNER BEAD OF THE TIRE MAY HAVE BEEN DAMAGED. IF THE BEAD IS DAMAGED, A BULGE MAY DEVELOP ON THE SIDEWALL OF THE TIRE AND AIR MAY…
2004–2006 BMW R 1200 GS, 2005–2006 BMW R 1200 RT, 2005–2006 BMW R 1200 ST
ON CERTAIN MOTORCYCLES, IF CERTAIN PROCEDURES ARE PERFORMED THAT INVOLVES REMOVAL OF THE FRONT LEFT BRAKE CALIPER, THE ABS SENSOR CABLE CAN BE ROUTED INCORRECTLY AND WHEN THE CALIPER IS REINSTALLED, THE SENSOR CABLE CAN COME INTO CONTACT AND RUB AGAINST THE…
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES, THE SEAT BACK MAY RECLINE UNTIL IT…
2004–2007 Fleetwood Bounder, 2004–2007 Fleetwood Pace Arrow, 2004–2007 Fleetwood Southwind, 2004–2007 Fleetwood Terra and 3 more
ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE…
1992–1995 Chevrolet Astro, 1992–1995 Chevrolet Blazer, 1992–1995 GMC Jimmy, 1992–1995 GMC S Series and 4 more
CERTAIN R&B, INC. CENTRAL MULTIPORT FUEL INJECTION (CMFI) FUEL RETURN LINES, MODELS HELP 55163, NAPA BALKAMP 700-3270, AND THE CONNECTION 2560001, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL RETURN LINE HAS A MECHANICAL BLEED…
ON CERTAIN PASSENGER VEHICLES, THE DAYLIGHT RUNNING LIGHTS (DRL), TURN SIGNAL, AND PARKING LAMPS USE THE SAME BULB. THE BULB MAY BECOME DAMAGED FROM VIBRATION WITHIN A LOOSE FITTING SOCKET OR AIR ENTERING THE BULB DUE TO AN INADEQUATE SEAL. BOTH OF THESE…
ON CERTAIN PASSENGER VEHICLES, DURING PRODUCTION OF THE DRIVER'S FRONTAL AIR BAG, THE AIR BAG MAY NOT UNFOLD PROPERLY IN THE EVENT OF A CRASH AND THEREFORE MAY NOT INFLATE AS DESIGNED.
1996–2005 Dodge Caravan, 1992–2001 Dodge Viper, 1995–2004 Jeep Grand Cherokee, 1996–2005 Chrysler Town and Country and 12 more
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST,…
1997–2004 Jeep Grand Cherokee, 1997–2004 Jeep Wrangler, 1997–2001 Jeep Cherokee, 2000–2003 Dodge Dakota
CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET…
2003–2004 Fleetwood Bounder, 2003–2004 Fleetwood Fiesta, 2003–2004 Fleetwood Flair, 2003–2004 Fleetwood Pace Arrow and 3 more
CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101 "CONTROLS AND DISPLAYS" AND NO. 105 "HYDRAULIC AND ELECTRIC BRAKE…
ON CERTAIN PASSENGER VEHICLES, THE STARTER WIRING HARNESS MAY BE ROUTED INCORRECTLY. THIS ROUTING COULD LEAD TO CHAFING OF THE PROTECTIVE SLEEVE COVERING THE STARTER WIRING HARNESS AT THE ENGINE MOUNT COVER.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 6 SPEED MANUAL TRANSMISSIONS, THE HYDRAULIC CLUTCH MASTER CYLINDER LINKAGE ROD MAY BREAK. THIS MAY NOT ALLOW DISENGAGEMENT OF THE CLUTCH WHEN THE PEDAL IS DEPRESSED.
2001–2006 GMC Sierra 1500, 2001–2006 GMC Sierra 2500
CERTAIN FEDERAL-MOGUL NATIONAL AND CARQUEST AFTERMARKET HUB ASSEMBLIES, P/N 515058, SOLD FOR USE ON 2001-2006 GENERAL MOTORS 1500 AND 2500 4WD TRUCKS. ON THE SUBJECT HUB ASSEMBLIES, THE ABS SENSOR CORD DEPARTS FROM THE HUB ASSEMBLY AT A 90 DEGREE ANGLE. AS A…
2006 Kawasaki ZX1000D6F, 2006 Kawasaki ZX1000D6F/L
ON CERTAIN MOTORCYCLES, THE BOLT THAT ATTACHES THE STEERING DAMPER BODY TO THE FRAME BRACKET MAY NOT HAVE BEEN TIGHTENED SUFFICIENTLY DURING VEHICLE ASSEMBLY.
2007 Chrysler Aspen, 2007 Dodge Durango
ON CERTAIN VEHICLES, THE RIGHT FRONT STEERING KNUCKLE MAY HAVE BEEN IMPROPERLY MANUFACTURED. BECAUSE OF A BROKEN COOLING LINE, PARTS CAST IN TOOL CAVITY #63 ON JULY 18 AND JULY 19, 2006, MAY HAVE A COLD SHUT CONDITION AND COULD FRACTURE.
SOME PASSENGER VEHICLES MAY HAVE FUEL TANKS IN WHICH THE FUEL DELIVERY MODULE (FDM), JET PUMP MODULE (JPM, AND/OR CLUSTER VALVE (CV) SEALS ARE NOT PROPERLY RETAINED IN THE FUEL TANK. THIS MAY RESULT IN ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL), OR…
ON CERTAIN FRONT WHEEL DRIVE HYBRID VEHICLES, THE INTERMEDIATE SHAFT MAY NOT HAVE BEEN PROPERLY HEAT TREATED AND MAY FRACTURE WHILE THE VEHICLE IS BEING DRIVEN.
ON CERTAIN VEHICLES EQUIPPED WITH AUTOMATIC TEMPERATURE CONTROL (ATC) ONLY, THE SOFTWARE PROGRAMMED INTO THE HEATING VENTILATION AND AIR CONDITIONING (HVAC) MODULE MAY CAUSE THE WINDSHIELD DEFROSTING AND DEFOGGING FUNCTIONS TO BECOME INOPERATIVE.
ON CERTAIN VEHICLES WHERE A WEAK BATTERY EXISTS, IT IS POSSIBLE THAT A LOW VOLTAGE CONDITION COULD CAUSE THE AIR BAG CONTROL UNIT TO IMPROPERLY SET A FAULT CODE. IF THIS OCCURS, THE PASSENGER SIDE FRONTAL AIR BAG WILL BECOME DEACTIVATED. HOWEVER, BOTH THE AIR…
2004–2006 Freightliner Classic, 2004–2006 Freightliner Classic Xl, 2004–2006 Freightliner Columbia, 2004–2006 Freightliner FLD120SD
ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE VARIABLE VALVE ACTUATION OIL LINE MAY WEAR AGAINST THE SHARP EDGE OF THE CYLINDER HEAD IF NOT POSITIONED CORRECTLY.
2007 Freightliner Argosy, 2007 Freightliner Business Class M2, 2007 Freightliner Cargo, 2007 Freightliner Century Class S/t and 5 more
CERTAIN HEAVY TRUCKS, SHUTTLE BUSES, AND SCHOOL BUSES EQUIPPED WITH BENDIX MODULATED SPRING BRAKE VALVES. A DEFECT IN THE MODULATED SPRING BRAKE VALVE CASTING MAY CAUSE AN INTERMITTENT DELAY IN THE APPLICATION OF THE PARK BRAKE.
2005–2006 Porsche 911 Carrera S, 2005–2006 Porsche 911 Carrera S Cabriolet
CERTAIN 2 DOOR COUPE AND CONVERTIBLE VEHICLES MAY HAVE BEEN SUPPLIED WITH A TAILPIPE THAT MAY HAVE BEEN PRODUCED WITH A WELD LOCATED BETWEEN THE FASTENING CLIP AND EXHAUST PIPE, WHICH IS INADEQUATELY DIMENSIONED. ALSO INCLUDED ARE CERTAIN ACCESSORY EXHAUST…
CERTAIN PASSENGER VEHICLES EQUIPPED WITH B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.
ON CERTAIN LOW CAB FORWARD CHASSIS TRUCKS, THE UNSEALED INJECTION PRESSURE REGULATOR CONNECTOR IS EXPOSED TO THE OUTSIDE ENVIRONMENT DUE TO ITS LOCATION ON THE BACK OF THE ENGINE AND THE ENGINE'S LOCATION IN THE VEHICLE. THE CONNECTOR HAS A HEAT INSULATION…
2003–2006 Suzuki SV1000S, 2003–2006 Suzuki SV650, 2003–2006 Suzuki SV650S, 2003 Suzuki SV1000
ON CERTAIN CALIFORNIA-SPECIFICATION MODEL MOTORCYCLES, REPEATED STRESS FROM VIBRATION CAN CAUSE A CRACK TO FORM IN THE AREA WHERE THE LIQUID/VAPOR SEPARATOR BRACKET IS WELDED INSIDE THE FUEL TANK. THIS CAN ALLOW FUEL LEAKAGE TO OCCUR.
2007 Chrysler 300, 2007 Dodge Charger, 2007 Dodge Dakota, 2007 Dodge Durango and 4 more
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE SOFTWARE PROGRAMMED INTO THE POWERTRAIN CONTROL MODULE CAN CAUSE A MOMENTARY LOCK UP OF THE DRIVE WHEELS IF THE VEHICLE IS TRAVELING OVER 40 MPH AND…
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE BRAKE PEDALS, THE STOP LAMP SWITCH WIRING HARNESS MAY BE OUT OF POSITION. AN IMPROPERLY POSITIONED STOP LAMP SWITCH WIRING HARNESS COULD MAKE CONTACT WITH THE U-JOINT ASSEMBLY OF THE STEERING COLUMN.…
ON CERTAIN SPORT UTILITY VEHICLES, THE MATERIAL USED TO MANUFACTURE THE FRONT DISC BRAKE CALIPERS MAY BE BRITTLE DUE TO IMPROPER METALLURGY.
ON CERTAIN PASSENGER VEHICLES, THE HOOD LATCH STRIKER MAY BREAK AND ALLOW THE HOOD TO OPEN WHILE DRIVING.
1990–2006 Honda Accord, 1992–2006 Honda Civic, 1994–2002 Ford Mustang, 1997–2006 Ford F-150 and 20 more
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108,…
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE ANCHOR BOLT FOR THE REAR, LEFT-HAND SIDE SEAT BELT BUCKLE DIRECTLY BEHIND THE DRIVER'S SEAT DOES NOT…
2007 Volvo VT, 2007 Volvo Vnl, 2007 Volvo Vnm
ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR RPL20 HIGH ANGLE INTERAXLE DRIVESHAFTS, AN IMPROPER SEATED OR MISSING SNAP RING CAN RESULT IN THE BEARING CUP TO SEPARATE FROM THE SLIP YOKE SUB-ASSEMBLY. THE UNIVERSAL JOINT CROSS COULD THEN CONTACT THE SLIP YOKE…
1993–2002 Chevrolet Camaro, 1998–2004 Chevrolet S10, 1997–2003 Dodge Dakota, 1991–1997 Isuzu Rodeo and 17 more
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108,…
2007 Freightliner MT55, 2007 Freightliner Mt-45
ON CERTAIN WALK-IN VANS, THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS. THE CRUISE CONTROL MAY NOT IMMEDIATELY DEACTIVATE WHEN THE SERVICE BRAKES ARE APPLIED.
2007 Cadillac Escalade Ext, 2006 Cadillac SRX, 2007 Chevrolet Avalanche 1500, 2007 Chevrolet Colorado and 3 more
CERTAIN SPORT UTILITY VEHICLES AND TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES HAVE AN INCOMPLETE TIRE RIM DESIGNATION ON THE CERTIFICATION/TIRE LABEL LOCATED ON THE…
ON CERTAIN SEDANS EQUIPPED WITH MOONROOFS, A REINFORCEMENT BAR WAS INCORRECTLY ASSEMBLED SO THAT THE BAR MAY CONTACT THE GLASS IN THE MOONROOF. WHEN CLOSING A DOOR OR UPON SEVERE ROAD IMPACT, IT IS POSSIBLE THAT THE MOONROOF GLASS MAY SHATTER.
ON CERTAIN PASSENGER VEHICLES, THE BOLT ATTACHING THE HORN ASSEMBLY TO THE STEERING WHEEL HUB MAY FAIL DURING A DRIVER SIDE FRONT AIR BAG DEPLOYMENT IN EXTREMELY LOW AMBIENT TEMPERATURE.
ON CERTAIN PASSENGER VEHICLES, DURING THE PRODUCTION PROCESS, THE THREADS IN THE NUT USED TO SECURE THE SEAT BELT BUCKLE IN A LIMITED NUMBER OF SECOND ROW SEATS MAY BE MISSING. THE ABSENCE OF THE SCREW THREADS RESULTS IN AN INCOMPLETE CONNECTION OF THE BUCKLE…
ON CERTAIN MOTORCYCLES, THE BOLTS HOLDING THE VEHICLE DOWN SENSOR MAY COME LOOSE AND ALLOW THE SENSOR TO FALL OUT OF ITS MOUNTING BRACKET.
2007 Volvo VT, 2007 Volvo Vhd, 2007 Volvo Vn
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH DANA STEERING SHAFTS, THERE IS A POTENTIAL THAT THE STEERING SHAFT PINCH BOLT HOLE MAY BE INCORRECTLY LOCATED. THE PINCH BOLT FITS INTO A GROOVE IN THE STEERING GEAR INPUT SHAFT TO ENSURE THAT THE STEERING…
2006 Chevrolet Impala (gmx 211)
CERTAIN VEHICLES EQUIPPED WITH A MANUAL PASSENGER SEAT ADJUSTER FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE LEFT FLOOR MOUNTING BRACKET MAY BE MISLOCATED.
ON CERTAIN MOTOR HOMES, THE TIE ROD SPECIFIED FOR THE AXLE ASSEMBLY IS TOO SHORT, POSSIBLY RESULTING IN INSUFFICIENT THREAD ENGAGEMENT.
2001–2005 Freightliner Coronado
ON CERTAIN TRUCKS EQUIPPED WITH VEHICLE IMPROVEMENT STEERING WHEELS, THE STEERING WHEELS MAY BE MANUFACTURED WITH INCORRECT LENGTH HUCK FASTENERS THAT ARE TOO SHORT TO ALLOW PROPER COLLAR ENGAGEMENT ON THE PIN. THE STEERING WHEEL WILL FEEL LOOSE ON THE HUB…
2006–2007 Triumph Sprint St 1050, 2006–2007 Triumph Sprint St Abs
ON CERTAIN MOTORCYCLES, THE REAR DRAG LINK-THROUGH BOLT MAY BEND AND, IF NOT REPLACED OR OVERLOADED, MAY FRACTURE CAUSING THE REAR TIRE TO CONTACT THE UNDERSIDE OF THE REAR MUDGUARD.
CERTAIN VEHICLES FAIL TO COMPLY WITH THE STOP LAMP AND REFLEX REFLECTOR REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
2007 Mitsubishi Eclipse, 2007 Mitsubishi Eclipse Spyder
ON CERTAIN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE KEY LOCK CABLE WAS IMPROPERLY MANUFACTURED AND MAY NOT ALLOW THE CABLE END TO LOCK INTO THE FLOOR SHIFTER MECHANISM. THIS CAN RESULT IN THE INTERLOCK SYSTEM TO BECOME INOPERATIVE AND ALLOW THE…
1990–2003 Honda Civic, 1990–2002 BMW E46, 1994–2000 Honda Accord, 1994–1999 Chevrolet Chevrolet Truck and 1 more
CERTAIN E SPEED RACING COMBINATION LAMPS SOLD AS REPLACEMENT EQUIPMENT FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.…
2003–2006 Ducati 749, 2003–2006 Ducati 999, 2004–2006 Yamaha YZF-R1, 2005–2006 Yamaha YZF-R6
CERTAIN CRG FRONT BRAKE LEVERS, MODEL RB-511 DESIGNED FOR USE ON 2004-2006 YAMAHA YZF-R1 MOTORCYCLES, AND 2005-2006 YAMAHA YZF-R6 MOTORCYCLES. MODEL RB-512 IS DESIGNED FOR USE ON 2003-2006 DUCATI 749 AND 999 MOTORCYCLES, AND ON 2004-2006 APRILIA MILLE R…
2007 Buick LaCrosse, 2007 Chevrolet Impala, 2007 Pontiac Grand Prix
ON CERTAIN VEHICLES, THE FUEL TANK IS MISSING THE ADHESIVE LAYER THAT BONDS THE BARRIER LAYER TO THE OUTER SHELL OF THE FUEL TANK.
2007 Mercedes-Benz M-Class, 2007 Mercedes-Benz R-Class
ON CERTAIN VEHICLES, THE ACCELERATOR PEDAL MIGHT NOT HAVE BEEN FULLY FASTENED TO ITS MOUNTING STUDS.
2007 Mitsubishi Eclipse, 2007 Mitsubishi Eclipse Spyder
ON CERTAIN PASSENGER VEHICLES, THE METAL FORMING PART OF THE FRONT CROSSMEMBER MAY HAVE BEEN IMPROPERLY STAMPED RESULTING IN THE METAL BECOMING THINNER IN THE CROSS-SECTION THAN SPECIFIED. THIS COULD, OVER TIME, RESULT IN BREAKAGE OF THE CROSSMEMBER.
2003–2006 Winnebago Chalet, 2003–2006 Winnebago Minnie, 2003–2006 Winnebago Minnie Winnie, 2003–2006 Winnebago Outlook
ON CERTAIN MOTOR HOMES EQUIPPED WITH FRONT OVERHEAD TELEVISIONS, INCORRECT FASTENERS WERE USED TO SECURE THE TELEVISION LOCATED IN THE FRONT OVERHEAD AREA OF THE MOTOR HOME.
1990–2003 Honda Accord, 1992–2003 Honda Civic, 1994–1998 Ford Mustang, 1992–1996 Honda Prelude and 7 more
CERTAIN POLI-AUTO COMBINATION HEADLAMP ASSEMBLIES, P/NOS. 11-728, 11-728D, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708P, 11-735, 11-725, 11-726, 11-716 (P&C), 11-721-1, 11-733, 11-729, 11-730, AND 11-732, SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN…
2006 Chevrolet Kodiak, 2006 Chevrolet T-Series, 2006 GMC T-Series, 2006 GMC Topkick and 4 more
CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." AN INTERNAL CONTROL AND CHECK VALVE WITHIN THE AIR BRAKE APPLICATION VALVE ASSEMBLY WAS CONFIGURED IMPROPERLY, PREVENTING AIR FROM…
2001–2006 Chevrolet Silverado 2500, 2001–2006 GMC Sierra 2500, 2003–2006 Hummer H2
CERTAIN FABTECH AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS71000 AND FTS71001, INSTALLED FOR USE ON CERTAIN 2001-2006 GM C/K 2500 PICK UP TRUCKS AND SPORT UTILITY VEHICLES. THE PIN LOCATED INSIDE THE PITMAN ARM CAN SHEAR OFF DUE TO A REVERSE BENDING…
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ALL WHEEL DRIVE AND A 3.6L V6 ENGINE, THE TORQUE MONITORING FUNCTIONS OF THE ELECTRONIC THROTTLE CONTROL (ETC) ARE NOT ENABLED. THESE FUNCTIONS CAN LIMIT ENGINE SPEED AND TORQUE IF UNUSUAL ENGINE CONTROL MODULE…
2006 Fleetwood Bounder, 2006 Fleetwood Bounder Diesel, 2006 Fleetwood Discovery, 2006 Fleetwood Excursion and 11 more
ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC ENTRY STEP BUILT WITH A CONTROL UNIT MANUFACTURED BY AMERICAN TECHNOLOGIES, MAY DEVELOP AN ELECTRICAL SHORT DURING COLD WEATHER, ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE.
1992–2003 Honda Civic, 1994–2002 Honda Accord, 1992–1998 BMW 3 Series, 1997–1999 Mitsubishi Eclipse
CERTAIN J & A AUTO ACCESSORIES COMBINATION HEADLAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.…
2006 Chevrolet C7500, 2006 Chevrolet C8500, 2006 Chevrolet Kodiak, 2006 Chevrolet T-Series and 5 more
CERTAIN MEDIUM DUTY TRUCKS EQUIPPED SR-7 BENDIX BRAKE VALVES, THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SET, CAUSING INTERNAL AIR LEAKAGE. IF THE CHECK VALVE DOES NOT PROPERLY SEAT, THE RESULTING LEAKAGE CAN CAUSE A DELAY IN THE APPLICATION OF…
2006–2007 Winnebago Adventurer, 2006–2007 Winnebago Sightseer, 2006–2007 Winnebago Voyage
CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE STEERING COULD BECOME LOOSE AT THE STEERING BOX DURING TIGHT STEERING MANEUVERS.
2005–2006 Fleetwood Bounder, 2005–2006 Fleetwood Flair, 2005–2006 Fleetwood Pace Arrow, 2005–2006 Fleetwood Southwind and 1 more
ON CERTAIN CLASS A MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.
2006–2007 Winnebago Aspect, 2007 Winnebago Access
ON CERTAIN MOTORHOMES,THE FLAME ON THE COOKING RANGE MAY BE FORCED DOWNWARD OVER THE BURNER OR FLAME OUTAGE MAY OCCUR WHEN THE COOKING RANGE AND FURNACE ARE OPERATED AT THE SAME TIME. THIS IS DUE TO THE POSSIBILITY OF A MISSING OR INCOMPLETE CABINET PANEL…
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 17-INCH WHEELS AND A 2.5L ENGINE FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE PRODUCED WITH A TIRE INFORMATION LABEL THAT LISTS AN…
ON CERTAIN TRUCKS, THE WHEEL SPACER MAY BECOME DISTORTED FROM HEAT WHICH POTENTIALLY COULD LEAD TO A LOSS OF CLAMP THAT MAY RESULT IN LOOSE WHEEL NUTS.
1990–2005 Honda Accord, 1990–2005 Honda Civic, 1990–2001 Acura Integra
CERTAIN EAGLE EYES AND SONAR HEADLIGHTS AND CORNER LIGHTS SOLD AS AFTERMARKET FOR USE ON 1988-2005 HONDA CIVIC, 1990-2005 HONDA ACCORD, AND 1990-2001 ACURA INTEGRA PASSENGER VEHICLES LISTED ABOVE. HEADLIGHTS AND CORNER LIGHTS THAT ARE NOT EQUIPPED WITH AMBER…
2005–2006 Buick LaCrosse, 2005–2006 Buick Rendezvous, 2005–2006 Chevrolet Trailblazer, 2005–2006 GMC Envoy and 8 more
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT…
ON CERTAIN MINIVANS EQUIPPED WITH ADJUSTABLE BRAKE PEDALS, THE STOP LAMP SWITCH WIRING HARNESS MAY BE OUT OF POSITION. AN IMPROPERLY POSITIONED STOP LAMP SWITCH WIRING HARNESS COULD MAKE CONTACT WITH THE U-JOINT ASSEMBLY OF THE STEERING COLUMN. REPEATED…
ON CERTAIN 2-DOOR PASSENGER VEHICLES, THE REAR WINDSHIELD OR REAR QUARTER GLASS PANELS DO NOT PROPERLY ADHERE TO THE BODY OF THE CAR DUE TO IMPROPER WINDOW OPENING PREPARATION.
2006 Nissan Altima, 2006 Nissan Maxima
ON CERTAIN VEHICLES, THE REAR SUBFRAME MAY HAVE BEEN MANUFACTURED INCORRECTLY, WHICH COULD RESULT IN A CRACK IN A BRACKET WHICH HOLDS PART OF THE REAR SUSPENSION.
1998–2005 Honda Accord, 1996–2003 Honda Civic, 2002–2004 Acura RSX, 1999–2001 Ford Mustang and 2 more
CERTAIN ALFAOTTO COMBINATION HEADLAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS,…
2007 BMW R 1200 S, 2006 BMW R1200 HP2
ON CERTAIN MOTORCYCLES, DURING ASSEMBLY, THE FINAL-DRIVE ASSEMBLY O-RING MAY NOT HAVE BEEN INSTALLED CORRECTLY. A LEAK MAY OCCUR AT THE LOCATION OF THIS O-RING WHICH IS NEAR THE REAR BRAKE DISC.
ON CERTAIN TRAILERS, THE WHEEL STUD CAN FAIL AND SEPARATES AT THE BASE OF THE THREAD. THIS REDUCES CLAMP FORCE ON THE WHEEL.
2006 Triumph Daytona 955I, 2006 Triumph Speed Triple, 2006 Triumph Sprint ST, 2006 Triumph Sprint St Abs
ON CERTAIN MOTORCYCLES, THE ANTI-ROTATION STOP BOLT ON THE REAR BRAKE CALIPER MAY SHEAR ALLOWING THE CALIPER TO CONTACT THE SWING ARM.
CERTAIN HONDA ACCESSORY TRAILER HITCHES, P/N 08L92-STK-200, MANUFACTURED BETWEEN JUNE 26 AND JULY 8, 2006, AND SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 2007 MODEL YEAR ACURA RDX VEHICLES. THE HITCHES MAY HAVE BEEN IMPROPERLY WELDED DURING INSTALLATION.
2006 Ducati ST3, 2006 Ducati ST3 Abs
ON CERTAIN MOTORCYCLES, THE FUEL SENDING UNIT WIRING CABLES INSTALLED DURING PRODUCTION COULD BE ROUTED INCORRECTLY POSSIBLY COMING IN CONTACT WITH THE EXHAUST PIPES.
ON CERTAIN PASSENGER VEHICLES, THE INNER BEZELS OF THE HEADLAMPS WERE NOT PROPERLY ASSEMBLED WHICH MAY CAUSE THE TURN SIGNAL LENSES TO BE IMPROPERLY POSITIONED.
2006 BMW R 1200 GS, 2006 BMW R 1200 RT, 2006 BMW R1200 HP2
ON CERTAIN MOTORCYCLES, THE CLUTCH COMPONENTS COULD BECOME LOOSE WHILE THE MOTORCYCLE IS BEING OPERATED.
2005–2007 Ford F-250, 2005–2007 Ford F-350
CERTAIN HARSCO WHEEL MODIFICATION GROUPS CONTAINING ACCURIDE STEEL RIMS, P/NOS. 203237 AND 203738; ACCURIDE ALUMINUM RIMS, P/N 203712; AND GKN STEEL RIMS, P/N 203688, SOLD AS MODIFICATION EQUIPMENT FOR CERTAIN 2005-2007 FORD F-250/F-350 4X4 PICKUP TRUCKS TO…
2005–2006 Mercedes-Benz SLR McLaren
ON CERTAIN PASSENGER VEHICLES, UNDER HARD OPERATING CONDITIONS, THE ENGINE COMPARTMENT TEMPERATURE CAN INCREASE TO A LEVEL WHICH EXCEEDS THE DESIGN PARAMETERS FOR THE ALTERNATOR TO NOT FUNCTION AND IT WILL BECOME DAMAGED.
CERTAIN FIFTH WHEEL TRAILERS FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE FEDERAL CERTIFICATION TAG WAS PRINTED WITH AN INCORRECT TIRE VALUE OF 80 PSI AND THE CORRECT TIRE PRESSURE VALUE IS 65 PSI.
2007 Fleetwood Orbit, 2007 Fleetwood Pegasus
CERTAIN TRAVEL TRAILERS MAY HAVE BEEN EQUIPPED WITH IMPROPERLY CONSTRUCTED SPARE TIRE SUPPORT BRACKETS THAT CAUSE THE SPARE TIRE TO HANG TOO LOW TO THE GROUND.
CERTAIN LIGHT TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." AN ARC WELD IS MISSING ON SOME RIGHT SIDE REAR DOOR UPPER LATCH ASSEMBLIES.
2007 Ford Crown Victoria, 2007 Mercury Grand Marquis
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING.' THE WINDSHIELD MAY NOT BE PROPERLY SECURED TO THE VEHICLE BODY.
2005 Ducati Monster 620, 2005 Ducati Monster 620 Dark
ON CERTAIN MOTORCYCLES, THE FUEL PUMP AND IGNITION RELAYS INSTALLED DURING PRODUCTION COULD BE DEFECTIVE. THIS CAN CAUSE THE INSTRUMENT PANEL TO STOP FUNCTIONING AND THE ENGINE TO STOP.
CERTAIN AFTERMARKET EIBACH BRANDED FRONT STRUTS ONLY, PART NO. 35101.8001, AND EIBACH BRANDED FRONT STRUTS AS SUSPENSION KITS, PART NOS. 35101.840, 35101.680, 35101.780, 35100.680, 35100.780, 4.10135.680, AND 4.10035.780, SOLD FOR USE ON 2005 THROUGH 2007…
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE WRONG OCCUPANT RESTRAINT CONTROLLER (ORC) WAS INSTALLED ON THESE VEHICLES.
CERTAIN TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 111, "REAR VIEW MIRRORS". THE RIGHT OUTSIDE REAR VIEW MIRROR GLASS HAS A CURVED (CONVEX) MIRROR GLASS INSTALLED INSTEAD OF FLAT GLASS. CURVED GLASS CREATES A WIDER…
CERTAIN CARGO VANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARDS NO. 110, "TIRE SELECTION AND RIMS" AND NO. 120. "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE CARGO VANS WERE SHIPPED WITHOUT A…
ON CERTAIN FIFTH WHEEL AND TRAVEL TRAILERS, THE AXLE SPRING SHACKLE NUTS MAY NOT HAVE BEEN PROPERLY TIGHTENED.
CERTAIN TRUCKS EQUIPPED WITH DUAL REAR WHEELS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT." THE TRUCKS MAY HAVE BEEN INADVERTENTLY MANUFACTURED WITHOUT THE ROOF…
1990–1992 Volkswagen Golf, 1990–1992 Volkswagen Jetta
CERTAIN HYDRAULIC BRAKE HOSES, P/N 171.611.107B, SOLD AS REPLACEMENT EQUIPMENT FOR 1975-1985 VOLKSWAGEN (VW) RABBIT; 1985-1992 VW GOLF; AND 1980-1992 VW JETTA PASSENGER VEHICLES. POSSIBLE BRAKE HOSE RUPTURE COULD OCCUR WHICH FAILS TO COMPLY WITH THE…
ON CERTAIN SPORT UTILITY VEHICLES, THE LEFT REAR SUSPENSION WATTS LINK MAY HAVE BEEN DAMAGED DURING VEHICLE ASSEMBLY AND COULD FAIL.
2007 Fleetwood Jamboree, 2007 Fleetwood Tioga
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE FEDERAL CERTIFICATION TAG FIGURES RELATED TO THE REAR TIRE PRESSURE TAG OF 60 PSI ARE INCORRECT. THE CORRECT REAR TIRE PRESSURE RATING IS 80 PSI.
1998–1999 Fleetwood American Dream, 1998–1999 Fleetwood American Eagle
ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH SPARTAN CHASSIS STEERING GEAR, THE STEERING GEAR SUPPORT BRACKET HAS THE POTENTIAL TO FAIL WHEN SUBJECT TO THE REPETITIVE FORCES OF STATIC STEERING CONDITIONS.
ON CERTAIN VEHICLES EQUIPPED WITH CURTAIN SIDE AIR BAGS (CSA), THE CSA TETHER STRAP LOCATED IN THE FRONT PILLARS MAY HAVE BEEN INCORRECTLY ROUTED DURING THE ASSEMBLY PROCESS.
ON CERTAIN FIFTH WHEEL TRAILERS, THE FURNACE AIR INTAKE WAS INCORRECTLY INSTALLED. THE AIR INTAKE MAY DRAW AIR FROM INSIDE THE UNIT (INSTEAD OF FRESH OUTSIDE AIR) WHICH CAN CAUSE IMPROPER GAS/AIR MIXTURE AND INEFFICIENT COMBUSTION. ALSO, IF THE TRANSITION…
CERTAIN AFTERMARKET ROUSH BRANDED FRONT STRUTS AS A STAND ALONE COMPONENT, PART NO. 401297, AND ROUSH BRANDED FRONT STRUTS AS A SUSPENSION KIT, PART NO. 401296, SOLD FOR USE ON 2005 AND 2006 FORD MUSTANG GT VEHICLES. THE FRONT ANTI ROLL BAR ATTACHMENT BRACKET…
2006 BMW R 1200 GS, 2006 BMW R1200 Gs Adventure
ON CERTAIN MOTORCYCLES, THE TIRE INFLATION VALVE HOLE IN THE RIM OF THE CROSS-SPOKE WHEEL WHICH IS EQUIPPED WITH THE OPTIONAL TIRE PRESSURE MONITORING SYSTEM (TPM) WAS INCORRECTLY MANUFACTURED. A LEAK MAY DEVELOP AT THIS LOCATION POSSIBLY CAUSING SUDDEN…
ON CERTAIN SPORT UTILITY VEHICLES, THE WALL THICKNESS OF THE RIGHT FORWARD BAFFLE OF THE FUEL TANK MAY BE BELOW SPECIFICATIONS.
Vehicle counts are the manufacturer's estimates in its report to NHTSA. Only makes covered by this site are counted, and a recall is counted in the year it was filed.