Biggest recalls
222 recalls filed with NHTSA in 2005, covering about 18,592,118 vehicles. The 200 largest are listed.
1994–2002 Ford F-150, 1997–2002 Ford Expedition, 1994–1999 Ford F-250, 1998–2002 Lincoln Navigator and 2 more
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
2003–2005 Cadillac Escalade, 2003–2005 Chevrolet Avalanche, 2003–2005 Chevrolet Silverado, 2003–2005 Chevrolet Suburban and 4 more
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS…
1999–2002 Chevrolet Silverado, 1999–2002 GMC Sierra, 2000–2002 Chevrolet Suburban, 2000–2002 Chevrolet Tahoe and 3 more
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT,…
1990–1995 Toyota 4Runner, 1990–1995 Toyota Pick-Up, 1993–1998 Toyota T100
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE STEERING WHEEL IS REPEATEDLY TURNED UNDER CERTAIN CONDITIONS WHERE HIGH STEERING EFFORT AND POWER ASSIST ARE REQUIRED, FOR INSTANCE, WHEN FULLY TURNING THE WHEEL WHILE THE VEHICLE IS STOPPED, A…
2001–2004 Toyota Tacoma, 2002–2004 Toyota Sequoia, 2002–2004 Toyota Tundra, 2001–2002 Toyota 4Runner
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND…
2000 Ford Expedition, 2000 Ford F-150, 2001 Ford Supercrew, 2000 Lincoln Navigator
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO,…
1997–2001 Honda Prelude, 1999–2002 Honda Accord, 1999–2000 Acura TL
ON CERTAIN PASSENGER VEHICLES, THE INTERLOCK OPERATION OF THE IGNITION SWITCH MAY NOT FUNCTION PROPERLY, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO PARK.
2003–2006 Chevrolet Express, 2003–2006 GMC Savana
ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
ON CERTAIN MINI VANS, IN THE MIDDLE ROW SEATING POSITION, THE SHOULDER PORTION OF THE SEAT BELT MAY BIND IN THE BEZEL TRIM PIECE. THE AFFECTED SEAT BELT BEZEL IS LOCATED ON THE SHOULDER PORTION OF THE SEAT IN THE RIGHT SIDE SEAT OF THE SEVEN PASSENGER MODELS…
2000–2001 Chevrolet Suburban, 2000–2001 GMC Yukon XL
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES WERE BUILT WITH FUEL MODULE RESERVOIR ASSEMBLIES THAT CONTAIN FUEL PUMP WIRES CONNECTORS MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.
2000–2002 Saturn LS, 2003 Saturn L200, 2004 Saturn L300
ON CERTAIN SEDANS AND WAGONS, THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.
2003–2004 Chevrolet Trailblazer, 2003–2004 GMC Envoy, 2003–2004 Isuzu Ascender, 2003–2004 Oldsmobile Bravada and 1 more
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN…
2005–2006 Chrysler 300, 2005–2006 Dodge Durango, 2005–2006 Dodge Magnum, 2005–2006 Jeep Liberty and 3 more
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO…
2003–2005 Dodge Ram 2500, 2003–2005 Dodge Ram 3500
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS, IN AN ATTEMPT TO EXIT THE VEHICLE QUICKLY WITHOUT SHUTTING OFF THE ENGINE AND REMOVING THE KEY, THE DRIVER MAY INADVERTENTLY LEAVE THE AUTOMATIC TRANSMISSION SHIFT CONTROL IN…
CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN…
2003–2005 Mercedes-Benz E-Class, 2003–2005 Mercedes-Benz SL-Class, 2006 Mercedes-Benz CLS-Class
ON CERTAIN VEHICLES, THE SENSOTRONIC BRAKE CONTROL (SBC) SYSTEM MAY PREMATURELY SHIFT TO THE HYDRAULIC BACK-UP FUNCTION MODE, DUE TO DETERIORATION OF THE WIRING HARNESS CONNECTION, OR DUE TO PREMATURE FAILURE OF THE HYDRAULIC PUMP.
2006 Ford E-150, 2006 Ford E-250, 2006 Ford E-350, 2006 Ford E-450 and 10 more
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
2003–2006 Infiniti FX35, 2003–2006 Infiniti FX45, 2003–2004 Infiniti G35, 2003–2004 Nissan 350Z
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE FUEL FILLER HOSE MAY CRACK AND RESULT IN FUEL LEAKAGE FROM THE HOSE WHILE REFUELING.
2004–2005 Ford E-350, 2004–2005 Ford E-450, 2004–2005 Ford Excursion, 2004–2005 Ford F-250 Sd and 3 more
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
1996–2005 Yamaha XV250, 1996–2005 Yamaha XVS11, 1996–2005 Yamaha XVS65
ON CERTAIN MOTORCYCLES, THE MOUNTING HARDWARE HOLDING THE PASSENGER SEAT TO THE FENDER COULD LOOSEN DUE TO THE PASSENGER'S WEIGHT SHIFTING ON THE SEAT.
2002–2005 Harley-Davidson Flstc, 2002–2005 Harley-Davidson Flstci, 2002–2005 Harley-Davidson Flstf, 2002–2005 Harley-Davidson Flstfi and 2 more
CERTAIN SOFTAIL MOTORCYCLES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, 'CERTIFICATION.' THE VIN/CERTIFICATION LABEL CONTAINS INCORRECT TIRE SIZE AND INFLATION PRESSURES FOR THE FRONT WHEEL. THE LABEL STATES THE TIRE SIZE IS MT90B21 AND THE INFLATION…
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE A MANUAL AIR BAG ON-OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE A CHILD…
2003–2005 Ford Crown Victoria, 2003–2005 Ford Cvpi
ON CERTAIN POLICE INTERCEPTORS (CVPI) AND COMMERCIAL HEAVY DUTY (TAXI) VEHICLES, AT EXTREMELY HIGH OPERATING TEMPERATURES, THE SOUND INSULATING PANEL, LOCATED UNDER THE VEHICLE POSITIONED BETWEEN THE EXHAUST SYSTEM AND THE UNDERBODY, COULD SAG AND POSSIBLY…
ON CERTAIN SPORT UTILITY VEHICLES, THERE IS A POSSIBILITY THAT A WIRE BREAKING INSIDE THE ALTERNATOR COULD STOP THE BATTERY FROM CHARGING.
2005–2006 Chevrolet Corvette, 2005–2006 Chevrolet Silverado, 2005–2006 GMC Sierra, 2006 Buick Rainier and 11 more
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
2005 Ford Five Hundred, 2005 Ford Freestyle, 2005 Mercury Montego
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
ON CERTAIN MINI VANS, THERE IS A SEAT ADJUSTMENT MECHANISM THAT CONTAINS EXPOSED MOVING COMPONENTS LOCATED AT THE REAR INSIDE EDGE OF THE SECOND ROW SEAT.
2000–2002 SAAB 9-3, 2000–2002 SAAB 9-5
CERTAIN PASSENGER VEHICLES EQUIPPED WITH B205/B235 4-CYLINDER GASOLINE ENGINES AND B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO…
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH THE DRIVER PREFERRED PACKAGE, THE WIRE HARNESS FROM THE DRIVER'S SEAT POWER LUMBAR SUPPORT SWITCH MAY BE ROUTED INCORRECTLY AND COULD BE PINCHED UNDER THE DRIVER SEAT.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.7L ENGINES AND NAG1 AUTOMATIC TRANSMISSIONS, THE AIR CONDITIONER EVAPORATOR CONDENSATE WATER MAY ENTER THE TRANSMISSION AT THE FILL TUBE GROMMET SEAL. THIS CAN RESULT IN SHUDDER DURING TORQUE CONVERTER CLUTCH…
2005 Ford Crown Victoria, 2005 Lincoln Town Car, 2005 Mercury Grand Marquis
ON CERTAIN PASSENGER VEHICLES, THE BATTERY CABLE INCLUDES A FUSIBLE LINK THAT MAY CONTACT AND SUBSEQUENTLY CHAFE ON A #2 CROSS MEMBER ATTACHING BOLT.
2000 Chevrolet C/k Pickups, 2000 Chevrolet Silverado, 2000 Chevrolet Suburban, 2000 GMC Savana and 2 more
SOME PICKUP TRUCKS, VANS, AND SPORT UTILITY VEHICLES EQUIPPED WITH A HYDRAULIC PUMP DRIVESHAFT THAT CAN FRACTURE, RESULTING IN IMMEDIATE LOSS OF HYDRAULIC POWER STEERING ASSIST. ON CERTAIN VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, THE SAME CONDITION…
2002–2003 Chevrolet Trailblazer Ext, 2002–2003 GMC Envoy Xl, 2003 Isuzu Ascender
CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES:…
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR…
1999–2005 Chevrolet Silverado, 1999–2005 GMC Sierra
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A…
2005 Infiniti FX35, 2005 Infiniti FX45, 2005 Nissan Maxima
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE LOWER ANCHORAGE BRACKETS IN THE REAR SEATS DO NOT MEET THE LOCATION REQUIREMENT IN THIS STANDARD. THIS MAY CAUSE…
ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.
2004 Cadillac CTS, 2004 Cadillac SRX
ON CERTAIN PASSENGER VEHICLES, AN INTERACTION BETWEEN THE SENSING AND DIAGNOSTIC MODULE AND VEHICLE'S ELECTRICAL SYSTEM MAY CAUSE THE DRIVER'S FRONTAL AIR BAG AND/OR ROOF-MOUNTED SIDE IMPACT AIR BAG TO DEPLOY WHEN THE IGNITION KEY IS TURNED TO THE "ON"…
THE FRONTAL AIR BAG SYSTEM HAS TWO EXTERNAL IMPACT SENSORS. ON CERTAIN MINI VANS,SOME SENSORS WERE INSUFFICIENTLY SEALED DURING MANUFACTURING. IF WATER ENTERS A SENSOR, CORROSION CAN OCCUR. CORRODED SENSORS COULD SHORT CIRCUIT INTERNALLY. IF SENSORS FAIL, THE…
2005 Ford F-250 Sd, 2005 Ford F-350 Sd, 2005 Ford F-450 Sd, 2005 Ford F-550 Sd
ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
2004–2005 Chevrolet Avalanche, 2004–2005 Chevrolet Express, 2004–2005 Chevrolet Kodiak, 2004–2005 Chevrolet Silverado and 6 more
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
2001–2002 Chevrolet Astro, 2001–2002 GMC Safari
ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER SEATS, THE WIRING UNDER THE FRONT SEATS COULD BE MISROUTED, ALLOWING CONTACT WITH METAL SEAT COMPONENTS.
ON CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG FEATURE, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN…
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A GLASS WIND DEFLECTOR, THE DEFLECTOR, IF IMPACTED BY A PROJECTILE, SUCH AS ROAD DEBRIS, WHILE DRIVING WITH THE WIND DEFLECTOR IN THE UPWARD-TILTED POSITION AT HIGHWAYS SPEEDS, MAY SHATTER AND SEPARATE FROM THE…
2003 Chrysler Town and Country, 2003 Dodge Caravan
ON CERTAIN MINIVANS, THE POWER LIFTGATE (PLG) LATCH MAY NOT ENGAGE THE STRIKER ALLOWING THE LIFTGATE TO OPEN WHILE DRIVING.
ON CERTAIN PASSENGER VEHICLES, FAILURE OF ONE OF THE SIDE BRAKE LIGHTS CAN OCCUR. THE BASE OF THE SOCKET CAN BE SUBJECT TO THERMAL DEFORMATION OVER TIME.
CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO…
ON CERTAIN SPORT UTILITY VEHICLES, THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.
ON CERTAIN PASSENGER VEHICLES, THE CLIP THAT SECURES THE BRAKE PUSHROD TO THE BRAKE PEDAL ARM PIN COULD HAVE BEEN BENT WHEN IT WAS INSTALLED. A BENT CLIP MAY COME OFF, ALLOWING THE BRAKE BOOSTER PUSHROD TO SEPARATE FROM THE BRAKE PEDAL.
2005–2006 Mercedes-Benz C-Class
CERTAIN PASSENGER VEHICLES EQUIPPED WITH SPORT MODEL STEERING WHEELS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." IN CERTAIN LOW RISK AIR BAG DEPLOYMENT TESTS CONDUCTED BY NHTSA, USING AN…
IF CERTAIN PASSENGER VEHICLES ARE PARKED AND THE ENGINE IS OPERATED AT HIGH RPM'S FOR AN EXCESSIVE LENGTH OF TIME, SOME OF THE PARTS AROUND THE EXHAUST SYSTEM CAN MELT AND PRODUCE A VARIETY OF MALFUNCTIONS. PROBLEMS CAUSED BY THE EXCESSIVE HEAT BUILD-UP CAN…
1998–2005 Yamaha XVS11, 1998–2005 Yamaha XVS65
ON CERTAIN MOTORCYLES, THE ORIGINAL REPLACEMENT MOUNTING HARDWARE HOLDING THE PASSENGER SEAT TO THE FENDER COULD BREAK IF THE MOUNTING HARDWARE IS OVER TIGHTENED.
ON CERTAIN PASSENGER VEHICLES, A VAPOR HOSE LOCATED IN THE FUEL TANK MAY NOT HAVE BEEN FORMED CORRECTLY DURING THE MANUFACTURING PROCESS. WHEN THE VEHICLE IS PARKED WITH A FULL FUEL TANK, FUEL MAY FLOW INTO THE VAPOR HOSE, WHICH IS CONNECTED TO A VAPOR…
1997 Ford Crown Victoria, 1997 Mercury MARQUIS
ON CERTAIN PASSENGER VEHICLES BUILT WITH ELECTRONIC TRACTION CONTROL, THE REAR BRAKE LINE MAY CHAFE DUE TO CONTACT BETWEEN IT AND A FLOOR PAN STIFFENING RIB, AND A BRAKE FLUID LEAK MAY OCCUR.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HALOGEN HEADLAMPS MAY EXPERIENCE AN INTERMITTENT AND EVENTUAL TOTAL LOSS OF HEADLAMP FUNCTION.
1993–2001 Mazda 626, 1993–1999 Mazda MX-6, 1993–1997 Ford Probe, 1990–1993 Subaru XT6 and 2 more
CERTAIN SPX FILTRAN FUEL FILTERS WITH A 45-DEGREE ANGLE INLET TUBE, MODEL 800F350-S1, SOLD AS REPLACEMENT FILTERS FOR 1993-1997 FORD PROBE,1993-2001 MAZDA 626 AND MX-6, AND 1983-1994 LOYAL, 3-DOOR COUPE, HATCHBACK, SEDAN, WAGON, BRAT, DL, GL, GL-10, RX, XT,…
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L GASOLINE ENGINE, A FUEL SUPPLY LINE CLAMP LOCATED IN THE ENGINE COMPARTMENT MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE A FUEL LEAK.
2004 Suzuki Forenza, 2004 Suzuki Verona
ON CERTAIN PASSENGER VEHICLES, THE BRAKE LIGHT SWITCH MAY BECOME MISADJUSTED IF AN UPWARD/REARWARD FORCE IS APPLIED TO THE BRAKE PEDAL. IF THIS SHOULD OCCUR, THE BRAKE LIGHT SWITCH WILL NOT FUNCTION PROPERLY, CAUSING THE BRAKE LIGHTS, INCLUDING THE HIGH…
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
2004 Freightliner Century, 2004 Freightliner Columbia, 2004 Freightliner Coronado, 2004 Freightliner Fld and 1 more
ON CERTAIN TRUCK AND MOTOR HOME CHASSIS EQUIPPED WITH I-SHAFTS SUPPLIED BY ZF HEAVY DUTY STEERING, THERE IS A POTENTIAL FOR A FAILURE OF THE FORK/SHAFT CONNECTION.
2002–2004 Honda GL1800, 2002–2004 Honda GL1800A, 2002–2004 Honda VFR800, 2002–2003 Honda CBR1100XX and 3 more
CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT BELT MAY INTERFERE WITH THE MANUAL SEAT BACK RECLINER KNOB AND COULD CAUSE THE FRONT MANUAL SEAT BACK RECLINER TO INADVERTENTLY RELEASE.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THE CHILD RESTRAINT LOWER ANCHORS IN THE CENTER REAR SEATING POSITION ARE LOCATED APPROXIMATELY 90MM BEHIND…
2001–2004 Honda GL1800, 2001–2004 Honda GL1800A
ON SOME MOTORCYCLES, CERTAIN FRAME WELDS DO NOT MEET MANUFACTURING SPECIFICATIONS. HIGH LOADS CREATED WHEN RIDING ON ROUGH ROAD SURFACES OR THROUGH POTHOLES CAN CAUSE THE AFFECTED WELDS TO CRACK.
2004 Buick Rendezvous, 2004 Pontiac Aztek
ON CERTAIN SPORT UTILITY VEHICLES, CONTAMINATION ON IGNITION RELAY CONTACTS CAN CAUSE HIGH RESISTANCE. THIS CAN AFFECT SIGNALS TO THE POWERTRAIN CONTROL MODULE AND, COULD CAUSE INTERMITTENT VEHICLE STALLS AT ANY TIME.
ON CERTAIN MINI VANS EQUIPPED WITH A FOLDING THIRD ROW REAR SEAT, WHEN THE THIRD ROW SEAT IS RAISED FROM ITS STOWED POSITION, IT ENGAGES STRIKER BRACKETS, ONE ON EACH SIDE OF THE SEAT CUSHION. THE FOLD-AWAY STRIKER LOOP IS WELDED TO A MOUNTING BRACKET. THE…
2006 Buick Rainier, 2006 Buick Terraza, 2006 Cadillac Escalade, 2006 Cadillac Escalade ESV and 22 more
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE…
1999–2000 Volkswagen GTI, 1999–2000 Volkswagen Golf
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH GASOLINE ENGINES AND DOUBLE-LAYER FUEL TANKS, TENSION ON THE FUEL SUPPLY LINE MAY CAUSE THE FUEL PUMP SUPPLY NIPPLE TO CRACK WHICH COULD RESULT IN A LEAK.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ELECTRONIC STABILITY PROGRAM (ESP), THE YAW RATE SENSOR MAY BECOME TOO SENSITIVE AND MAY RECALIBRATE INACCURATELY. WHILE DRIVING THE ESP PROGRAM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKE AT ONE…
ON CERTAIN PASSENGER VEHICLES, DUE TO IMPROPER FORGING OF THE LOWER CONTROL ARM, CRACKS MAY OCCUR IN THE BALL JOINT SOCKET.
ON CERTAIN SPORT UTILITY VEHICLES, THE FUEL TANK FILLER TUBE INLET CHECK VALVE MAY NOT FULLY CLOSE AT THE END OF REFUELING. THIS COULD ALLOW SOME FUEL TO ESCAPE FROM THE VEHICLE FILLER NECK.
CERTAIN PASSENGER VEHICLES, THE PEDAL WERE NOT PROPERLY INSTALLED AND MAY COME LOOSE AT THE FLOOR MOUNTING.
2003–2005 Chevrolet Gmt 560, 2003–2005 GMC Gmt 560
CERTAIN MEDIUM DUTY CONVENTIONAL CAB TRUCKS WERE PRODUCED WITH A BODY WIRING HARNESS WITH NO PROTECTIVE CONDUIT IN THE AREA UNDER THE DRIVER'S FEET TO REDUCE THE POTENTIAL FOR HARNESS WEAR. THE BODY WIRING HARNESS INCLUDES SDM WIRING THAT COULD BE DAMAGED…
CERTAIN PASSENGER VEHICLES MAY HAVE A MANUFACTURING FLAW THAT COULD CAUSE THE WHEELS TO CRACK UNDER LONG TERM DRIVING FATIGUE. IF CRACKS OCCUR, WHEEL NOISE AND VIBRATION WILL RESULT AND BECOME PROGRESSIVELY WORSE OVER TIME.
2005–2006 Suzuki VL800, 2005–2006 Suzuki VZ800
ON CERTAIN MOTORCYCLES, THE IGNITION SWITCH WIRING HARNESS MAY HAVE BEEN IMPROPERLY ROUTED AT THE TIME OF PRODUCTION. IF THE WIRING HARNESS IS NOT ROUTED PROPERLY, IT CAN RUB AGAINST THE CLUTCH CABLE/THROTTLE CABLE.
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO,…
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH…
2003 Saturn L200, 2004 Saturn L300, 2002 Saturn LS
CERTAIN WAGONS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE SEAT BELT ANCHOR MAY SEPARATE FROM THE FLOOR OF THE VEHICLE BEFORE HOLDING THE REQUIRED TEST LOAD FOR THE REQUIRED TIME.
2004 Cadillac SRX, 2004 Cadillac XLR, 2004 Pontiac Grand Prix
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IF ONE OF THE TWO ACCELERATOR PEDAL RETURN SPRINGS FAILS AND THE TEMPERATURE IS -22 DEGREES F TO -40 DEGREES F,…
2005 Chevrolet Uplander, 2005 Pontiac Montana, 2005 Saturn Relay
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S…
2005 Buick Rainier, 2005 Chevrolet Trailblazer, 2005 GMC Envoy, 2005 Isuzu Ascender
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING.' THE WINDSHIELD URETHANE BEAD MAY NOT HAVE ADHERED TO THE BODY IN CERTAIN AREAS DURING THE CURE PROCESS.
SOME SPORT UTILITY VEHICLES MAY HAVE FUEL TANKS THAT CONTAIN AN INTERNAL BREATHER PIPE THAT WAS NOT MADE TO SPECIFICATION. THIS COULD RESULT IN EXCESSIVE SWELLING AND CRACKING OF A GROMMET AND SUBSEQUENT DETACHMENT OF THE BREATHER PIPE FROM A CONNECTOR TUBE.…
ON CERTAIN SPORT UTILITY VEHICLES WITH ANTI-LOCK BRAKE SYSTEM (ABS), THE ABS CONTROL MODULE SOFTWARE PROGRAM MAY CAUSE THE REAR BRAKES TO LOCK UP DURING CERTAIN BRAKING CONDITIONS.
1998–2003 Freightliner Mb-45, 1998–2003 Freightliner Mb-55, 1998–2003 Freightliner Xb, 1998–2002 Freightliner Fs-65 and 1 more
CERTAIN 1998-2003 MY FREIGHTLINER FS-65 SCHOOL BUS CHASSIS AND MB-45, MB-55, AND XB SHUTTLE BUS CHASSIS, AND THOMAS BUILT BUS: MVP-ER AND MVP-EF SCHOOL BUS AND NON-SCHOOL BUS MODELS EQUIPPED WITH CUMMINS ISB DIESEL ENGINES AND EQUIPPED WITH FEDERAL-MOGAL 12…
2002–2004 Isuzu Axiom, 2002–2004 Isuzu Rodeo, 2002–2003 Isuzu Rodeo Sport, 2002 Honda Passport
CERTAIN SPORT UTILITY VEHICLES THAT HAVE BEEN EXPOSED TO FUEL CONTAMINATED WITH SILICON MAY DEVELOP SMALL PIN HOLES IN THE FUEL PUMP FEED PORT. SILICON HAS BEEN IDENTIFIED IN THE FUEL SYSTEMS OF AFFECTED VEHICLES AND IN CERTAIN FUEL AVAILABLE IN THE REGION OF…
CERTAIN HONDA ACCESSORY TRAILER HARNESS KIT, P/N 08L91-SCV-102, MANUFACTURED BETWEEN NOVEMBER 24 AND DECEMBER 18, 2004, SOLD FOR USE ON MY 2005 HONDA ELEMENT VEHICLES MANUFACTURED BETWEEN DECEMBER 20, 2004, AND APRIL 29, 2005. THE WIRE HARNESS OF THE TRAILER…
2005 Buick Terraza, 2005 Chevrolet Uplander, 2005 Pontiac Montana, 2005 Saturn Relay
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING…
ON CERTAIN 2-DOOR PASSENGER VEHICLES, THE FRONT PASSENGER OCCUPANT DETECTION SYSTEM (ODS) CONTAINS A FAULTY ELECTRONIC COMPONENT. AS A RESULT, THE ODS WILL NOT FUNCTION PROPERLY AND WILL NOT SUPPRESS FRONT PASSENGER AIR BAG DEPLOYMENT WHEN THE WEIGHT OF AN…
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A NISSAN ACCESSORY TOW HITCH, INADEQUATE QUALITY OF SOME WELDED JOINTS IN THE HITCH ASSEMBLY MAY RESULT IN SEPARATION OF THE HITCH FROM THE VEHICLE WHEN BEING USED TO TOW.
2004 Harley-Davidson Fxdi, 2004 Harley-Davidson Fxdli, 2004 Harley-Davidson Fxdp, 2004 Harley-Davidson Fxdwgi and 1 more
ON CERTAIN MOTORCYCLES, THE THROTTLE CABLES COME INTO CONTACT WITH THE TUNNEL PORTION OF THE FUEL TANK.
ON CERTAIN VEHICLES EQUIPPED WITH AN OCCUPANT CLASSIFICATION SYSTEM (OCS) THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY CERTAIN SMALL CHILDREN SEATED ON THE FRONT EDGE OF THE SEAT AS AN ADULT.
ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.
2006 Harley-Davidson FXD, 2006 Harley-Davidson FXD35, 2006 Harley-Davidson FXDC, 2006 Harley-Davidson Fxdbi and 2 more
ON CERTAIN MOTORCYCLES, THE TRANSMISSION MAY GO INTO A FALSE NEUTRAL POSITION EVEN THOUGH THE NEUTRAL INDICATOR LIGHT IS ILLUMINATED.
ON CERTAIN SPORT UTILITY VEHICLES, FUEL MAY LEAK FROM THE O-RING INTO THE INTERNAL VAPOR CHAMBER LOCATED IN THE FUEL TANK AT FULL TANK CONDITIONS.
2005 Volvo S80, 2005 Volvo XC90
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY…
2006 Ford Expedition, 2006 Lincoln Navigator
ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT AND REAR TIRES ON THE DRIVER'S SIDE OF AFFECTED VEHICLES MAY HAVE BEEN DAMAGED AT THE CENTER TREAD DURING PRODUCTION.
2003–2004 Audi A4, 2003–2004 Audi S4
ON CERTAIN PASSENGER VEHICLES, THERE IS A POSSIBILITY OF XENON HEADLAMP COATING DEGRADATION OVER TIME. THE LUMINOUS TRANSMITTANCE OF THE HEADLAMP MAY DECREASE OVER A PERIOD OF TIME.
2005 Chevrolet Classic, 2005 Pontiac Grand AM
CERTAIN PASSENGER VEHICLES EQUIPPED WITH REAR SUSPENSION KNUCKLE BOLTS THAT ARE NOT TO SPECIFICATION AND COULD FRACTURE UNDER HIGH LOADS THAT CAN OCCUR IN SOME DRIVING CONDITIONS.
2004–2005 Freightliner Cargo, 2004–2005 Freightliner MT55, 2004–2005 Freightliner Mb-55, 2004–2005 Freightliner Mc and 5 more
CERTAIN 2004 AND 2005 FREIGHTLINER VAN, MOTOR HOME, SHUTTLE BUS, AND SCHOOL BUS CHASSIS MANUFACTURED BETWEEN JANUARY 2004 AND MAY 2005. ERRATIC VOLTAGE SUPPLY TO THE FUEL LIFT PUMP CAUSES PREMATURE WEAR OF THE PUMP. THIS PREMATURE WEAR COULD RESULT IN FUEL…
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ELECTRONIC STABILITY PROGRAM (ESP), THE YAW RATE SENSOR MAY BECOME TOO SENSITIVE AND MAY RECALIBRATE INACCURATELY. WHILE DRIVING THE ESP PROGRAM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKE AT ONE…
2005 Cadillac Escalade, 2005 Cadillac Escalade ESV, 2005 Cadillac Escalade Ext, 2005 Chevrolet Avalanche and 6 more
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER…
ON CERTAIN PASSENGER VEHICLES, A HOSE CLAMP THAT SECURES THE POWER STEERING FLUID COOLING HOSE TO THE POWER STEERING FLUID COOLER MAY NOT PROVIDE SUFFICIENT CLAMPING FORCE FOR THIS CONNECTION.
ON CERTAIN SPORT UTILITY VEHICLES, A HEAT BUILDUP IN THE EXHAUST SYSTEM CAN OCCUR.
ON CERTAIN MOTORCYCLES, A DAMAGED CONNECTOR IN THE HANDLEBAR MOUNTED HEADLIGHT SWITCH MAY CAUSE THE HEADLIGHT TO FLICKER AND EVENTUALLY FAIL.
2003–2005 Chevrolet Kodiak, 2003–2005 GMC Topkick
CERTAIN 2003-2005 MODEL YEAR 4500/5500 SERIES CHEVROLET KODIAK, SCHOOL BUS CHASSIS, AND GMC TOPKICK VEHICLES; AND 2003-2004 MODEL YEAR GMC SCHOOL BUS CHASSIS VEHICLES EQUIPPED WITH AN 8.1L ENGINE AND HYDROMAX BRAKE SYSTEM. THE POWER STEERING HOSE MAY COME…
2005 Ford F-650 Sd, 2005 Ford F-750
ON CERTAIN MEDIUM DUTY CHASSIS CAB VEHICLES EQUIPPED WITH HYDRAULIC BRAKES, THE DRIVE LINE PARK BRAKE ANCHOR BOLT MAY BE SUSCEPTIBLE TO FATIGUE LOADING. THE BOLT COULD FRACTURE OVER TIME DUE TO INSUFFICIENT CLAMP LOAD AS A RESULT OF IMPROPER ANCHOR BOLT…
ON CERTAIN SPORT UTILITY VEHICLES, THE PARKING BRAKE LEVER RATCHET PAWL WAS NOT PROPERLY MANUFACTURED AND MY DAMAGE THE TEETH OF THE PARKING BRAKE LEVER RATCHET. DAMAGED PARKING BRAKE LEVER RATCHET TEETH MAY PREVENT THE PARKING BRAKE FROM ENGAGING OR MAY…
2003–2004 Suzuki AN650 Burgman, 2004 Suzuki AN400, 2003 Suzuki AN400 Burgman
ON CERTAIN SCOOTERS, IF THE IGNITION SWITCH IS NOT FULLY TURNED FROM THE 'OFF' TO THE 'ON' POSITION, THERE MAY BE UNSTABLE CONTACT BETWEEN THE IGNITION SWITCH CONTACTS. THIS CAN CAUSE ARCING IN THE IGNITION SWITCH.
CERTAIN PICKUP TRUCKS EQUIPPED WITH BOTH VEHICLE STABILITY CONTROL (VSC) AND THE TRD DUAL EXHAUST SYSTEMS. THE TRD DUAL EXHAUST SYSTEM MET ALL CLEARANCE SPECIFICATIONS ON MODELS WITHOUT VSC, HOWEVER THE DRIVER'S SIDE EXHAUST LOCATED IN A POSITION WHERE…
ON CERTAIN PASSENGER VEHICLES, THE STEERING YOKE WAS NOT WELDED TO THE STEERING SHAFT. IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT THE YOKE MAY COME OFF FROM THE SHAFT, AND COULD RESULT IN A LOSS OF VEHICLE STEERING CONTROL.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS" THE VEHICLES' TIRE AND LOADING INFORMATION LABEL OR PLACARD ON THE DRIVER'S SIDE B-PILLAR INCORRECTLY INDICATES THE…
2006 Mazda B-Series Truck, 2006 Mazda Tribute
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE APPLIED TO THE OUTPUT SHAFT GEAR.
2004–2005 Freightliner Business Class M2
CERTAIN 2004 AND 2005 THOMAS BUILT C2 SCHOOL BUSES AND FREIGHTLINER BUSINESS CLASS M2 HEAVY TRUCKS MANUFACTURED BETWEEN JUNE 2004 AND MARCH 2005. THE ANCHOR/PIVOT BOLT SUPPLIED WITH THE PARK BRAKE IS DEFECTIVE AND COULD FATIGUE FRACTURE PREMATURELY, RESULTING…
ON CERTAIN PASSENGER VEHICLES, ONE OF FOUR SEALS INSIDE THE MASTER CYLINDER MAY HAVE BEEN INSTALLED IMPROPERLY. AS A RESULT, THE MASTER CYLINDER MAY UNEXPECTEDLY BY-PASS HYDRAULIC BRAKING FORCE PRESSURE AND ALLOW A LONGER THAN NORMAL PEDAL STROKE.
ON CERTAIN SPORT UTILITY VEHICLES, THE PARKING BRAKE LEVER RATCHET PAWL WAS NOT PROPERLY MANUFACTURED AND MY DAMAGE THE TEETH OF THE PARKING BRAKE LEVER RATCHET. DAMAGED PARKING BRAKE LEVER RATCHET TEETH MAY PREVENT THE PARKING BRAKE FROM ENGAGING OR MAY…
2004–2006 Winnebago Itasca Spirit, 2005–2006 Winnebago Aspect, 2004–2005 Winnebago Minnie, 2005–2006 Winnebago Minnie Winnie and 1 more
ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE FASTENERS HOLDING THE FUEL TANK MOUNTING STRAPS MAY NOT HAVE BEEN PROPERLY TIGHTENED, ALLOWING THE POSSIBILITY FOR THE FUEL TANK TO LOOSEN AND FALL.
2001–2004 Freightliner Business Class M2
ON CERTAIN TRUCKS AND FIRE TRUCKS EQUIPPED WITH KYS 4735-43782-02 ENGINE COOLING FANS AND BUILT ON CATERPILLAR 3126, C7, MBE906, MBE926, OR CUMMINS ISC ENGINES, THE STEEL FAN INSERT ON THE COOLING FANS CAN CRACK.
ON CERTAIN PASSENGER VEHICLES, THERE IS A POSSIBILITY THAT THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN THE PARTIALLY DEPRESSED POSITION DUE TO INADEQUATE CLEARANCE BETWEEN THE ACCELERATOR PEDAL LINKAGE AND A PLASTIC PAD EMBEDDED INTO THE VEHICLE'S…
2005 Freightliner American Lafrance, 2005 Freightliner Century St, 2005 Freightliner Columbia, 2005 Freightliner Sterling Acterra and 1 more
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH ACCURIDE ALUMINUM WHEELS, THE WHEELS WERE NOT PROPERLY PRE-STRESSED. THIS ALLOWS CRACKS TO DEVELOP OVER TIME.
2005 Chevrolet Silverado, 2005 GMC Sierra
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
ON CERTAIN MOTORCYCLES, THE DEFECT INVOLVES A WATER LEAK AROUND THE FUEL PUMP THAT IS INTEGRATED WITHIN THE FUEL TANK. AN O-RING SEAL ATTACHED TO THE PUMP'S ELECTRONIC HOUSING DOES NOT MEET SPECIFICATIONS AND WATER CAN BYPASS THIS SEAL AND CONTACT THE PUMP…
CERTAIN SPORT UTILITY VEHICLES MAY EXPERIENCE A FUEL LEAK FROM FUEL TUBES NEAR THE FUEL TANK DUE TO AN INTERFERENCE FIT WITH THE VEHICLE FLOOR PANEL.
2005 Mitsubishi Endeavor, 2005 Mitsubishi Galant
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ANTI-LOCK BRAKES, THE BRAKE MASTER CYLINDER, WHICH CONTROLS THE FLUID PRESSURE TO THE VEHICLE'S BRAKES, MAY ALLOW BRAKE FLUID TO BYPASS INTERNALLY DURING STOPPING.
2004–2005 Keystone Everest, 2004 Keystone Montana
ON CERTAIN FIFTH WHEEL TRAILERS EQUIPPED WITH 16", 6-BOLT ALUMINUM WHEEL OPTION WITH 5.5" BOLT CIRCLES, FOREIGN MATERIAL MAY BE PRESENT IN THE 'CLAMP JOINT' (MATING SURFACE BETWEEN THE WHEEL AND HUB FACE. THIS CAN HINDER THE PROPER TORQUE OF THE LUG NUTS IF…
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS" THE REQUIREMENTS FOR LOCATION AND INSTRUCTIONS FOR PROPERLY ATTACHING CHILD RESTRAINTS. THE OWNER MANUAL…
CERTAIN PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND OPTIONAL FABRIC FRONT CAPTAIN'S CHAIRS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THESE VEHICLES WERE BUILT WITH AN…
ON CERTAIN MEDIUM DUTY CHASSIS CABS, THE CAB ENTRY STEP PLATFORMS ON EITHER SIDE OF THE VEHICLE MAY CRACK DURING NORMAL USE.
2005–2006 Fleetwood Bounder Diesel, 2005–2006 Fleetwood Discovery, 2005–2006 Fleetwood Excursion, 2005–2006 Fleetwood Expedition and 1 more
CERTAIN DIESEL CLASS A MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE MANUFACTURERS' TOW HITCH RECEIVER INFORMATION LABEL WAS PRINTED WITH THE INCORRECT WEIGHT CARRYING CAPACITY VALUE AND THE INCORRECT TONGUE WEIGHT VALUE.
2006 Harley-Davidson FLHX, 2006 Harley-Davidson Flhxi
CERTAIN MOTORCYCLES WERE BUILT WITH MIRRORS THAT WERE IMPROPERLY LOCATED ON THE INNER FAIRING.
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE…
2005 Keystone Springdale, 2005 Keystone Sprinter, 2005 Keystone Tail-Gator
ON CERTAIN TRAVEL TRAILERS AND FIFTH WHEEL RECREATIONAL VEHICLES, DURING PRODUCTION IT WAS DISCOVERED THAT THE FURNACE MAY NOT BE SECURED AND THE GASKET THAT SEALS THE FURNACE TO THE FLOOR DUCT SYSTEM MAY BE MISSING.
CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN…
ON CERTAIN MOTORCYCLES, DAMAGE TO THE OIL SEAL OCCURRED DURING FINAL ASSEMBLY. ONCE DAMAGED SOME OF THE OIL IN THE DRIVE UNIT COULD ESCAPE PAST THE SEAL.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3.3 LITER ENGINES AND ELECTRONIC STABILITY CONTROL (ESC), THE ESC MAY HAVE BEEN PROGRAMMED TO BE OVERSENSITIVE TO THE ONSET OF OVERSTEERING WHILE DRIVING ON BANKED CURVES, CAUSING INADVERTENT APPLICATION OF THE…
2006 Land Rover LR3, 2006 Land Rover Range Rover, 2006 Land Rover Range Rover Sport
CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN MANUFACTURED WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.
2002–2005 Land Rover Freelander
ON CERTAIN FIVE DOOR SPORT UTILITY VEHICLES, IT IS POSSIBLE TO OPERATE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR WHEN THE CHILD SAFETY LEVER IS IN THE "ON" POSITION.
2005 Acura TL, 2005 Honda Accord, 2005 Honda Odyssey
ON CERTAIN PASSENGER VEHICLES, A LOOSE TERMINAL IN THE MAIN FUSE BOX MAY CAUSE THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.
2004 Freightliner Century St, 2004 Freightliner Columbia, 2004 Freightliner Coronado, 2004 Freightliner Fld
ON CERTAIN TRUCKS EQUIPPED WITH 3RD GENERATION CONMET ALUMINUM WHEELS, THE DRUM MOUNTING FLANGE ON THE CONMET TRUTURN BRAKE DRUM MAY HAVE BEEN MANUFACTURED WITH A TAPER FROM THE PILOT HOLE TO THE BARREL OF THE DRUM.
2002–2004 Freightliner Columbia
ON CERTAIN TRUCKS EQUIPPED WITH SEATS BUILT BY GRA-MAG, THE SEAT PIVOT BOLTS CAN LOOSEN AND POSSIBLY FRACTURE OR DISLODGE, CAUSING THE SEAT BACK TO FAIL TO PROVIDE FULL SUPPORT TO THE DRIVER'S BACK.
CERTAIN FREIGHTLINER CUSTOM CHASSIS FS-65 SCHOOL BUS CHASSIS AND FB-65 SHUTTLE BUS CHASSIS EQUIPPED WITH CATERPILLAR C7 ENGINES AND REVISED COOLING PACKAGES AND MANUFACTURED BETWEEN JANUARY 24, 2004, AND JUNE 15, 2005. THE FRONT HYDRAULIC LINE MAY RUB THROUGH…
ON CERTAIN PASSENGER VEHICLES, THE TIRES COULD HAVE BEEN DAMAGED WHEN THE TIRES WERE MOUNTED ON THE WHEELS. IN CERTAIN CIRCUMSTANCES, THE BEAD AREA OF THE TIRE MAY HAVE BEEN DAMAGED.
2005 Harley-Davidson FLHPEI, 2005 Harley-Davidson FLHPI, 2005 Harley-Davidson Flhtpi
ON CERTAIN POLICE AND ESCORT MOTORCYCLES, THE ANTI-LOCK BRAKE SYSTEM (ABS) LINES MAY HAVE BEEN REVERSED DURING INSTALLATION PROCEDURES.
ON CERTAIN PASSENGER VEHICLES, A WIRING HARNESS CONDITION EXISTS THAT MAY DEACTIVATE THE PASSENGER SIDE FRONTAL AIR BAG EVEN UNDER CIRCUMSTANCES WHEN IT SHOULD REMAIN ACTIVATED.
2004 Freightliner Business Class M2
CERTAIN MY 2004 FREIGHTLINER BUSINESS CLASS M2 AND THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BETWEEN JULY 26 AND OCTOBER 29, 2004, EQUIPPED WITH A CATERPILLAR C-7 ENGINE AND BORG-WARNER KYS 4735 35480 55 ENGINE FAN. THE FAN SHROUD MAY BE DRAWN…
2003–2006 Volvo Vnl, 2003–2006 Volvo Vnm
CERTAIN TRUCKS EQUIPPED WITH FRONT STEER AXLE AIR SUSPENSION MAY DEVELOP A FRONT WHEEL WOBBLE WHEN THE TIRES BECOME WORN.
2004–2006 Winnebago Journey, 2003–2005 Winnebago Adventurer, 2005 Winnebago Voyage
ON CERTAIN MOTOR HOMES, THE ROOF VENT FOR THE OPTIONAL 4-DOOR REFRIGERATOR WAS INCORRECTLY LOCATED.
2005 Mitsubishi Lancer Evolution
ON CERTAIN PASSENGER VEHICLES, THE TURBO CHARGER COOLANT HOSE WAS INCORRECTLY MANUFACTURED, AND MAY ALLOW COOLANT LEAKAGE.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN FITTED WITH A DEFECTIVE BRAKE BOOSTER ASSEMBLY.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH THE OPTIONAL SIDE CURTAIN AIR BAG, THE CURTAIN FASTENERS MAY NOT HAVE BEEN PROPERLY TIGHTENED.
2005 Freightliner Argosy, 2005 Freightliner Business Class M2, 2005 Freightliner Century St, 2005 Freightliner Columbia
CERTAIN 2005 THOMAS BUILT FS-65 AND C-2 SCHOOL BUSES AND 2005 FREIGHTLINER ARGOSY, COLUMBIA, CENTURY ST, AND M2 BUSINESS CLASS TRUCKS MANUFACTURED BETWEEN JUNE 4 AND JULY 8, 2005. THE SPINDLES IN THE REAR AXLE HOUSING WERE OVERHEATED DURING THE HEAT TREATMENT…
2005 Triumph Daytona 955I, 2005 Triumph Speed Triple, 2005 Triumph Sprint ST, 2005 Triumph Sprint St Abs
ON CERTAIN MOTORCYCLES, THE LOWER BY-PASS COOLANT HOSE CAN RUPTURE.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, 'TIRE SELECTION AND RIMS.' THE STANDARD REQUIRES THAT THE RELATIONSHIP BETWEEN THE TIRE SIZE AND MAXIMUM TIRE PRESSURE BE INDICATED ON THE…
2004–2006 Volvo Vnl, 2004–2006 Volvo Vnm
CERTAIN HEAVY DUTY TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE TIRE SIZE DESIGNATION ON THE CERTIFICATION LABEL IS NOT SHOWN.
2005–2006 Keystone Cougar, 2005–2006 Keystone Mountaineer, 2005–2006 Keystone Sprinter, 2005–2006 Keystone Tail-Gator
ON CERTAIN TRAVEL TRAILERS AND FIFTH WHEEL RECREATIONAL VEHICLES EQUIPPED WITH TREDIT 16" CHROME WHEELS, THE RIMS MAY HAVE POOR WELD QUALITY AND INSUFFICIENT PRESS FIT BETWEEN THE WHEEL RIM AND DISC.
1999–2005 Suzuki Grand Vitara, 2001–2006 Suzuki XL7
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE…
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH ACCURIDE ALUMINUM WHEELS, THE WHEELS WERE NOT PROPERLY PRE-STRESSED. THIS ALLOWS CRACKS TO DEVELOP OVER TIME.
ON CERTAIN SCOOTERS, THE FUEL PUMP RETAINING RING MAY HAVE BEEN IMPROPERLY INSTALLED RESULTING IN IMPROPER SEATING OF THE FUEL PUMP RETAINING RING ON THE FUEL TANK DUE TO MISALIGNMENT OF THE THREADS.
ON CERTAIN TRAVEL AND FIFTH WHEEL TRAILERS, THE WIRING FROM THE BATTERY CIRCUIT BREAKERS IS WIRED ON THE UNPROTECTED SIDE OF THE CIRCUIT BREAKER.
2004–2005 Fleetwood American Eagle, 2004–2005 Fleetwood American Tradition, 2005 Fleetwood Revolution Le
ON CERTAIN CLASS A MOTOR HOMES, A PNEUMATIC LINE CAN BECOME PINCHED BETWEEN THE HYDRAULIC FILTER AND A COMPARTMENT DOOR STRUT. THE CHAFFING CAUSED BY OPENING AND CLOSING OF THE COMPARTMENT DOOR CAN CAUSE THE FILTER TO RUPTURE AND RESULT IN A HYDRAULIC FLUID…
2005 Chevrolet Suburban, 2005 Chevrolet Tahoe, 2005 GMC Yukon, 2005 GMC Yukon XL
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE PEDAL PUSHROD RETAINER MAY BE MISSING. IF THE RETAINER IS MISSING, THE BRAKE BOOSTER PUSHROD COULD DISENGAGE FROM THE BRAKE PEDAL.
ON CERTAIN PASSENGER VEHICLES, THE ACCELERATOR PEDAL ARMS WERE INCORRECTLY ASSEMBLED BY THE SUPPLIER. THE CLEARANCE BETWEEN THE ACCELERATOR PEDAL AND THE BRAKE PEDAL MAY BE REDUCED. THIS CONDITION CAN INCREASE THE RISK OF BOTH PEDALS BEING OPERATED AT THE…
2004 Freightliner American Lafrance, 2004 Freightliner Freightliner, 2004 Freightliner Sterling, 2004 Freightliner Western Star
CERTAIN FREIGHTLINER TRUCKS AND THOMAS SCHOOL BUSES EQUIPPED WITH HOLLAND/NEWAY AIR SUSPENSION SYSTEMS, A TRANSVERSE BEAM CASTING MAY FRACTURE UNDER NORMAL LOADS. IF A CASTING BREAKS WHEN THE VEHICLE IS TRAVELING ON A ROADWAY THERE IS THE POTENTIAL FOR PIECES…
2004 Ducati ST3, 2004 Ducati ST4S, 2004 Ducati ST4S Abs
ON CERTAIN MOTORCYCLES, THE AIR BOX BREATHER HOSE MAY COME IN CONTACT WITH THE HORIZONTAL CYLINDER EXHAUST PIPE.
2002–2004 Forest River Forest River
ON CERTAIN MOTOR HOMES EQUIPPED WITH TREDIT WHEELS, THE RIMS MAY HAVE POOR WELD QUALITY AND INSUFFICIENT PRESS FIT BETWEEN THE WHEEL RIM AND DISC.
ON CERTAIN PASSENGER VEHICLES, THE POWER STEERING PUMP PULLEY MAY SEPARATE FROM THE POWER STEERING PUMP DUE TO INADEQUATE WALL THICKNESS OF THE PULLEY.
2006 Land Rover LR3, 2006 Land Rover Range Rover Sport
CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN BUILT WITH A INCORRECTLY BUILT SEAT BELT BUCKLE MOUNTINGS.
2005 BMW R 1200 GS, 2005 BMW R 1200 RT, 2005 BMW R 1200 ST
ON CERTAIN MOTORCYCLES, EXPOSURE OF THE THROTTLE HOUSING TO ROAD DEBRIS COULD FALL AND BECOME CAUGHT BETWEEN THE THROTTLE-BODY AND THE ENGINE BLOCK.
2006 Freightliner Business Class M2, 2006 Freightliner Century, 2006 Freightliner Columbia, 2006 Freightliner Coronado
ON CERTAIN TRUCKS AND MOTOR HOME CHASSIS, THE TOP FLANGE OF THE FRONT AXLE I-BEAM MAY FATIGUE AND FRACTURE.
CERTAIN VAN CHASSIS WITH SINGLE REAR TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE REAR TIRE RATING WAS INCORRECTLY ENTERED IN THE…
CERTAIN VALLEY INDUSTRIES HITCH-CLASS III RECEIVER TRAILER HITCHES P/N 82850 MANUFACTURED BETWEEN MARCH AND SEPTEMBER 2005 SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR 2005 NISSAN XTERRA PASSENGER VEHICLES. DUE TO INSUFFICIENT WELD STRENGTH, UNDER CERTAIN…
2004–2005 Fleetwood Prowler, 2004–2005 Fleetwood Terry, 2004–2005 Fleetwood Wilderness
CERTAIN FIFTH WHEEL TRAVEL TRAILERS HAVE MISSING WELDS ON THE CHASSIS CROSS-MEMBERS.
2006 Jaguar S-Type, 2006 Jaguar XJ
CERTAIN SEDANS MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.
ON CERTAIN SPORT UTILITY VEHICLES, THE FUEL RETURN HOSE BETWEEN FUEL TANK AND RETURN LINE CAN BE PERMEATED WITH FUEL. THIS SITUATION RESULTS FROM THE EXPANSION AND CONTRACTION OF THE HOSE UNDER PRESSURE CAUSING MICROCRACKS IN THE HOSE MATERIAL.
2005 Ford F-450 Sd, 2005 Ford F-550 Sd
ON CERTAIN CHASSIS CAB TRUCKS, THE STEERING GEAR MAY HAVE SOME GEARS WITH A GEAR PISTON THAT WAS ASSEMBLED WITH AN INCORRECT RE-CIRCULATING BALL TUBE RETAINER. AN INCORRECT RETAINER MAY RESULT IN AN IMPROPERLY RETAINED RE-CIRCULATING BALL TUBE, WHICH MAY NOT…
2005–2006 Fleetwood Jamboree, 2005–2006 Fleetwood Tioga
CERTAIN CLASS C MOTOR HOMES BUILT ON CHEVROLET CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE FEDERAL CERTIFICATION TAG WAS PRINTED WITH THE INCORRECT REAR GROSS AXLE WEIGHT RATING (GAWR) AND INCORRECT CARGO CARRYING CAPACITY…
ON CERTAIN MOTORCYCLES, THE OIL COOLER DELIVERY AND RETURN HOSE COULD LEAK OIL.
ON CERTAIN PASSENGER VEHICLES, THE STEERING TIE RODS MAY HAVE A MANUFACTURING FLAW THAT AFFECTS THE METALLURGY.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ELECTRONIC STABILITY PROGRAM (ESP), THE YAW RATE SENSOR MAY BECOME TOO SENSITIVE AND MAY RECALIBRATE INACCURATELY. WHILE DRIVING THE ESP PROGRAM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKE AT ONE…
ON CERTAIN MOTOR HOMES WITH THE OPTIONAL GALLEY UPGRADE PACKAGE, KNIVES STORED IN THE GALLEY KNIFE HOLDER MAY INTERFERE WITH THE PROPANE GAS LINE TO THE STOVE.
ON CERTAIN MOTORCYCLES, THERE COULD BE A PROBLEM WITH THE ROUTING OF THE INTEGRAL ANTI-LOCK-BRAKE SYSTEM (IABS) SENSOR CABLE IF SERVICE HAS BEEN PERFORMED ON THE MOTORCYCLE, FOR EXAMPLE, A FRONT TIRE CHANGE.
ON CERTAIN PASSENGER VEHICLES, THE PARKING LEVER RATCHET PAWL WAS NOT PROPERLY MANUFACTURED AND MAY DAMAGE THE TEETH OF THE PARKING LEVER RATCHET. DAMAGED PARKING BRAKE LEVER RATCHET TEETH MAY PREVENT THE PARKING BRAKE FROM ENGAGING OR MAY ALLOW THE PARKING…
2006 Acura TL, 2006 Honda Accord
ON CERTAIN PASSENGER VEHICLES, ON THE FRONTAL AIRBAG SYSTEM WHERE THE TWO EXTERNAL IMPACT SENSORS IS MOUNTED, NEAR THE FRONT HEADLIGHTS THE FRONT IMPACT SENSOR BOLTS WERE NOT PROPERLY TORQUED.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.
2005 Harley-Davidson FLHTCSE2, 2006 Harley-Davidson Flhtcuse
CERTAIN MOTORCYCLES MAY HAVE FRONT BRAKE LINES WHICH COULD LEAK DUE TO A MANUFACTURING DEFECT.
2005 Hyundai Elantra, 2005 Hyundai Tiburon
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH THREADED PORTIONS OF THE STEERING GEARBOX ASSEMBLY'S LEFT AND RIGHT INNER BALL JOINT ASSEMBLIES THAT CONTAIN INTERNAL CRACKS IN THE MATERIAL STRUCTURE.
2003–2004 Chevrolet W3500, 2003–2004 Chevrolet W4500, 2003–2004 GMC W3500, 2003–2004 GMC W4500 and 4 more
ON CERTAIN TRUCKS EQUIPPED WITH RPO IK9, DUE TO INSUFFICIENT DURABILITY AND TESTING, THE FUEL SWITCHING MANIFOLD SOLENOIDS LACK WATER OR SALT INTRUSION RESISTANCE, WHICH CAN LEAD TO FAILURE OF ONE OR MORE SOLENOIDS. FUEL SWITCHING MANIFOLD SOLENOID FAILURE…
2000–2003 Freightliner Freightliner
CERTAIN MY 2000-2003 FREIGHTLINER, THOMAS MVP SCHOOL BUS AND WESTERN STARS TRUCKS MANUFACTURED BETWEEN NOVEMBER 19, 2000, AND MARCH 30, 2005, AND EQUIPPED WITH WEBASTO COOLANT HEATERS, MODEL DBW 2010, ASSEMBLED WITH WEBASTO BURNER TUBES, P/N 303046/26533A.…
2005–2006 BMW 5 Series, 2005–2006 BMW 6 Series, 2005–2006 BMW X5
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.
CERTAIN MOTOR HOMES BUILT ON 24,000-LB GROSS VEHICLE WEIGHT RATING (GVWR)WORKHORSE CHASSIS WITH 235/80R22.5G XRV TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER…
2005 Honda Odyssey, 2005 Honda Pilot
ON CERTAIN MINIVANS AND SPORT UTILITY VEHICLES, THE STEERING COLUMN MAY BE INCORRECTLY ASSEMBLED, WHICH COULD RESULT IN A LOSS OF STEERING CONTROL.
2006 Forest River Lexington, 2006 Forest River Lexington GT
ON CERTAIN CLASS B MOTOR HOMES, IF THE AXLE BOTTOMS OUT AGAINST THE RUBBER SUSPENSION SNUBBERS, IT IS POSSIBLE THAT THE "U" BOLTS THAT HOLD THE SPRINGS TO THE REAR AXLE CAN PENETRATE THE STEEL TUBE AND COME INTO CONTACT WITH THE STEEL LIQUID PROPANE (LP)…
2005–2006 Freightliner Business Class M2
ON CERTAIN TRUCKS EQUIPPED WITH FONTAINE MODIFICATION RIGHT HAND STEERING CONTROL AND EQUIPPED WITH SIT DOWN DUAL DRIVE CONVERSIONS, THE PINCH BOLT THAT SECURES THE LOWER STEERING SHAFT CONNECTION TO THE LH MITER BOX MAY HAVE BEEN IMPROPERLY TORQUED CAUSING…
2006 Winnebago Aspect, 2006 Winnebago Journey, 2006 Winnebago Minnie Winnie, 2006 Winnebago Outlook and 5 more
ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC STEPS, THE STEPS MAY HAVE BEEN MANUFACTURED WITH DEFECTIVE STEP CONTROL UNITS.
2003–2005 Fleetwood American Dream, 2003–2005 Fleetwood American Eagle, 2003–2005 Fleetwood American Heritage, 2003–2005 Fleetwood American Tradition
ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.
2004–2005 Fleetwood Prowler, 2004–2005 Fleetwood Terry, 2004–2005 Fleetwood Wilderness
ON CERTAIN FIFTH WHEEL TRAILERS, THE PROPANE GAS LINES THAT RUN THROUGH THE FLOOR OF THE SLIDE OUT ROOM PENETRATE THE FLOOR TOO FAR FROM THE OUTSIDE WALL CAUSING THE POTENTIAL FOR PINCHED LINES DURING SLIDE OUT ROOM OPERATION.
ON CERTAIN FIFTH WHEEL TRAILERS EQUIPPED WITH TREDIT WHEELS, THE WHEELS MAY DEVELOP A SEPARATION AT THE WELD BETWEEN THE CENTER PORTION OF THE WHEEL AND THE OUTER RIM.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER REAR SEATS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE LOWER ANCHORAGE BRACKETS IN THE REAR SEATS DO NOT MEET THE LOCATION…
Vehicle counts are the manufacturer's estimates in its report to NHTSA. Only makes covered by this site are counted, and a recall is counted in the year it was filed.